Kohler 10ERG, 15ERG, 13ERG manual

Contents Model TP-6335 9/04Page Table of Contents Page Accidental Starting Safety Precautions and InstructionsBattery Engine Backfire/Flash Fire Exhaust SystemHazardous Voltage/ Electrical Shock Fuel SystemHazardous Noise Hot Parts Moving Parts246242 VI Safety Precautions and Instructions TP-6335 9/04 Introduction Installation StandardsGenerator Set Specifications Generator Set OperationIntroduction TP-6335 9/04 Location Location and MountingGeneral Considerations Vehicle-Floor MountingLocation and Mounting TP-6335 9/04 Air Requirements High Water Temperature SwitchCooling System Block HeatersCooling System TP-6335 9/04 Exhaust System Exhaust Piping, If Used PlanningClearance Requirements Fuel System GasolineFuel Lines Fuel Filters or StrainersLP Gas Fuel Pump Lift and Fuel Consumption Fuel Pump Lift Capability Max., Gasoline ModelsFuel System TP-6335 9/04 AC Load Lead Connections Electrical SystemElectrical Connections Transfer Switch Connections Wire AC Circuit Circuit Protection Circuit Breaker ConsiderationsCircuit Breaker Installation Electrical ConnectionsADC 2100 Continuous Power Mode Jumper Battery and Connections CCARemote Connection View BElectrical System TP-6335 9/04 Installation Drawing Dimension Drawing, Gasoline Fuel SystemDimension Drawing, LP Fuel System Dimension Drawing, Floor Template Installation Drawing TP-6335 9/04 Reconnection/Adjustments 100--120-Volt, 2-Wire Configuration Four-Lead Reconnection200--220--240-Volt, 2-Wire Configuration For Models with ADC Controller Software Version Number Configuration Mode Time OutAdvanced Digital Control ADC Adjusting the Voltage, Gain, and Volts/Hz Voltage AdjustmentOutput Voltage Adjustment Mode On FigureV E From FigureController Configuration Controller Parameters N c V E 11 Save Mode after configuring generator set parameters Reconnection/Adjustments TP-6335 9/04 Appendix a Generator Selection and Wattage Requirements General Wattage RequirementsAppendix B Abbreviations AnsiLCB Page Page By Kohler Co. All rights reserved