Vermont Casting DVRTSB manual Homeowner’s Installation Operating Manual

Page 1

Bay Window

Rear/Top Convertible

Direct Vent Fireplaces

Model: DVRTSB

INSTALLER/CONSUMER

SAFETY INFORMATION

PLEASE READ THIS MANUAL BEFORE INSTALLING AND USING APPLIANCE

WARNING!

IF THE INFORMATION IN THIS MANUAL IS NOT FOLLOWED EXACTLY, A FIRE OR EXPLOSION MAY RESULT, CAUSING PROPERTY DAMAGE, PERSONAL INJURY OR LOSS OF LIFE.

FOR YOUR SAFETY

Installation and service must be performed by a qualiﬁed installer, service agency or your gas supplier.

WHAT TO DO IF YOU SMELL GAS:

•Do not try to light any appliance.

•Do not touch any electric switch; do not use any phone in your building.

•Immediately call your gas supplier from your neighbor’s phone. Follow the gas suppliers instructions.

•If you cannot reach your gas supplier call the ﬁre department.

DO NOT STORE OR USE GASOLINE OR OTHER FLAMMABLE VAPORS AND/OR LIQUIDS IN THE VICINITY OF THIS OR

ANY OTHER APPLIANCE.

Homeowner’s Installation and

Operating Manual

	S
E IG		N
D		N

	C	CERTIFIED
	C	D
	E	D
		RTIFIE

INSTALLER: Leave this manual with the appliance.

CONSUMER: Retain this manual for future reference.

10003848 1/07 Rev. 3

Image 1

Contents Homeowner’s Installation Operating Manual Table of Contents National Fuel Gas Code Ansi Z223.1/NFPA Installation & Operating InstructionsFraming Dimensions Fireplace Dimensions Installed as Top VentDvrtsb Top Vent Dvrtsb Rear Vent Fireplace Dimensions Installed as Rear VentClearance to Combustibles Locating Your FireplaceMantels HearthFinal Finishing Gas Line InstallationGas Speciﬁcations Gas Inlet and Manifold PressuresAlternate Switch Location Remote ON/OFF Switch InstallationEB-1 Electrical Box Remove ﬂue cover and ﬂue pipe Optional Top Vent ApplicationLocation of Vent Termination General Venting Information Termination LocationTermination location requirements Canadian Installations1 US Installations2Canadian Installations General Information for Connecting Vent PipesUSA Installations Twist Lock PipesRear Wall Vent Installation How to Use the Vent GraphRear Wall Vent Applications Example aZero clearance sleeve is only required for combustible walls Vertical Sidewall ApplicationsMaximum vent run with elbows Vertical Sidewall InstallationHorizontal length requirement Always install horizontal venting on a level planeVertical Through-the-Roof Applications Below Grade InstallationEnlarged ends of the vent section always face downward Vertical Through-The-Roof InstallationAttic Insulation Shield Upper Floor Twist Lock Venting Components Louvre Removal Glass InformationGlass/Frame Removal Side Glass FrameCeramic Refractory Installation Glass CleaningInstallation of Logs Clean the glass after the ﬁrst two weeks of operationLava Rock & Ember Material Flame Characteristics Flame & Temperature AdjustmentCeramic Ember Rocks Pt. # RN/RP ModelsTo Turn Off Gas To Heater Lighting and Operating InstructionsTroubleshooting the Gas Control System Honeywell Millivolt Valve SIT top Convertible Pilot Fuel Conversion InstructionsPSE Pilot SIT 820 Nova Gas Control Valve FigBurner and Burner Compartment Cleaning the Standing Pilot Control SystemBrass Trim OFF DescriptionDvrtsb Dvrtsb Bay Window Fireplace Fan Kits ON/OFF and Temperature Remote ControlsModel Function/s Controlled Wall mounted thermostat controlDvrtsb Bay Window Fireplace Limited Lifetime Warranty Efﬁciency Ratings