Multiquip DCA-25USIXF/DCA-25USI2XF- Output Terminal Panel, 120VAC Gfci Receptacles

Page 23

DCA-25USIXF/DCA-25USI2XF— OUTPUT TERMINAL PANEL

120VAC GFCI Receptacles

There are two 120 VAC, 20 amp GFCI (Duplex Nema 5-20R) recepacles provided on the output terminal panel. These receptacles can be accessed in any voltage selector switch position. Each receptacle is protected by a 20 amp circuit breaker.These breakers are located directly above the GFCI receptacles. Remember the load output (current) of both GFCI receptacles is dependent on the load requirements of the U, V, and W output terminal lugs.

Pressing the reset button resets the GFCI receptacle after being tripped. Pressing the Test Button (See Figure 9) in the center of the receptacle will check the GFCI function. Both receptacles should be tested at least once a month.

Figure 9. G.F.C.I. Receptacle

Twist Lock Dual Voltage 120/240 VAC Receptacles

There are three 120/240V, 50 amp auxilliary twist-lock (CS-6369) recepacles (Figure 10) provided on the output terminal panel.These receptacles can only be accessed when the voltage selector switch is placed in the single- phase 240/120 position.

Each auxilliary receptacle is protected by a 50 amp circuit breaker.These breakers are located directly above the GFCI receptacles. Remember the load output (current) on all three receptacles is dependent on the load requirements of the Output Terminal Lugs.

Turn the voltage regulator control knob (Figure 11) on the control panel to obtain the desired voltage.Turning the knob clockwise will increase the voltage, turning the knob counter- clockwise will decrease the voltage.

Figure 11. Voltage Regulator Control Knob

Removing the Plastic Face Plate (UVWO Terminals)

The UVWO terminal lugs are protected by a plastic face plate cover (Figure 12). Un-lock the locking latch, and lift the terminal cover to gain access to the plastic face plate. Remove the screws securing the face plate to the terminal enclosure, then lift the plastic hinged face plate.

After the load wires have been securely attached to the UVWO terminals, reinstall the plastic face plate. Place the terminal cover in the down position and secure the locking latch.

Figure 12. Plastic Face Plate (UVWO Terminals)

Figure 10. 120/240V Twist-Lock

Auxiliary Receptacles

DCA-25USIXF/DCA-25USI2XF — OPERATION AND PARTS MANUAL — REV. #1 (05/08/09) — PAGE 23

Image 23
Contents Model DCA-25USIXF Model DCA-25USI2XF DCA-25USIXF/DCA-25USI2XF- Proposition 65WARNING Diesel engine exhaust and someDCA-25USIXF/DCA-25USI2XF-TABLE of Contents Ordering parts has never been easier DCA-25USIXF/DCA-25USI2XF- Parts Ordering ProceduresGenerator Specifications DCA-25USIXF/DCA-25USI2XF- SpecificationsDimensions DCA-25USIXF/DCA-25USI2XF- Dimensions TOP, Side and FrontHazard Symbols DCA-25USIXF/DCA-25USI2XF- Safety Message Alert SymbolsDCA-25USIXF/DCA-25USI2XF- Safety Message Alert Symbols Carbon monoxide gas General SafetyDCA-25USIXF/DCA-25USI2XF- Rules for Safe Operation Injury PeopleDCA-25USIXF/DCA-25USI2XF- Rules for Safe Operation Maintenance SafetyUse well insulated gloves when picking up the battery Battery SafetyDeath Guidelines section in this manual Towing and Transporting SafetyGenerator Decals DCA-25USIXF/DCA-25USI2XF- DecalsDCA-25USIXF/DCA-25USI2XF- Decals Typical Generator Grounding Application DCA-25USIXF/DCA-25USI2XF- InstallationMounting Outdoor InstallationIndoor Installation When connecting the generator Two auxilliary circuit breakers, 250V @50 amps DCA-25USIXF/DCA-25USI2XF- General InformationMajor Components DCA-25USIXF/DCA-25USI2XF- Major ComponentsGenerator Control Panel DCA-25USIXF/DCA-25USI2XF- Generator Control PanelEngine Operating Panel DCA-25USIXF/DCA-25USI2XF- Engine Operating PanelOutput Terminal Familiarization DCA-25USIXF/DCA-25USI2XF- Output Terminal PanelOutput Terminal Panel 120VAC Gfci Receptacles DCA-25USIXF/DCA-25USI2XF- Output Terminal PanelOver Current Relay Connecting LoadsMotors and motor-driven Single Phase LoadThree Phase Load DCA-25USIXF/DCA-25USI2XF- Load APPLICATION/MAXIMUMMaximum Amps Voltage Selector SwitchDCA-25USI Gauge READING/TERMINAL Panel Connections Generator OutputVoltagesReading Voltage Voltage selector switchChange-Over Switch DCA-25USI Gauge READING/TERMINAL Panel Connections3Ø 208V/1Ø120V Output Terminal Lug Voltages Three-Phase PositionUvwo Terminal Output Voltages 3Ø 240/139 Output Terminal Lug Voltages1Ø 240V/120V Output Terminal Lug Voltages 3Ø 480/277 Output Terminal Lug VoltagesFuel Check DCA-25USIXF/DCA-25USI2XF- SetupCircuit Breakers Lubrication OilRefueling DCA-25USIXF/DCA-25USI2XF- SetupRefueling Procedure Must be less than 50% Cleaning the RadiatorAir Cleaner Fan Belt Tension Operation FreezingWeatherAlternator BatteryBattery Cable Installation WiringDirect exhaust away from nearby personnel DCA-25USIXF/DCA-25USI2XF- Generator START-UP ProcedureBefore Starting Engines exhaust contains harmful emissionsIgnition Switch Start Position Oil Pressure Gauge Automatic Shut-down System DCA-25USIXF/DCA-25USI2XF- Generator SHUT-DOWN ProcedureNormal Shut-down Procedure Emergency Shut-down ProcedureDCA-25USIXF/DCA-25USI2XF- Maintenance DCA-25USIXF/DCA-25USI2XF- Maintenance Check the wheel and drum for free rotation DCA-25USIXF/DCA-25USI2XF-TRAILER MaintenanceBrake Adjustment BrakesSuspension DCA-25USIXF/DCA-25USI2XF-TRAILER MaintenanceTires/Wheels/Lug Nuts TireWear/InflationStart all wheel lug nuts by hand DCA-25USIXF/DCA-25USI2XF-TRAILER MaintenanceLug Nut Torque Requirements Trailer/Towing Vehicle Wiring Diagram DCA-25USIXF/DCA-25USI2XF-TRAILERWIRING DiagramEngine Wiring Diagram DCA-25USIXF/DCA-25USI2XF- Enginewiring DiagramDCA-25USIXF/DCA-25USI2XF- Enginewiring Diagram Generator Wiring Diagram DCA-25USIXF/DCA-25USI2XF- Generatorwiring DiagramStarter does not run DCA-25USIXF/DCA-25USI2XF-TROUBLESHOOTING EngineEngine does not start DCA-25USIXF/DCA-25USI2XF-TROUBLESHOOTING Engine Generator Troubleshooting DCA-25USIXF/DCA-25USI2XF-TROUBLESHOOTING GeneratorDCA-25USIXF/DCA-25USI2XF- Explanation of Code in Remarks Sample Parts ListQty Description DCA-25USIXF/DCA-25USI2XF- Suggested Spare PartsDCA-25USIXF/DCA-25USI2XF- Generator Assy DCA-25USIXF/DCA-25USI2XF- Generator Assy DCA-25USIXF- Control BOX Assy DCA-25USIXF- Control BOX Assy DCA-25USIXF- Control BOX Assy DCA-25USIXF- Control BOX Assy DCA-25USI2XF- Control BOX Assy DCA-25USI2XF- Control BOX Assy DCA-25USI2XF- Control BOX Assy DCA-25USI2XF- Control BOX Assy DCA-25USIXF- Engine ANDvRADIATOR Assy DCA-25USIXF- Engine and Radiator Assy DCA-25USIXF- Engine and Radiator Assy 0199901600 M9602000003M9200200004 0150000018DCA-25USI2XF- Engine and Radiator Assy 0150000016 M19232001248944567412 M9200100904DCA-25USI2XF- Engine and Radiator Assy M1316100603 Output Terminal Assy DCA-25USIXF/DCA-25USI2XF- Outputterminal Assy0039308000 M1230700003M9220000004 M9220000104DCA-25USIXF/DCA-25USI2XF- Battery Assy 0602220920 0602220185M9310500014 M9103000304DCA-25USIXF- Muffler Assy DCA-25USIXF Muffler Assy DCA-25USI2XF- Muffler Assy M1333003013 M1332000512M1333200304 M1333300204DCA-25USIXF/DCA-25USI2XF- Fueltank Assy 0605516090 M13630013020605505072 0605501098DCA-25USIXF- Enclosure Assy 0603306797 PLUG, 1-1/2 0016910030 M1413002502M1493000004 M1413100003DCA-25USIXF- Enclosure Assy M1445400103 M144530010327A M1495300504 27B M1495300604DCA-25USIXF- Enclosure Assy M1435000903 51A C931250000452A 0030006000 M9112100504DCA-25USI2XF- Enclosure Assy M1423002402 M1413003902M1493000704 M1413600004DCA-25USI2XF- Enclosure Assy 35A M1493305204 M144330220334A M1493305104 M1443400103DCA-25USI2XF- Enclosure Assy M1433001103 58A C931250000459A 0030006000 M1433300003DCA-25USIXF/DCA-25USI2XF- Rubber Seals Assy 0228901220 02292007900314500560 0229200630DCA-25USIXF/DCA-25USI2XF- Nameplate and Decals Assy DCA-25USIXF/DCA-25USI2XF- Nameplate and Decals Assy Freightpolicy Terms and Conditions of Sale PartsPage Fax 972 Tel