Invacare M71 service manual E05

Page 21

SECTION 3—SAFETY INSPECTION/TROUBLESHOOTING

NUMBER OF FLASHES	DIAGNOSTICS CODE	ERROR CODE DESCRIPTION	SUB CODE*	DETAILS OF ERROR CODE	POSSIBLE SOLUTION

5	E05	Left Park Brake	00	Left Park Brake Drive-Time	Check the left park brake connections and
		Fault		Test Failed	cable.

			01	Left Park Brake Output
				Enabled When Wheelchair
				Idle

			02	Left Park Brake Output Did
				not Enable When Entering
				Drive Mode

			03	Left Park Brake fault during
				power-up testing

			04	Left park brake feedback low
				during drive (park brake
				short)

6	E06	Right Park Brake	00	Right Park Brake Drive-Time	Check the right park brake connections
		Fault		Test Failed	and cable.

			01	Right Park Brake Output
				Enabled When Wheelchair
				Idle

			02	Right Park Brake Output Did
				not Enable When Entering
				Drive Mode

			03	Right Park Brake fault during
				power-up testing

			04	Right park brake feedback
				low during drive (park brake
				short)

7	E07	Remote Fault	00	Local SR Fault (CPU,	Check the communications bus,
				EEPROM, etc.)	connections and wiring. Replace the
					remote.
			01	Joystick fault at the remote	remote.
			01	Joystick fault at the remote

			02	Speed pot fault at the remote

Part No 1118377

21

Pronto® M71™

Image 21

Contents Pronto M71 Reference Documents Reference DocumentsDocument Part Number Table of Contents Removing/Installing the Adjustable Height Tubes Seat AssemblyWheels ArmsFront RIGGINGS/FOOTBOARD SHROUDS/FRAMEMotors BATTERIES/CHARGER Limited WarrantyController and Joystick DISASSEMBLING/ASSEMBLING the M71Signal Word Meaning Special NotesSeat Positioning Strap Trro and Trbkts Warnings Label Locations Wiring Label on M71 Standard with Battery CoversOne of these battery wiring Labels is in this location M71 with PTO+ Labels Typical Product Parameters Typical Product ParametersInch VAN Asba Repair or Service Information General GuidelinesOperation Information Electrical Tire PressureBatteries Grounding InstructionsEMI Information EMI InformationEMI Information Safety INSPECTION/ Troubleshooting Safety Inspection ChecklistsInspect/Adjust Troubleshooting Troubleshooting ElectricalDisplay Description Definition Diagnostics Code Possible SolutionSUB Code E05 Solutions SymptomJS REV TOO Large Troubleshooting Motor/Gearbox/Brake Troubleshooting CommonSymptom Probable Cause Solutions WheelsTion. Replace motor or gearbox if contamination Troubleshooting Battery Charger Troubleshooting BatteryDON’T Checking Battery Charge LevelField Load Test Battery Quality Motor TestingRemoving/Installing the Seat Assembly Seat AssemblyInstalling Seat Removing SeatRemoving/Installing the Seat Assembly Adjusting the Seat HeightWheelchair Equipped with Available Mounting Holes for VAN Seat with NON-HEMI Front RiggingVAN Seat with Hemi Front Rigging or Footboard Asba Seat with Footboard Or Front Riggings NON-HEMI or Hemi Removing/Installing the Adjustable Height TubesRemoving/Installing the Adjustable Height Tubes Removing/Installing the Seat Pan Adjustable Asba Seat Service ProceduresAdjusting the Seat Width Seat WidthFrame Size Seat Depth Range Adjusting the Seat DepthSeat Depth DISTANCE* in Inches Adjusting the Seat Depth Removing/Installing Side RailsRemoving/Installing Side Rails Replacing the Seat Frame Replacing the Seat FrameRemoving/Installing the Back Canes Replacing Seat Positioning Strap Removing/Installing the Back Canes11 Adjusting the Back Angle Adjusting the Back Angle12 Removing/Installing the Seat Pan Asba Seat Service Procedures13 Replacing the Seat Frame Changing the Seat Width/Depth Replacing the Seat FrameBack Upholstery Replacing the Seat Positioning StrapSeat Assembly Seat Assembly Back Height 15 Removing/Installing the Back UpholsteryAngle Back Cane Mounting Hole Back Angle Plate Hole 16 Adjusting the Back AngleAdjusting the Seat Position on Van Seat Frame Van Seat Service Procedures18 Adjusting the Seat Position on Van Seat Frame Back Depth Seat Size Adjusting the Van Seat Back DepthRemoving/Installing Van Seat Arm Arm Service Procedures for Van SeatAdjusting Van Seat Arm Width ArmsAdjusting Van Seat Arm Height Adjusting Van Seat Arm AngleArmrest Pad Armrest Insert Mounting Screw Arm Post Washers Locknut Arm Service Procedures for Asba or Adjustable Asba Seat Removing/Installing Flip Back ArmrestAdjusting the Flip Back Armrest Adjusting the Flip Back Armrest Replacing the Front/Rear Casters WheelsAdjusting Caster Assembly Adjusting Caster AssemblyRemoving/Installing the Front Headtube Assembly Removing/Installing the Front/Rear Caster AssembliesInstalling RemovingRemoving/Installing the Drive Wheel Installing the Drive WheelRemoving the Drive Wheel Removing/Installing the Drive Wheel Inner Rim Front RIGGINGS/ Footboard Installing/Removing Front RiggingsAdjusting Footrest Height Model PHWH93 Front RiggingsModel PH904A and PHAL4A Front Riggings Replacing Heel Loops Adjusting/Replacing Telescoping Front Rigging SupportsRaising/Lowering Elevating Front Riggings Van SeatStandard Position Inch OUT Inches OUT Asba Seat Adjustable Asba SeatRemoving/Installing the Footboard Assembly Angle/Depth/Height Adjustment of the Footboard Assembly Angle AdjustmentDepth Adjustment 11 Depth Adjustment/Height Adjustment Height AdjustmentSHROUDS/FRAME Removing/Installing the ShroudsRemoving/Installing the Shrouds Removing/Installing the Pivot Tube Disassembling/Reassembling the Side Frame AssemblyDisassembling/Reassembling the Side Frame Assembly Removing/Installing the SureStep Springs Removing/Installing the SureStep Springs Motors Removing/Installing the MotorRemoving/Installing the Motor Release Lever Removing/Installing the Motor Release LeverReplacing Internal Motor Brushes Replacing Internal Motor Brushes Inspecting/Replacing External Motor Brushes Electro-Mechanical Parking Brake Testing Electro-Mechanical Parking Brake TestingBATTERIES/CHARGER Using the Proper Batteries Using the Proper BatteriesTool Quantity Comments Removing/Installing Batteries From/Into Battery TrayRemoving Batteries Installing BatteriesRemoving/Installing Batteries From/Into Battery Tray Connecting Battery Cables Connecting/Disconnecting Battery Cables20 x 7/8-Inch Removed for clarity Disconnecting Battery CablesReplacing the On-Board Battery Charger Fuse Replacing the On-Board Battery Charger Fuse Replacing the On-Board Battery ChargerReplacing the On-Board Battery Charger Disconnecting Disconnecting/Connecting the JoystickConnecting Controller and JoystickVan Seat Models Removing/Installing the JoystickRemoving/Installing the Joystick Van Seat Models Asba and Adjustable Asba ModelsReplacing the Mkiv RII Controller Replacing the Mkiv RII Controller Replacing the MK5-NX or MK660 ACC Controller Replacing the MK5-NX or MK660 ACC ControllerDISASSEMBLING/ Assembling the M71 Disassembling/Assembling the WheelchairDisassembling the Wheelchair 104 Disassembling the Wheelchair Assembling the Wheelchair Assembling the Wheelchair Final Assembly Transport Ready Package Model Wheelchair Weight Limit SpecificationsAbout Transport Ready Packages Compliance InformationPositioning the Wheelchair in the Vehicle Securing the Wheelchair to the VehicleSecuring the Wheelchair Securement PointsWheelchair-Anchored Belts Securing the OccupantVehicle-Anchored Belts Seating SystemRating Description Positioning Belts Positioning BeltsUSA Limited Warranty

Related manuals

Manual 28 pages 55.84 Kb