Cornelius 1550 installation manual Flow Diagram

Page 9

LINE LEGEND

BEER

CO2

1550 UNIVERSAL BEER DISPENSER

BEER KEG SECONDARY

CO2 REGULATOR (2)

COIL NO. 1

COIL NO. 2

DISPENSING

FAUCET (2)

1

2

PRIMARY CO2

REGULATOR

5

SEE NOTE 2

SYRUP TANK

CO2 QUICK

DISCONNECT

BEER KEG

TAPPER (2)

BEER KEG (2)

CO2 CYLINDER

569000246

			BEER	COILS IN PARALLEL	DISPENSING
TEE			BEER		DISPENSING
TEE			SHUTOFF		FAUCET (2)
FITTING			SHUTOFF		FAUCET (2)
FITTING			VALVE
			VALVE
CO2	SHUTOFF	CO2 GAS			1
CO2	SHUTOFF	CHECK VALVE (2)	TEE
VALVE (2)		CHECK VALVE (2)	TEE	COIL NO. 1
VALVE (2)			FITTING	COIL NO. 1
			FITTING

		2
	COIL NO. 2
SEE NOTE 1	COILS IN SERIES	1550 UNIVERSAL
	(561600074 ONLY)	1550 UNIVERSAL
	(561600074 ONLY)	BEER DISPENSER
		BEER DISPENSER

NO. 1	NO. 2	SYRUP TANK
		LIQUID QUICK
		DISCONNECT

NOTE 1: THESE PARTS MUST BE INSTALLED IN UNIT BEER

INLET LINES CLOSE TO BEER KEG TAPPERS TO

FACILITATE SANITIZING THE BEER SYSTEMS.

NOTE 2: THESE PARTS MUST BE INSTALLED IN THE CO2

LINE TO FACILITATE CONNECTING CO2 TO SYRUP

TANK CONTAINING SANITIZING SOLUTION.

FIGURE 2. FLOW DIAGRAM

Image 9

Contents This Document Contains Important Information Installation ManualTable of Contents Table of Contents cont’d Recognize Safety Information Safety InformationPage This page Left Blank Intentionally General Information Warranty Reference InformationGeneral Description Design DataUniversal Beer Dispenser Theory of OperationFlow Diagram Page This page Left Blank Intentionally Installation Unpacking and InspectionSelecting Location Fill Water Tank and Start Refrigeration System InstallationConnecting CO2 System to Beer KEG Tappers Connecting Beer Source Supplies to UnitPreparing Unit for Operation Unit Operation Proper Beer Storage OPERATOR’S InstructionsOperating Controls Daily PRE-OPERATION CheckAdjustments Cooling Unit MaintenanceOperating Clearances Cleaning CO2 System GAS Check Valves Cleaning and SanitizingReplenishing CO2 Supply Replenishing Beer SupplyPage This page Left Blank Intentionally Adjusting CO2 Regulators Service and MaintenancePreparing Unit for SHIPPING, RELOCATING, or Storing Periodic InspectionDispenser Components Parts Identification Beer Faucet Adjustment Unit Maintenance Cleaning Condenser CoilChecking ICE Water Bath Cleaning Water TankSanitize Beer Systems Replenishing CO2 Supply CO2 GAS Check Valve Cleaning CO2 GAS Check Valve Wiring Diagram Troubleshooting Rate TOO High Temperature TOO WarmOFF-TASTE Beer Sour UnpalatableCompressor does not Coolant Sufficiently Installation SectionOperate Compressor will notRefrigeration Compressor notOperating Warranty One Cornelius Place Anoka, Minnesota 612 800