Manuals / Monessen Hearth / Outdoor Cooking / Fire Pit

Monessen Hearth BWB400 manual Fireplace Components, GD42B OR GD42PB, Sc Round, FP-4-U, Uninsulated

Models: BWB400 BWBC400I

1 80

Download 80 pages 49.21 Kb

Page 52

GD42B OR GD42PB

FIREPLACE COMPONENTS

	FIGURE 13
						GD42B OR GD42PB	SCS
			SCF42A/SCF42AI			GD42B OR GD42PB	CHIMNEY
	SF42A/SF42AI					GLASS DOOR KIT	CHIMNEY
	SF42A/SF42AI						SUPPORT


		612-1212		SC ROUND		SF FIRESTOP	H2066 HEARTH
		612-1212				SPACER	EXTENSION KIT
	SE30 30∞	FLASHING
				CHIMNEY CAP

	ELBOW
	ELBOW
	403 DUCT	AK4 COMBUSTION
	CONNECTOR	AK4 COMBUSTION				FP-4-U
	CONNECTOR	AIR ASSEMBLY				FP-4-U
		AIR ASSEMBLY				UNINSULATED	FA2 FAN
						UNINSULATED	FA2 FAN
						FLEX PIPE	ASSEMBLY
	CF8
	CHIMNEY CAP			S48	S36	S18	S12
	Must use with VFK				S36	S18	S12
	Must use with VFK
	12
	53D9032. Rev 1 03/03

Image 52

Monessen Hearth BWBC400I, BWB400I manual Fireplace Components, GD42B OR GD42PB, Sc Round, FP-4-U, Uninsulated

Contents

INSTALLATION, OPERATION AND MAINTENANCE MANUAL BWB400, BWB400I, BWBC400 ANDBWBC400I WOOD BURNING FIREPLACES BWB400-SERIESCONGRATULATIONS TABLE OF CONTENTSLISTING AND CODE APPROVALS IMPORTANT INFORMATION 1. Damage to the fireplace from overheating3. The emission of smoke, sparks or hazardous gases into the dwelling 4. Leakage of rain water into the dwellingOPERATION GUIDELINES RESIDENTIAL INSTALLATION CLEARANCESOPERATION GUIDELINES OUTSIDE AIR CONNECTOR CENTERLINE 13 1/8 TOP VIEW CLEARANCESFIREPLACE LOCATION CAUTION Do not install fireplace over carpetingINSTALLATION PREPARATION SINGLE STORY INSTALLATION WITH ATTIC SPACE INSTALLATION PREPARATIONMULTIPLE STORY INSTALLATION FLOOR PROTECTION FLOOR PROTECTION C=K divided by the material thickness Example C = .43 divided by 1/2R3672 36 FIREPLACE COMPONENTSR4884 48 MODEL FIREPLACE COMPONENTSDESCRIPTION FIREPLACE INSTALLATION CHIMNEY INSTALLATION CHIMNEY INSTALLATION 0/12CHIMNEY OFFSET INSTALLATION CHIMNEY OFFSET AND CAP INSTALLATION 14-1/222-1/16 30 ˚CHIMNEY CAP INSTALLATION CHIMNEY HEIGHT AND OFFSET CHARTS CHIMNEY CAP CHASE INSTALLATION CHIMNEY CAP SUPPORT BRACKETS. 3 PLACES SCREW MAINTAIN CHIMNEYSYSTEM AIR SPACE CLEARANCES TO COMBUSTIBLES ABOVE ROOF LINE FLAT FLASHING OR CHASE COVER WITH 11-1/4 MIN. DIA. HOLEOUTSIDE COMBUSTION AIR PRECAUTIONS AND RECOMMENDATIONS OUTSIDE COMBUSTION AIR PRECAUTIONS & RECOMMENDATIONS GAS APPLIANCE INSTALLATION COMBUSTION AIR ASSEMBLYIMPORTANT NOTICES GAS APPLIANCE INSTALLATION CAUTION If an unvented gas appliance is installed in the fireplace, the gas appliance must only be operated with the fireplace glass door fully open if included. Only unvented gas log set which have been found to comply with the standard for unvented room heaters, ANSI/IAS/AGA Z21.11.2, are to be installed in this fireplaceTRIM INSTALLATION GAS APPLIANCE INSTALLATION12 MAX 1 1/2TRIM INSTALLATION PART APART B PART CGLASS DOOR INSTALLATION AND FAN ACCESSORY FIREPLACE OPERATION FIREPLACE OPERATION DogwoodMAINTENANCE AND SAFETY MAINTENANCE AND SAFETY DO’SMAINTENANCE AND SAFETY DONT’SPARTS DIAGRAM AND LIST BWB400/BWB400I MODEL FIREPLACEBWBC400/BWBC400I PARTS DIAGRAM AND LISTMODEL FIREPLACE FACTORY-BUILT FIREPLACE AND COMPONENTS LIMITED WARRANTYEXCEPT BLOWERS IF YOU HAVE A PROBLEM WITH YOUR FIREPLACE OR COMPONENT LIMITED WARRANTYYOUR DUTIES This page intentionally left blank 53D9031. Rev 1 03/03This page intentionally left blank 53D9031. Rev 1 03/03APPLIANCE INSTALLER PLEASE RETURN THESE OPERATING AND INSTALLATION INSTRUCTIONSTO THE CONSUMER 53D9031. Rev 1 03/03BWB500, BWB500I, BWBC500 AND BWBC500I RESIDENTIAL FIREPLACESSF42 SERIES INSTALLATION, OPERATION AND MAINTENANCE MANUALTABLE OF CONTENTS CONGRATULATIONSChimney Cap Chase Installation LISTING AND CODE APPROVALSINTENDED PRODUCT USAGE IMPROPER INSTALLATIONIMPORTANT INFORMATION Glass doors should be installed to receive the maximum benefit from your fireplace. For large fires, the maximum heating benefit from the fireplace will be obtained with the doors open due to the high amount of radiant heat being emitted out of the front opening of the fireplace. With a small fire, or before retiring in the evenings, it is best to operate the fireplace with the doors closed to prevent excessive room air from being drawn up the chimney. When the doors are open, the mesh screens should be closed to help keep burning embers from popping out of the firebox OPERATION GUIDELINESRESIDENTIAL INSTALLATION CLEARANCESCLEARANCES 53D9032. Rev 1 03/03CAUTION Do not install fireplace over carpeting WITH GLASS DOORS INSTALLEDFIREPLACE LOCATION 21 1/2 MININSTALLATION PREPARATION JOIST INSULATE SAMESINGLE STORY INSTALLATION WITH ATTIC SPACE INSTALLATION PREPARATION53D9032. Rev 1 03/03 If this fireplace is installed on a combustible floor, the floor area 20 inches in front of, and 12 inches either side of the fireplace opening must be protected by an insulating noncombustible hearth extension. This hearth extension may be either minimum 6-inch thick stone or brick as shown by Figure 10, an H2066 Hearth Extension Kit or a locally constructed hearth equivalent to the H2066 FLOOR PROTECTIONFLOOR METAL SAFETY STRIP FLOOR PROTECTIONFLOOR LINE WITH RAISED HEARTH FIREPLACE HEARTHFIREPLACE COMPONENTS GD42B OR GD42PBSC ROUND FP-4-UMODEL FIREPLACE COMPONENTSDESCRIPTION FIREPLACE INSTALLATION CHIMNEY INSTALLATION 53D9032. Rev 1 03/03CHIMNEY INSTALLATION 53D9032. Rev 1 03/03CHIMNEY OFFSET INSTALLATION REQUIRED TO BE SECURED FORADDED STABILIZATION OF PIPE STRAPS MUST BE NAILED ON TO FRAMING MEMBERCHIMNEY OFFSET AND CAP INSTALLATION 14-1/222-1/16 14 FTCHIMNEY CAP INSTALLATION CHIMNEY HEIGHT AND OFFSET CHARTS 53D9032. Rev 1 03/03CHIMNEY CAP CHASE INSTALLATION OUTSIDE COMBUSTION AIR PRECAUTIONS & RECOMMENDATIONS 53D9032. Rev 1 03/03OUTSIDE COMBUSTION AIR PRECAUTIONS & RECOMMENDATIONS MODEL AK4 COMBUSTION AIR ASSEMBLY COMBUSTION AIR ASSEMBLY53D9032. Rev 1 03/03 GAS APPLIANCE INSTALLATION 53D9032. Rev 1 03/03GAS APPLIANCE INSTALLATION GAS LINE PLUMBING DETAILTRIM INSTALLATION FRAMING EXTEND LINE FROM OPPOSITE REAR OFFIREBOX THRU A POINT 4 IN FRONT OF FIREPLACE FACE, AND 1 OUTSIDE OF 1/4 SCREENED OPENING FINISHED WALL SCREENED OPENING OF FIREPLACEGLASS DOOR INSTALLATION AND FAN ACCESSORY GLASS DOOR INSTALLATIONFAN ASSEMBLY 53D9032. Rev 1 03/03HOW TO BUILD A BETTER FIRE FIREPLACE OPERATIONADVANTAGES OF A WOOD BURNING FIREPLACE WHICH WOODS ARE BEST?FIREPLACE OPERATION SPECIESDENSITY HEAT VALUEMAINTENANCE AND SAFETY CHIMNEY MAINTENANCEFUEL STORAGE DISPOSAL OF ASHESMAINTENANCE AND SAFETY DO’SMAINTENANCE AND SAFETY DONT’SREPAIR PART DIAGRAMS AND LISTS BWB500 / BWB500I MODEL FIREPLACEBWBC500 / BWBC500I MODEL FIREPLACE REPAIR PART DIAGRAMS AND LISTSFACTORY-BUILT FIREPLACE AND COMPONENTS LIMITED WARRANTYEXCEPT BLOWERS Technical Service Department LIMITED WARRANTY2813 W. Mall Drive, Unit B. Florence, Alabama Tel 53D9032. Rev 1 03/03 THIS PAGE INTENTIONALLY LEFT BLANK53D9032. Rev 1 03/03 THIS PAGE INTENTIONALLY LEFT BLANKPLEASE RETURN THIS OPERATING AND INSTALLATION INSTRUCTIONS 53D9032. REV 1 03/03APPLIANCE INSTALLER TO THE CONSUMER