Manuals / Monessen Hearth / Outdoor Cooking / Fire Pit

Monessen Hearth BWB400I manual Parts Diagram And List, BWBC400/BWBC400I, Model Fireplace

Models: BWB400 BWBC400I

1 80

Page 35

PARTS DIAGRAM AND LIST

All repair part orders should be placed through your local dealer. To ensure prompt and accurate service, please provide the following information when placing a repair part order: Model number of your Appliance, Part Name, Part Number, and Quantity of parts needed.

Technical Service Department

2813 W. Mall Drive, Unit B. Florence, Alabama 35630.

Tel. - 1-866-500-5671

www.monessenhearth.com

BWBC400/BWBC400I

MODEL FIREPLACE

KEY NO.	PART NAME	QTY.	PART NUMBER
1	UPPER GRILLE PNTD. ASSY.	1	077000
2	WELDMENT AIR DOOR ROD	2	031867
3	FIRESCREEN PANELS	1	070940
4	FIREBRICK BACK ASSY.	1	031871
5	FIREBRICK SIDE ASSY.	2	031872
6	LEDGE HEARTH PNTD. ASSY.	1	077151
7	LOWER GRILLE PNTD. ASSY.	1	020362
8	GRATE PNTD. ASSY.	1	055119
9	HEARTH REFRACTORY ASSY.	1	031873

53D9031. Rev 1 03/03

Page 35

Image 35

Monessen Hearth BWB400I manual Parts Diagram And List, BWBC400/BWBC400I, Model Fireplace

Contents

BWB400-SERIES INSTALLATION, OPERATION AND MAINTENANCE MANUALBWB400, BWB400I, BWBC400 AND BWBC400I WOOD BURNING FIREPLACESLISTING AND CODE APPROVALS TABLE OF CONTENTSCONGRATULATIONS 4. Leakage of rain water into the dwelling IMPORTANT INFORMATION1. Damage to the fireplace from overheating 3. The emission of smoke, sparks or hazardous gases into the dwellingOPERATION GUIDELINES OPERATION GUIDELINES CLEARANCESRESIDENTIAL INSTALLATION CLEARANCES OUTSIDE AIR CONNECTOR CENTERLINE 13 1/8 TOP VIEWCAUTION Do not install fireplace over carpeting FIREPLACE LOCATIONINSTALLATION PREPARATION MULTIPLE STORY INSTALLATION INSTALLATION PREPARATIONSINGLE STORY INSTALLATION WITH ATTIC SPACE FLOOR PROTECTION C=K divided by the material thickness Example C = .43 divided by 1/2 FLOOR PROTECTIONR4884 48 FIREPLACE COMPONENTSR3672 36 DESCRIPTION FIREPLACE COMPONENTSMODEL FIREPLACE INSTALLATION CHIMNEY INSTALLATION 0/12 CHIMNEY INSTALLATIONCHIMNEY OFFSET INSTALLATION 30 ˚ CHIMNEY OFFSET AND CAP INSTALLATION14-1/2 22-1/16CHIMNEY CAP INSTALLATION CHIMNEY HEIGHT AND OFFSET CHARTS FLAT FLASHING OR CHASE COVER WITH 11-1/4 MIN. DIA. HOLE CHIMNEY CAP CHASE INSTALLATIONCHIMNEY CAP SUPPORT BRACKETS. 3 PLACES SCREW MAINTAIN CHIMNEY SYSTEM AIR SPACE CLEARANCES TO COMBUSTIBLES ABOVE ROOF LINEOUTSIDE COMBUSTION AIR PRECAUTIONS AND RECOMMENDATIONS OUTSIDE COMBUSTION AIR PRECAUTIONS & RECOMMENDATIONS IMPORTANT NOTICES COMBUSTION AIR ASSEMBLYGAS APPLIANCE INSTALLATION CAUTION If an unvented gas appliance is installed in the fireplace, the gas appliance must only be operated with the fireplace glass door fully open if included. Only unvented gas log set which have been found to comply with the standard for unvented room heaters, ANSI/IAS/AGA Z21.11.2, are to be installed in this fireplace GAS APPLIANCE INSTALLATION1 1/2 TRIM INSTALLATIONGAS APPLIANCE INSTALLATION 12 MAXPART C TRIM INSTALLATIONPART A PART BGLASS DOOR INSTALLATION AND FAN ACCESSORY FIREPLACE OPERATION Dogwood FIREPLACE OPERATIONMAINTENANCE AND SAFETY DO’S MAINTENANCE AND SAFETYDONT’S MAINTENANCE AND SAFETYBWB400/BWB400I MODEL FIREPLACE PARTS DIAGRAM AND LISTMODEL FIREPLACE PARTS DIAGRAM AND LISTBWBC400/BWBC400I EXCEPT BLOWERS LIMITED WARRANTYFACTORY-BUILT FIREPLACE AND COMPONENTS YOUR DUTIES LIMITED WARRANTYIF YOU HAVE A PROBLEM WITH YOUR FIREPLACE OR COMPONENT 53D9031. Rev 1 03/03 This page intentionally left blank53D9031. Rev 1 03/03 This page intentionally left blank53D9031. Rev 1 03/03 APPLIANCE INSTALLERPLEASE RETURN THESE OPERATING AND INSTALLATION INSTRUCTIONS TO THE CONSUMERINSTALLATION, OPERATION AND MAINTENANCE MANUAL BWB500, BWB500I, BWBC500 ANDBWBC500I RESIDENTIAL FIREPLACES SF42 SERIESLISTING AND CODE APPROVALS TABLE OF CONTENTSCONGRATULATIONS Chimney Cap Chase InstallationIMPORTANT INFORMATION IMPROPER INSTALLATIONINTENDED PRODUCT USAGE OPERATION GUIDELINES Glass doors should be installed to receive the maximum benefit from your fireplace. For large fires, the maximum heating benefit from the fireplace will be obtained with the doors open due to the high amount of radiant heat being emitted out of the front opening of the fireplace. With a small fire, or before retiring in the evenings, it is best to operate the fireplace with the doors closed to prevent excessive room air from being drawn up the chimney. When the doors are open, the mesh screens should be closed to help keep burning embers from popping out of the fireboxCLEARANCES RESIDENTIAL INSTALLATION53D9032. Rev 1 03/03 CLEARANCES21 1/2 MIN CAUTION Do not install fireplace over carpetingWITH GLASS DOORS INSTALLED FIREPLACE LOCATIONJOIST INSULATE SAME INSTALLATION PREPARATION53D9032. Rev 1 03/03 INSTALLATION PREPARATIONSINGLE STORY INSTALLATION WITH ATTIC SPACE FLOOR PROTECTION If this fireplace is installed on a combustible floor, the floor area 20 inches in front of, and 12 inches either side of the fireplace opening must be protected by an insulating noncombustible hearth extension. This hearth extension may be either minimum 6-inch thick stone or brick as shown by Figure 10, an H2066 Hearth Extension Kit or a locally constructed hearth equivalent to the H2066FIREPLACE HEARTH FLOOR METAL SAFETY STRIPFLOOR PROTECTION FLOOR LINE WITH RAISED HEARTHFP-4-U FIREPLACE COMPONENTSGD42B OR GD42PB SC ROUNDDESCRIPTION FIREPLACE COMPONENTSMODEL FIREPLACE INSTALLATION 53D9032. Rev 1 03/03 CHIMNEY INSTALLATION53D9032. Rev 1 03/03 CHIMNEY INSTALLATIONSTRAPS MUST BE NAILED ON TO FRAMING MEMBER CHIMNEY OFFSET INSTALLATIONREQUIRED TO BE SECURED FOR ADDED STABILIZATION OF PIPE14 FT CHIMNEY OFFSET AND CAP INSTALLATION14-1/2 22-1/16CHIMNEY CAP INSTALLATION 53D9032. Rev 1 03/03 CHIMNEY HEIGHT AND OFFSET CHARTSCHIMNEY CAP CHASE INSTALLATION 53D9032. Rev 1 03/03 OUTSIDE COMBUSTION AIR PRECAUTIONS & RECOMMENDATIONSOUTSIDE COMBUSTION AIR PRECAUTIONS & RECOMMENDATIONS 53D9032. Rev 1 03/03 COMBUSTION AIR ASSEMBLYMODEL AK4 COMBUSTION AIR ASSEMBLY 53D9032. Rev 1 03/03 GAS APPLIANCE INSTALLATIONGAS LINE PLUMBING DETAIL GAS APPLIANCE INSTALLATION1/4 SCREENED OPENING FINISHED WALL SCREENED OPENING OF FIREPLACE TRIM INSTALLATIONFRAMING EXTEND LINE FROM OPPOSITE REAR OF FIREBOX THRU A POINT 4 IN FRONT OF FIREPLACE FACE, AND 1 OUTSIDE OF53D9032. Rev 1 03/03 GLASS DOOR INSTALLATION AND FAN ACCESSORYGLASS DOOR INSTALLATION FAN ASSEMBLYWHICH WOODS ARE BEST? HOW TO BUILD A BETTER FIREFIREPLACE OPERATION ADVANTAGES OF A WOOD BURNING FIREPLACEHEAT VALUE FIREPLACE OPERATIONSPECIES DENSITYDISPOSAL OF ASHES MAINTENANCE AND SAFETYCHIMNEY MAINTENANCE FUEL STORAGEDO’S MAINTENANCE AND SAFETYDONT’S MAINTENANCE AND SAFETYBWB500 / BWB500I MODEL FIREPLACE REPAIR PART DIAGRAMS AND LISTSREPAIR PART DIAGRAMS AND LISTS BWBC500 / BWBC500I MODEL FIREPLACEEXCEPT BLOWERS LIMITED WARRANTYFACTORY-BUILT FIREPLACE AND COMPONENTS 2813 W. Mall Drive, Unit B. Florence, Alabama Tel LIMITED WARRANTYTechnical Service Department THIS PAGE INTENTIONALLY LEFT BLANK 53D9032. Rev 1 03/03THIS PAGE INTENTIONALLY LEFT BLANK 53D9032. Rev 1 03/03TO THE CONSUMER PLEASE RETURN THIS OPERATING AND INSTALLATION INSTRUCTIONS53D9032. REV 1 03/03 APPLIANCE INSTALLER