Manuals / Monessen Hearth / Outdoor Cooking / Fire Pit

Monessen Hearth BWB400I manual Fireplace Location, CAUTION Do not install fireplace over carpeting

Models: BWB400 BWBC400I

1 80

Download 80 pages 49.21 Kb

Page 7

FIREPLACE LOCATION

FIREPLACE LOCATION

CAUTION: Do not install fireplace over carpeting.

This fireplace does not weigh more than large pieces of furniture and can normally be located near a load bearing wall without requiring additional foundations or supports. If however, the fireplace is to be trimmed with a heavy stone or brick facing and hearth extension, be sure the supporting structure is adequate.

Figures 4 and 5 provide dimensional details of the fireplace, required spacing to combustible walls, and some suggested fireplace locations. When selecting a location, choose one that is away from frequently opened doors, central heat outlets or returns, or other places where air movements may disturb the airflow around the fireplace. Air turbulence near the fireplace may cause smoke to spill out of the fireplace opening.

FIGURE 4

46 5/16" MIN.

13 3/4"	21 1/2" MIN.
MIN.

23" MIN.

24" MIN.*

65 1/2" MIN.

49" MIN.

13 3/4"(WITH GLASS DOORS INSTALLED)

MIN.

CORNER INSTALLATION

FIGURE 5

SIDE WALL INSTALLATION

FULL PROJECTION

CORNER

FLUSH

7

53D9031. Rev 1 03/03

Image 7

Monessen Hearth BWB400I, BWBC400I manual Fireplace Location, CAUTION Do not install fireplace over carpeting

Contents

BWB400-SERIES INSTALLATION, OPERATION AND MAINTENANCE MANUALBWB400, BWB400I, BWBC400 AND BWBC400I WOOD BURNING FIREPLACESCONGRATULATIONS TABLE OF CONTENTSLISTING AND CODE APPROVALS 4. Leakage of rain water into the dwelling IMPORTANT INFORMATION1. Damage to the fireplace from overheating 3. The emission of smoke, sparks or hazardous gases into the dwellingOPERATION GUIDELINES RESIDENTIAL INSTALLATION CLEARANCESOPERATION GUIDELINES CLEARANCES OUTSIDE AIR CONNECTOR CENTERLINE 13 1/8 TOP VIEWCAUTION Do not install fireplace over carpeting FIREPLACE LOCATIONINSTALLATION PREPARATION SINGLE STORY INSTALLATION WITH ATTIC SPACE INSTALLATION PREPARATIONMULTIPLE STORY INSTALLATION FLOOR PROTECTION C=K divided by the material thickness Example C = .43 divided by 1/2 FLOOR PROTECTIONR3672 36 FIREPLACE COMPONENTSR4884 48 MODEL FIREPLACE COMPONENTSDESCRIPTION FIREPLACE INSTALLATION CHIMNEY INSTALLATION 0/12 CHIMNEY INSTALLATIONCHIMNEY OFFSET INSTALLATION 30 ˚ CHIMNEY OFFSET AND CAP INSTALLATION14-1/2 22-1/16CHIMNEY CAP INSTALLATION CHIMNEY HEIGHT AND OFFSET CHARTS FLAT FLASHING OR CHASE COVER WITH 11-1/4 MIN. DIA. HOLE CHIMNEY CAP CHASE INSTALLATIONCHIMNEY CAP SUPPORT BRACKETS. 3 PLACES SCREW MAINTAIN CHIMNEY SYSTEM AIR SPACE CLEARANCES TO COMBUSTIBLES ABOVE ROOF LINEOUTSIDE COMBUSTION AIR PRECAUTIONS AND RECOMMENDATIONS OUTSIDE COMBUSTION AIR PRECAUTIONS & RECOMMENDATIONS GAS APPLIANCE INSTALLATION COMBUSTION AIR ASSEMBLYIMPORTANT NOTICES CAUTION If an unvented gas appliance is installed in the fireplace, the gas appliance must only be operated with the fireplace glass door fully open if included. Only unvented gas log set which have been found to comply with the standard for unvented room heaters, ANSI/IAS/AGA Z21.11.2, are to be installed in this fireplace GAS APPLIANCE INSTALLATION1 1/2 TRIM INSTALLATIONGAS APPLIANCE INSTALLATION 12 MAXPART C TRIM INSTALLATIONPART A PART BGLASS DOOR INSTALLATION AND FAN ACCESSORY FIREPLACE OPERATION Dogwood FIREPLACE OPERATIONMAINTENANCE AND SAFETY DO’S MAINTENANCE AND SAFETYDONT’S MAINTENANCE AND SAFETYBWB400/BWB400I MODEL FIREPLACE PARTS DIAGRAM AND LISTBWBC400/BWBC400I PARTS DIAGRAM AND LISTMODEL FIREPLACE FACTORY-BUILT FIREPLACE AND COMPONENTS LIMITED WARRANTYEXCEPT BLOWERS IF YOU HAVE A PROBLEM WITH YOUR FIREPLACE OR COMPONENT LIMITED WARRANTYYOUR DUTIES 53D9031. Rev 1 03/03 This page intentionally left blank53D9031. Rev 1 03/03 This page intentionally left blank53D9031. Rev 1 03/03 APPLIANCE INSTALLERPLEASE RETURN THESE OPERATING AND INSTALLATION INSTRUCTIONS TO THE CONSUMERINSTALLATION, OPERATION AND MAINTENANCE MANUAL BWB500, BWB500I, BWBC500 ANDBWBC500I RESIDENTIAL FIREPLACES SF42 SERIESLISTING AND CODE APPROVALS TABLE OF CONTENTSCONGRATULATIONS Chimney Cap Chase InstallationINTENDED PRODUCT USAGE IMPROPER INSTALLATIONIMPORTANT INFORMATION OPERATION GUIDELINES Glass doors should be installed to receive the maximum benefit from your fireplace. For large fires, the maximum heating benefit from the fireplace will be obtained with the doors open due to the high amount of radiant heat being emitted out of the front opening of the fireplace. With a small fire, or before retiring in the evenings, it is best to operate the fireplace with the doors closed to prevent excessive room air from being drawn up the chimney. When the doors are open, the mesh screens should be closed to help keep burning embers from popping out of the fireboxCLEARANCES RESIDENTIAL INSTALLATION53D9032. Rev 1 03/03 CLEARANCES21 1/2 MIN CAUTION Do not install fireplace over carpetingWITH GLASS DOORS INSTALLED FIREPLACE LOCATIONJOIST INSULATE SAME INSTALLATION PREPARATIONSINGLE STORY INSTALLATION WITH ATTIC SPACE INSTALLATION PREPARATION53D9032. Rev 1 03/03 FLOOR PROTECTION If this fireplace is installed on a combustible floor, the floor area 20 inches in front of, and 12 inches either side of the fireplace opening must be protected by an insulating noncombustible hearth extension. This hearth extension may be either minimum 6-inch thick stone or brick as shown by Figure 10, an H2066 Hearth Extension Kit or a locally constructed hearth equivalent to the H2066FIREPLACE HEARTH FLOOR METAL SAFETY STRIPFLOOR PROTECTION FLOOR LINE WITH RAISED HEARTHFP-4-U FIREPLACE COMPONENTSGD42B OR GD42PB SC ROUNDMODEL FIREPLACE COMPONENTSDESCRIPTION FIREPLACE INSTALLATION 53D9032. Rev 1 03/03 CHIMNEY INSTALLATION53D9032. Rev 1 03/03 CHIMNEY INSTALLATIONSTRAPS MUST BE NAILED ON TO FRAMING MEMBER CHIMNEY OFFSET INSTALLATIONREQUIRED TO BE SECURED FOR ADDED STABILIZATION OF PIPE14 FT CHIMNEY OFFSET AND CAP INSTALLATION14-1/2 22-1/16CHIMNEY CAP INSTALLATION 53D9032. Rev 1 03/03 CHIMNEY HEIGHT AND OFFSET CHARTSCHIMNEY CAP CHASE INSTALLATION 53D9032. Rev 1 03/03 OUTSIDE COMBUSTION AIR PRECAUTIONS & RECOMMENDATIONSOUTSIDE COMBUSTION AIR PRECAUTIONS & RECOMMENDATIONS MODEL AK4 COMBUSTION AIR ASSEMBLY COMBUSTION AIR ASSEMBLY53D9032. Rev 1 03/03 53D9032. Rev 1 03/03 GAS APPLIANCE INSTALLATIONGAS LINE PLUMBING DETAIL GAS APPLIANCE INSTALLATION1/4 SCREENED OPENING FINISHED WALL SCREENED OPENING OF FIREPLACE TRIM INSTALLATIONFRAMING EXTEND LINE FROM OPPOSITE REAR OF FIREBOX THRU A POINT 4 IN FRONT OF FIREPLACE FACE, AND 1 OUTSIDE OF53D9032. Rev 1 03/03 GLASS DOOR INSTALLATION AND FAN ACCESSORYGLASS DOOR INSTALLATION FAN ASSEMBLYWHICH WOODS ARE BEST? HOW TO BUILD A BETTER FIREFIREPLACE OPERATION ADVANTAGES OF A WOOD BURNING FIREPLACEHEAT VALUE FIREPLACE OPERATIONSPECIES DENSITYDISPOSAL OF ASHES MAINTENANCE AND SAFETYCHIMNEY MAINTENANCE FUEL STORAGEDO’S MAINTENANCE AND SAFETYDONT’S MAINTENANCE AND SAFETYBWB500 / BWB500I MODEL FIREPLACE REPAIR PART DIAGRAMS AND LISTSREPAIR PART DIAGRAMS AND LISTS BWBC500 / BWBC500I MODEL FIREPLACEFACTORY-BUILT FIREPLACE AND COMPONENTS LIMITED WARRANTYEXCEPT BLOWERS Technical Service Department LIMITED WARRANTY2813 W. Mall Drive, Unit B. Florence, Alabama Tel THIS PAGE INTENTIONALLY LEFT BLANK 53D9032. Rev 1 03/03THIS PAGE INTENTIONALLY LEFT BLANK 53D9032. Rev 1 03/03TO THE CONSUMER PLEASE RETURN THIS OPERATING AND INSTALLATION INSTRUCTIONS53D9032. REV 1 03/03 APPLIANCE INSTALLER