Craftsman 139.53993D owner manual Installation Step, Determine the Header Bracket Location

Page 12

INSTALLATION STEP 1

Determine the Header Bracket

Location

To prevent possible SERIOUSINJURYor DEATH:

•Header bracket MUST be RIGIDLYfastened to structural support on headerwall or ceiling, otherwise garagedoor might not reversewhen required. DO NOTinstall header bracket over drywall.

•Concreteanchors MUST be used if mounting header bracket or 2x4 into masonry.

•NEVERtry to loosen, move or adjust garagedoor, springs, cables, pulleys, brackets, or their hardware, all of which are under EXTREMEtension.

•ALWAYScall a trained door systems technician if garage door binds, sticks, or is out of balance. An unbalanced garagedoor might not reversewhen required.

Installation procedures vary according to garage door types. Follow the instructions which apply to your door.

1.Close the door and mark the inside vertical centerline of the garage door.

2.Extend the line onto the header wall above the door. You can fasten the header bracket within 4 feet (1.22 m) of the left or right of the door center only if a torsion spring or center bearing plate is in the way; or you can attach it to the ceiling

(see page 13) when clearance is minimal. (It may be mounted on the wall upside down if necessary, to gain approximately 1/2" (1 cm).

If you need to install the header bracket on a 2x4 (on wall or ceiling), use lag screws (not provided) to securely fasten the 2x4 to structural supports as shown here and on page 13.

3.Open your door to the highest point of travel as shown. Draw an intersecting horizontal line on the header wall above the high point:

•3" (7.5 cm) above the high point for sectional door and one-piece door with track.

•8" (20 cm) above the high point for one-piece door without track.

This height will provide travel clearance for the top edge of the door.

NOTE: If the total number of inches exceeds the height available in your garage, use the maximum

height possible, or refer to page 13 for ceiling installation.

Header Wall

Header Wall

"_, 3" (7.5 cm)Track

of Travel

Door

Sectional door with curved track

Header Wall

DoorHighest

Point

of Travel

Hardware

Header Wall

'_'_L _3" (7.5 cm!, Track

Y

of Travel

!

 

One-piecedoor with horizontal track

Header Wall

:8" (20 cm)

,"Highest

Point

of Travel

One-piece door=without track:

One-piecedoor without track:

jamb hardware

pivot hardware

12

Page 11 Page 13
Image 12
Page 11 Page 13
Contents Abridor DE Puerta DE Cochera DE 315MN= Contents IntroductionTools needed Preparing your garage doorSectional Door Installation Sectional Door InstallationsPlanning Finished CeilingONE-PIECE Door Installations ONE-PIECE Door Without TrackONE-PIECE Door with Track Finished CeungCarton Inventory SECURITY+Assembly Hardware Installation HardwareHardware Inventory Assembly Step Assemble the RailHardware Shown Actual Size Fasten the Rail to the Motor Unit Install the Trolley Installation Readand Followall Installationwarningsand InstructionsAttach the Rail Brackets Installation Step Determine the Header Bracket LocationInstall the Header Bracket Wall Header Bracket InstallationCeiling Header Bracket Installation Attach the Rail to the Header Bracket Install The Protector System Important Information about Safety Reversing SensorInstalling the Brackets Garage door track installation preferredWall installation Floor installation FigureMounting and Wiring the Safety Sensors Recommended Wire RoutingPosition the Opener Sectional Door or ONE-PIECE Door with TrackEngaged Released Hang the Opener Fenshed Ceung Hardware Shown Actual SizeInstall Door Control Complete the Safety Reversing Sensor Installation Aligning the Safety Reversing SensorsTroubleshooting the Safety Reversing Sensors Permanent Wiring ConnectionInstall the Lights Attach the Emergency Release Rope and HandleFasten the Door Bracket Sectional DoorsONE-PIECEDOORS Connect Door Arm to Trolley Sectional Doors onlyAdjustment procedures, Figure ALL ONE-PIECE DoorsAssemble the door arm, Figure Connect the door arm to the trolleyAdjustment Step Adjust the Travel LimitsHOW and When to Adjust the Limits If door does not open at least 5 feet 1.5 mAdjust the Force HOW and When to Adjust the ForcesTest the Down close force Test the UP open forceTest the Safety Reversal System AdjustImportant Safety Check Test The Protector SystemUsing Your Garage Door Opener OperationReadand Followall Warningsand Instructions Using the Wall.Mounted Door Control Light featureTo Open the Door Manually Remote Control Battery Care of Your OpenerOnce a Month Once a YearHaving a PROBLEM? Refer to Adjustment , Adjust the ForceSymptom LED is not lit on door control Symptom Motor unit doesnt operateTo Add or Reprogram a Hand-held Remote Control Using the Learn Button Using the Premium Control ConsoleProgramming To Erase All Codes From Motor Unit MemoryTo Add Reprogram Change Keyless Entry PIN Must be programmed To operate Your Garage door OpenerEntry is already mounted outside the garage To change an existing, known PINRepair Parts Rail Assembly Parts Installation PartsKEY Part NO. NO. Description Not ShownMotor Unit Assembly Parts KEY PartKEY Part NO. NO.DESCRIPTION Accessories WarrantyService For Sectional Doors OnlyContenido IntroduccionPreparaci6n de la puerta de su cochera Herramientas necesariasPlanificaci6n Instalacicn CON UNA Puerta SeccionalInstalacion EN UNA Puerta Seccional Techo TERMI/ADOPlanificaci6n continba Instalacion CON Puertas DE UNA Sola PiezaPuerta DE UNA Sola Pieza SIN Carril Puerta DE UNA Pieza CON CarrilInventario de las caja de cart6n Inventario de Piezas Tornillera Y Piezas Para EL MontajeMontaje Paso Monte el rielMontaje el riel continba Estas Piezas SE Muestran EN SU Tamano RealFije el riel a la unidad del motor e instale el trole Estas Piezas SE Muestran EN SU Tamaiio RealLA Muerte Fijacibn de las mnsulas del rielInstalacion Paso Determine dbnde va a instalar la Mnsula del CabezalCabezal EltechoInstale la mnsula del cabezal Instalacion DE LA Mensula DEL Cabezal EN ELColocacibn del riel en la mnsula del cabezal Estas Piezas SE Muestran EN SU Tamaiio RealInstale la Sistema de Protecci6n Enfrentando la puerta desde el lado interno del garajeInstalacion DE LAS Mcnsulas Instalaci6n en la pared Figura 2 yInstalaci6n en el piso Figura Montajeparedlado DerechoRuta recomendada para el cableado Coloque el Abridor en Posici6n Puerta DE UNA Sola Pieza SIN RielEnganchado Desenganchado INSTALACION, Paso Cuelgue el AbridorInstale la unidad de control de la puerta Estas Piezas SE Muestran EN SU Tamaio RealQuitar Y Volvera Ponerlatapa Requisitos para la instalaci6n el6ctrica COMe Alinear LOS Sensores DE SeguridadInstale las Luces Coloque la Cuerda y la Manija De EmergenciaFije la mnsula de la puerta Puertas SeccionalesPuertas DE UNA Sola Pieza Conecte el brazo de la puerta al trole SLO Para Puertas SeccionalesTodas LAS Puertas DE UNA Sola Pieza Arme el brazo de la puerta, FiguraAjustes Paso Ajuste el limite del recorrido Hacia Arriba y Hacia AbajoCalcomanade Ajustes Ajuste de la fuerza Etiouetade Ajustede FuerzaPruebe la Sistema de Protecci6n Pruebe el Sistema de Retroceso de SeguridadPrueba AjusteConserveestasinstrucciones OperacionC6mo Usar su Abridor de Puerta de Cochera Active su abridor de alguna de las siguientes manerasC6mo usar la unidad de control de pared C6mo abrir la puerta manualmenteComo Desconectar EL Trole CMO Reconectar EL TroleMantenimiento DE SU Abridor DE Puerta DE Cochera Ajustes DE Lmite Y FuerzaSI Tiene Algon Problema El control remoto no activa la puertaTabla de Diag El motorComo Programar EL Abridor C6mo Agregar o Reprogramar un Control Remoto ManualControles Remotos de 3 Funciones Para cambiar un PIN existente Accesorios Riel de 2.4 m 8 piesNo.,a,,erw.orna1,,noe.,a,,erw.so,1

139.53993D specifications

The Craftsman 139.53993D is a top-tier garage door opener designed for efficiency, convenience, and durability. This model is part of Craftsman's renowned lineup, known for reliable home improvement products. With its advanced features and technology, this garage door opener offers users a blend of functionality and modern convenience.

One of the standout features of the Craftsman 139.53993D is its powerful motor. Equipped with a robust 1/2 horsepower motor, it delivers strong lifting power, making it suitable for handling standard residential garage doors with ease. This strength ensures a smooth and reliable operation, even for heavier doors.

The technology integrated into the Craftsman 139.53993D significantly enhances security. This model utilizes a rolling code technology that changes the code each time the remote is used, making it nearly impossible for intruders to gain access. The safety features extend to the presence of an infrared safety sensor, which detects any obstacles in the door’s path and reverses its direction, preventing accidents and injuries.

Convenience is a key characteristic of this garage door opener. The Craftsman 139.53993D is compatible with various remote controls, including a keypad entry, allowing for keyless entry. Additionally, the model includes an integrated Wi-Fi capability. This feature grants homeowners remote access via a mobile app, enabling them to monitor and control their garage door from anywhere, adding an extra layer of convenience.

Installation is user-friendly owing to its clear instructions and included components. Most users can set it up in a short timeframe without professional help. Furthermore, the design of the motor unit is compact, allowing for easy placement and ensuring that it does not take up excessive space in the garage.

Alongside its functionality, the Craftsman 139.53993D is built with durability in mind. It features all-steel construction, providing long-lasting reliability and strength, suitable for the demands of daily use. The quiet operation is another impressive feature, ensuring that the door opens and closes smoothly without causing disturbances.

In summary, the Craftsman 139.53993D garage door opener stands out with its powerful motor, advanced security features, convenient technology, and robust construction. It reflects Craftsman's commitment to quality and innovation in home improvement solutions, making it a dependable choice for homeowners seeking a reliable garage door opener.
Top Page Image Contents