Manuals / Monessen Hearth / Outdoor Cooking / Fire Pit

Monessen Hearth BWBC400I BWB500, BWB500I, BWBC500 AND, BWBC500I RESIDENTIAL FIREPLACES, SCF42

Models: BWB400 BWBC400I

1 80

Download 80 pages 49.21 Kb

Page 41

Image 41

BWB500, BWB500I, BWBC500 AND

BWBC500I RESIDENTIAL FIREPLACES

INSTALLATION, OPERATION AND MAINTENANCE MANUAL

42INCH BUILT-IN WOOD BURNING FIREPLACES. (GLASS DOORS, FAN ASSEMBLY, AND OUTSIDE COMBUSTION AIR KIT AVAILABLE.)

SF42

SERIES

THESE FIREPLACES ARE U. L.® LISTED FOR USE
WITH "S" SERIES CHIMNEY SYSTEM COMPONENTS.	SCF42
	SERIES

ONLY UNVENTED GAS LOG SETS WHICH HAVE BEEN FOUND TO COMPLY WITH THE STANDARD FOR UNVENTED ROOM HEATERS ANSI Z21.11.2 ARE TO BE INSTALLED IN THESE FIREPLACES. WHEN AN APPROVED ANSI Z21.11.2 UNVENTED ROOM HEATER IS INSTALLED IN ONE OF THESE FIREPLACES, AN H2853 CANOPY MUST ALSO BE INSTALLED.

WARNING: DO NOT OPERATE AN UNVENTED GAS LOG

SET IN ANY OF THESE FIREPLACES WITH THE CHIMNEY REMOVED.

53D9032. Rev 1 03/03

Page 41

Image 41

Monessen Hearth BWBC400I, BWB400 BWB500, BWB500I, BWBC500 AND, BWBC500I RESIDENTIAL FIREPLACES, SF42 SERIES, SCF42, Series

Contents

BWB400, BWB400I, BWBC400 AND INSTALLATION, OPERATION AND MAINTENANCE MANUALBWBC400I WOOD BURNING FIREPLACES BWB400-SERIESLISTING AND CODE APPROVALS TABLE OF CONTENTSCONGRATULATIONS 1. Damage to the fireplace from overheating IMPORTANT INFORMATION3. The emission of smoke, sparks or hazardous gases into the dwelling 4. Leakage of rain water into the dwellingOPERATION GUIDELINES OPERATION GUIDELINES CLEARANCESRESIDENTIAL INSTALLATION CLEARANCES OUTSIDE AIR CONNECTOR CENTERLINE 13 1/8 TOP VIEWCAUTION Do not install fireplace over carpeting FIREPLACE LOCATIONINSTALLATION PREPARATION MULTIPLE STORY INSTALLATION INSTALLATION PREPARATIONSINGLE STORY INSTALLATION WITH ATTIC SPACE FLOOR PROTECTION C=K divided by the material thickness Example C = .43 divided by 1/2 FLOOR PROTECTIONR4884 48 FIREPLACE COMPONENTSR3672 36 DESCRIPTION FIREPLACE COMPONENTSMODEL FIREPLACE INSTALLATION CHIMNEY INSTALLATION 0/12 CHIMNEY INSTALLATIONCHIMNEY OFFSET INSTALLATION 14-1/2 CHIMNEY OFFSET AND CAP INSTALLATION22-1/16 30 ˚CHIMNEY CAP INSTALLATION CHIMNEY HEIGHT AND OFFSET CHARTS CHIMNEY CAP SUPPORT BRACKETS. 3 PLACES SCREW MAINTAIN CHIMNEY CHIMNEY CAP CHASE INSTALLATIONSYSTEM AIR SPACE CLEARANCES TO COMBUSTIBLES ABOVE ROOF LINE FLAT FLASHING OR CHASE COVER WITH 11-1/4 MIN. DIA. HOLEOUTSIDE COMBUSTION AIR PRECAUTIONS AND RECOMMENDATIONS OUTSIDE COMBUSTION AIR PRECAUTIONS & RECOMMENDATIONS IMPORTANT NOTICES COMBUSTION AIR ASSEMBLYGAS APPLIANCE INSTALLATION CAUTION If an unvented gas appliance is installed in the fireplace, the gas appliance must only be operated with the fireplace glass door fully open if included. Only unvented gas log set which have been found to comply with the standard for unvented room heaters, ANSI/IAS/AGA Z21.11.2, are to be installed in this fireplace GAS APPLIANCE INSTALLATIONGAS APPLIANCE INSTALLATION TRIM INSTALLATION12 MAX 1 1/2PART A TRIM INSTALLATIONPART B PART CGLASS DOOR INSTALLATION AND FAN ACCESSORY FIREPLACE OPERATION Dogwood FIREPLACE OPERATIONMAINTENANCE AND SAFETY DO’S MAINTENANCE AND SAFETYDONT’S MAINTENANCE AND SAFETYBWB400/BWB400I MODEL FIREPLACE PARTS DIAGRAM AND LISTMODEL FIREPLACE PARTS DIAGRAM AND LISTBWBC400/BWBC400I EXCEPT BLOWERS LIMITED WARRANTYFACTORY-BUILT FIREPLACE AND COMPONENTS YOUR DUTIES LIMITED WARRANTYIF YOU HAVE A PROBLEM WITH YOUR FIREPLACE OR COMPONENT 53D9031. Rev 1 03/03 This page intentionally left blank53D9031. Rev 1 03/03 This page intentionally left blankPLEASE RETURN THESE OPERATING AND INSTALLATION INSTRUCTIONS APPLIANCE INSTALLERTO THE CONSUMER 53D9031. Rev 1 03/03BWBC500I RESIDENTIAL FIREPLACES BWB500, BWB500I, BWBC500 ANDSF42 SERIES INSTALLATION, OPERATION AND MAINTENANCE MANUALCONGRATULATIONS TABLE OF CONTENTSChimney Cap Chase Installation LISTING AND CODE APPROVALSIMPORTANT INFORMATION IMPROPER INSTALLATIONINTENDED PRODUCT USAGE OPERATION GUIDELINES Glass doors should be installed to receive the maximum benefit from your fireplace. For large fires, the maximum heating benefit from the fireplace will be obtained with the doors open due to the high amount of radiant heat being emitted out of the front opening of the fireplace. With a small fire, or before retiring in the evenings, it is best to operate the fireplace with the doors closed to prevent excessive room air from being drawn up the chimney. When the doors are open, the mesh screens should be closed to help keep burning embers from popping out of the fireboxCLEARANCES RESIDENTIAL INSTALLATION53D9032. Rev 1 03/03 CLEARANCESWITH GLASS DOORS INSTALLED CAUTION Do not install fireplace over carpetingFIREPLACE LOCATION 21 1/2 MINJOIST INSULATE SAME INSTALLATION PREPARATION53D9032. Rev 1 03/03 INSTALLATION PREPARATIONSINGLE STORY INSTALLATION WITH ATTIC SPACE FLOOR PROTECTION If this fireplace is installed on a combustible floor, the floor area 20 inches in front of, and 12 inches either side of the fireplace opening must be protected by an insulating noncombustible hearth extension. This hearth extension may be either minimum 6-inch thick stone or brick as shown by Figure 10, an H2066 Hearth Extension Kit or a locally constructed hearth equivalent to the H2066FLOOR PROTECTION FLOOR METAL SAFETY STRIPFLOOR LINE WITH RAISED HEARTH FIREPLACE HEARTHGD42B OR GD42PB FIREPLACE COMPONENTSSC ROUND FP-4-UDESCRIPTION FIREPLACE COMPONENTSMODEL FIREPLACE INSTALLATION 53D9032. Rev 1 03/03 CHIMNEY INSTALLATION53D9032. Rev 1 03/03 CHIMNEY INSTALLATIONREQUIRED TO BE SECURED FOR CHIMNEY OFFSET INSTALLATIONADDED STABILIZATION OF PIPE STRAPS MUST BE NAILED ON TO FRAMING MEMBER14-1/2 CHIMNEY OFFSET AND CAP INSTALLATION22-1/16 14 FTCHIMNEY CAP INSTALLATION 53D9032. Rev 1 03/03 CHIMNEY HEIGHT AND OFFSET CHARTSCHIMNEY CAP CHASE INSTALLATION 53D9032. Rev 1 03/03 OUTSIDE COMBUSTION AIR PRECAUTIONS & RECOMMENDATIONSOUTSIDE COMBUSTION AIR PRECAUTIONS & RECOMMENDATIONS 53D9032. Rev 1 03/03 COMBUSTION AIR ASSEMBLYMODEL AK4 COMBUSTION AIR ASSEMBLY 53D9032. Rev 1 03/03 GAS APPLIANCE INSTALLATIONGAS LINE PLUMBING DETAIL GAS APPLIANCE INSTALLATIONFRAMING EXTEND LINE FROM OPPOSITE REAR OF TRIM INSTALLATIONFIREBOX THRU A POINT 4 IN FRONT OF FIREPLACE FACE, AND 1 OUTSIDE OF 1/4 SCREENED OPENING FINISHED WALL SCREENED OPENING OF FIREPLACEGLASS DOOR INSTALLATION GLASS DOOR INSTALLATION AND FAN ACCESSORYFAN ASSEMBLY 53D9032. Rev 1 03/03FIREPLACE OPERATION HOW TO BUILD A BETTER FIREADVANTAGES OF A WOOD BURNING FIREPLACE WHICH WOODS ARE BEST?SPECIES FIREPLACE OPERATIONDENSITY HEAT VALUECHIMNEY MAINTENANCE MAINTENANCE AND SAFETYFUEL STORAGE DISPOSAL OF ASHESDO’S MAINTENANCE AND SAFETYDONT’S MAINTENANCE AND SAFETYBWB500 / BWB500I MODEL FIREPLACE REPAIR PART DIAGRAMS AND LISTSREPAIR PART DIAGRAMS AND LISTS BWBC500 / BWBC500I MODEL FIREPLACEEXCEPT BLOWERS LIMITED WARRANTYFACTORY-BUILT FIREPLACE AND COMPONENTS 2813 W. Mall Drive, Unit B. Florence, Alabama Tel LIMITED WARRANTYTechnical Service Department THIS PAGE INTENTIONALLY LEFT BLANK 53D9032. Rev 1 03/03THIS PAGE INTENTIONALLY LEFT BLANK 53D9032. Rev 1 03/0353D9032. REV 1 03/03 PLEASE RETURN THIS OPERATING AND INSTALLATION INSTRUCTIONSAPPLIANCE INSTALLER TO THE CONSUMER