Invacare M71 service manual Seat Assembly, Removing/Installing the Adjustable Height Tubes

Page 4

TABLE OF CONTENTS
TABLE OF CONTENTS
SECTION 4—SEAT ASSEMBLY	30
Removing/Installing the Seat Assembly	30
Removing Seat	30
Installing Seat	30
Adjusting the Seat Height	31
Removing/Installing the Adjustable Height Tubes	33
Adjustable ASBA Seat Service Procedures	35
Removing/Installing the Seat Pan	35
Adjusting the Seat Width	35
Adjusting the Seat Depth	36
Removing/Installing Side Rails	38
Replacing the Seat Frame	40
Removing/Installing the Back Canes	41
Replacing Seat Positioning Strap	42
Adjusting the Back Angle	43
ASBA Seat Service Procedures	44
Removing/Installing the Seat Pan	44
Changing the Seat Width/Depth	45
Replacing the Seat Frame	45
Replacing the Seat Positioning Strap	46
Removing/Installing the Back Upholstery	46
Removing/Installing/Changing the Back Cane Height	46
Adjusting the Back Angle	50
Van Seat Service Procedures	51
Adjusting the Back Angle	51
Adjusting the Seat Position on Van Seat Frame	51
Adjusting the Van Seat Back Depth	53

Part No 1118377

4

Pronto® M71™

Image 4

Contents Pronto M71 Reference Documents Reference DocumentsDocument Part Number Table of Contents Seat Assembly Removing/Installing the Adjustable Height TubesArms WheelsSHROUDS/FRAME Front RIGGINGS/FOOTBOARDMotors Limited Warranty BATTERIES/CHARGERController and Joystick DISASSEMBLING/ASSEMBLING the M71Special Notes Signal Word MeaningSeat Positioning Strap Trro and Trbkts Warnings Wiring Label on M71 Standard with Battery Covers Label LocationsOne of these battery wiring Labels is in this location M71 with PTO+ Labels Typical Product Parameters Typical Product ParametersInch VAN Asba General Guidelines Repair or Service InformationOperation Information Tire Pressure ElectricalBatteries Grounding InstructionsEMI Information EMI InformationEMI Information Safety Inspection Checklists Safety INSPECTION/ TroubleshootingInspect/Adjust Troubleshooting Electrical TroubleshootingDisplay Description Definition Possible Solution Diagnostics CodeSUB Code E05 Symptom SolutionsJS REV TOO Large Troubleshooting Common Troubleshooting Motor/Gearbox/BrakeSymptom Probable Cause Solutions WheelsTion. Replace motor or gearbox if contamination Troubleshooting Battery Troubleshooting Battery ChargerChecking Battery Charge Level DON’TField Load Test Motor Testing Battery QualitySeat Assembly Removing/Installing the Seat AssemblyInstalling Seat Removing SeatAdjusting the Seat Height Removing/Installing the Seat AssemblyVAN Seat with NON-HEMI Front Rigging Wheelchair Equipped with Available Mounting Holes forVAN Seat with Hemi Front Rigging or Footboard Removing/Installing the Adjustable Height Tubes Asba Seat with Footboard Or Front Riggings NON-HEMI or HemiRemoving/Installing the Adjustable Height Tubes Adjustable Asba Seat Service Procedures Removing/Installing the Seat PanAdjusting the Seat Width Seat WidthAdjusting the Seat Depth Frame Size Seat Depth RangeSeat Depth DISTANCE* in Inches Removing/Installing Side Rails Adjusting the Seat DepthRemoving/Installing Side Rails Replacing the Seat Frame Replacing the Seat FrameRemoving/Installing the Back Canes Removing/Installing the Back Canes Replacing Seat Positioning StrapAdjusting the Back Angle 11 Adjusting the Back AngleAsba Seat Service Procedures 12 Removing/Installing the Seat PanChanging the Seat Width/Depth Replacing the Seat Frame 13 Replacing the Seat FrameReplacing the Seat Positioning Strap Back UpholsterySeat Assembly Seat Assembly 15 Removing/Installing the Back Upholstery Back Height16 Adjusting the Back Angle Angle Back Cane Mounting Hole Back Angle Plate HoleVan Seat Service Procedures Adjusting the Seat Position on Van Seat Frame18 Adjusting the Seat Position on Van Seat Frame Adjusting the Van Seat Back Depth Back Depth Seat SizeArm Service Procedures for Van Seat Removing/Installing Van Seat ArmAdjusting Van Seat Arm Width ArmsAdjusting Van Seat Arm Angle Adjusting Van Seat Arm HeightArmrest Pad Armrest Insert Mounting Screw Arm Post Washers Locknut Removing/Installing Flip Back Armrest Arm Service Procedures for Asba or Adjustable Asba SeatAdjusting the Flip Back Armrest Adjusting the Flip Back Armrest Wheels Replacing the Front/Rear CastersAdjusting Caster Assembly Adjusting Caster AssemblyRemoving/Installing the Front/Rear Caster Assemblies Removing/Installing the Front Headtube AssemblyInstalling RemovingInstalling the Drive Wheel Removing/Installing the Drive WheelRemoving the Drive Wheel Removing/Installing the Drive Wheel Inner Rim Installing/Removing Front Riggings Front RIGGINGS/ FootboardModel PHWH93 Front Riggings Adjusting Footrest HeightModel PH904A and PHAL4A Front Riggings Adjusting/Replacing Telescoping Front Rigging Supports Replacing Heel LoopsRaising/Lowering Elevating Front Riggings Van SeatStandard Position Inch OUT Inches OUT Adjustable Asba Seat Asba SeatRemoving/Installing the Footboard Assembly Angle Adjustment Angle/Depth/Height Adjustment of the Footboard AssemblyDepth Adjustment Height Adjustment 11 Depth Adjustment/Height AdjustmentRemoving/Installing the Shrouds SHROUDS/FRAMERemoving/Installing the Shrouds Disassembling/Reassembling the Side Frame Assembly Removing/Installing the Pivot TubeDisassembling/Reassembling the Side Frame Assembly Removing/Installing the SureStep Springs Removing/Installing the SureStep Springs Removing/Installing the Motor MotorsRemoving/Installing the Motor Release Lever Removing/Installing the Motor Release LeverReplacing Internal Motor Brushes Replacing Internal Motor Brushes Inspecting/Replacing External Motor Brushes Electro-Mechanical Parking Brake Testing Electro-Mechanical Parking Brake TestingBATTERIES/CHARGER Using the Proper Batteries Using the Proper BatteriesRemoving/Installing Batteries From/Into Battery Tray Tool Quantity CommentsInstalling Batteries Removing BatteriesRemoving/Installing Batteries From/Into Battery Tray Connecting/Disconnecting Battery Cables Connecting Battery Cables20 x 7/8-Inch Disconnecting Battery Cables Removed for clarityReplacing the On-Board Battery Charger Fuse Replacing the On-Board Battery Charger Replacing the On-Board Battery Charger FuseReplacing the On-Board Battery Charger Disconnecting/Connecting the Joystick DisconnectingConnecting Controller and JoystickRemoving/Installing the Joystick Van Seat ModelsAsba and Adjustable Asba Models Removing/Installing the Joystick Van Seat ModelsReplacing the Mkiv RII Controller Replacing the Mkiv RII Controller Replacing the MK5-NX or MK660 ACC Controller Replacing the MK5-NX or MK660 ACC ControllerDisassembling/Assembling the Wheelchair DISASSEMBLING/ Assembling the M71Disassembling the Wheelchair 104 Disassembling the Wheelchair Assembling the Wheelchair Assembling the Wheelchair Final Assembly Transport Ready Package Specifications Model Wheelchair Weight LimitAbout Transport Ready Packages Compliance InformationSecuring the Wheelchair to the Vehicle Positioning the Wheelchair in the VehicleSecurement Points Securing the WheelchairSecuring the Occupant Wheelchair-Anchored BeltsSeating System Vehicle-Anchored BeltsRating Description Positioning Belts Positioning BeltsLimited Warranty USA

Related manuals

Manual 28 pages 55.84 Kb