Manuals / Monessen Hearth / Outdoor Cooking / Fire Pit

Monessen Hearth BWBC400, BWB400 Chimney Offset And Cap Installation, 14-1/2, 22-1/16, 14 FT, 9/16

Models: BWB400 BWBC400I

1 80

Download 80 pages 49.21 Kb

Page 58

Manual background

CHIMNEY OFFSET AND CAP INSTALLATION

FIGURE 19		14-1/2"
		22-1/16"
	-9/16"	-1/4"
	-9/16"	7
		7
	7

30˚ CENTERLINE OF CHIMNEY

SF30 FIRESTOP SPACER

FIGURE 20

C

L

STORM COLLAR

FLASHING

ROOF

CONTINUE CHIMNEY TO PROPER HEIGHT AND INSTALL ROUND CHIMNEY CAP OR CHIMNEY HOUSING.

SF FIRESTOP SPACER.

1-3/4"MINIMUM AIR SPACE CLEARANCE TO COMBUSTIBLES.

C

L

FIGURE 21

SUPPORT STRAPS

NOT TO PENETRATE

FIRESTOP

VERTICAL CHIMNEY

ENCLOSURE

FASTEN ALL SUPPORT

STRAPS SECURELY.

VERTICAL CHIMNEY

ENCLOSURE

RECOMMENDED.

DIAGONAL CHIMNEY

ENCLOSURE

ACCEPTABLE.

CONTINUE CHIMNEY THROUGH ROOF AND

INSTALL ROUND CHIMNEY CAP OR CHIMNEY

HOUSING.

SF FIRESTOP SPACER.

1-3/4"MINIMUM AIR SPACE CLEARANCE TO COMBUSTIBLES.

CHIMNEY MUST BE ENCLOSED

IN ACCESSIBLE AREAS.

VERTICAL CHIMNEY

ENCLOSURE

SF FIRESTOP SPACER.

1-3/4"MINIMUM AIR SPACE CLEARANCE TO COMBUSTIBLES.

DIAGONAL

CHIMNEY

ENCLOSURE

RISE

FIGURE 22

SCRIBE LINE

AT BOTTOM

FASTEN SUPPORT STRAPS SECURELY

NOTE: TWO ELBOWS

MAY BE USED WHEN

TOTAL INSTALLATION

HEIGHT EXCEEDS

14 FT.

HOLD PIPE

VERTICAL

DIAGONAL CHIMNEY ENCLOSURE

SUPPORT

STRAPS

10 FEET

(MAXIMUM OFFSET.)

NOTE: SCL CHIMNEY CAP

IS SAME AS SC WITH THE

EXCEPTION OF A LONGER TELESCOPING

PIPE WHICH MAY BE NEEDED FOR SPECIAL

INSTALLATIONS SUCH AS CHASE INSTALLATIONS.

SF FIRESTOP SPACER.

C	1-3/4"MINIMUM AIR	MODEL SC	18-1/2"
	SPACE CLEARANCE
L	TO COMBUSTIBLES.	CHIMNEY CAP

NOTE: FOUR ELBOWS MAY BE USED WHEN TOTAL INSTALLATION HEIGHT

36"

APPLY MASTIC HERE

EXCEEDS 21 FT.

MAXIMUM 4 ELBOWS PER FIREPLACE.

STORM COLLAR

FLASHING

18

53D9032. Rev 1 03/03

Image 58

Monessen Hearth BWBC400I, BWB400I manual Chimney Offset And Cap Installation, 14-1/2, 22-1/16, 14 FT, 9/16

Contents

BWBC400I WOOD BURNING FIREPLACES INSTALLATION, OPERATION AND MAINTENANCE MANUALBWB400, BWB400I, BWBC400 AND BWB400-SERIESCONGRATULATIONS TABLE OF CONTENTSLISTING AND CODE APPROVALS 3. The emission of smoke, sparks or hazardous gases into the dwelling IMPORTANT INFORMATION1. Damage to the fireplace from overheating 4. Leakage of rain water into the dwellingOPERATION GUIDELINES RESIDENTIAL INSTALLATION CLEARANCESOPERATION GUIDELINES OUTSIDE AIR CONNECTOR CENTERLINE 13 1/8 TOP VIEW CLEARANCESFIREPLACE LOCATION CAUTION Do not install fireplace over carpetingINSTALLATION PREPARATION SINGLE STORY INSTALLATION WITH ATTIC SPACE INSTALLATION PREPARATIONMULTIPLE STORY INSTALLATION FLOOR PROTECTION FLOOR PROTECTION C=K divided by the material thickness Example C = .43 divided by 1/2R3672 36 FIREPLACE COMPONENTSR4884 48 MODEL FIREPLACE COMPONENTSDESCRIPTION FIREPLACE INSTALLATION CHIMNEY INSTALLATION CHIMNEY INSTALLATION 0/12CHIMNEY OFFSET INSTALLATION 22-1/16 CHIMNEY OFFSET AND CAP INSTALLATION14-1/2 30 ˚CHIMNEY CAP INSTALLATION CHIMNEY HEIGHT AND OFFSET CHARTS SYSTEM AIR SPACE CLEARANCES TO COMBUSTIBLES ABOVE ROOF LINE CHIMNEY CAP CHASE INSTALLATIONCHIMNEY CAP SUPPORT BRACKETS. 3 PLACES SCREW MAINTAIN CHIMNEY FLAT FLASHING OR CHASE COVER WITH 11-1/4 MIN. DIA. HOLEOUTSIDE COMBUSTION AIR PRECAUTIONS AND RECOMMENDATIONS OUTSIDE COMBUSTION AIR PRECAUTIONS & RECOMMENDATIONS GAS APPLIANCE INSTALLATION COMBUSTION AIR ASSEMBLYIMPORTANT NOTICES GAS APPLIANCE INSTALLATION CAUTION If an unvented gas appliance is installed in the fireplace, the gas appliance must only be operated with the fireplace glass door fully open if included. Only unvented gas log set which have been found to comply with the standard for unvented room heaters, ANSI/IAS/AGA Z21.11.2, are to be installed in this fireplace12 MAX TRIM INSTALLATIONGAS APPLIANCE INSTALLATION 1 1/2PART B TRIM INSTALLATIONPART A PART CGLASS DOOR INSTALLATION AND FAN ACCESSORY FIREPLACE OPERATION FIREPLACE OPERATION DogwoodMAINTENANCE AND SAFETY MAINTENANCE AND SAFETY DO’SMAINTENANCE AND SAFETY DONT’SPARTS DIAGRAM AND LIST BWB400/BWB400I MODEL FIREPLACEBWBC400/BWBC400I PARTS DIAGRAM AND LISTMODEL FIREPLACE FACTORY-BUILT FIREPLACE AND COMPONENTS LIMITED WARRANTYEXCEPT BLOWERS IF YOU HAVE A PROBLEM WITH YOUR FIREPLACE OR COMPONENT LIMITED WARRANTYYOUR DUTIES This page intentionally left blank 53D9031. Rev 1 03/03This page intentionally left blank 53D9031. Rev 1 03/03TO THE CONSUMER APPLIANCE INSTALLERPLEASE RETURN THESE OPERATING AND INSTALLATION INSTRUCTIONS 53D9031. Rev 1 03/03SF42 SERIES BWB500, BWB500I, BWBC500 ANDBWBC500I RESIDENTIAL FIREPLACES INSTALLATION, OPERATION AND MAINTENANCE MANUALChimney Cap Chase Installation TABLE OF CONTENTSCONGRATULATIONS LISTING AND CODE APPROVALSINTENDED PRODUCT USAGE IMPROPER INSTALLATIONIMPORTANT INFORMATION Glass doors should be installed to receive the maximum benefit from your fireplace. For large fires, the maximum heating benefit from the fireplace will be obtained with the doors open due to the high amount of radiant heat being emitted out of the front opening of the fireplace. With a small fire, or before retiring in the evenings, it is best to operate the fireplace with the doors closed to prevent excessive room air from being drawn up the chimney. When the doors are open, the mesh screens should be closed to help keep burning embers from popping out of the firebox OPERATION GUIDELINESRESIDENTIAL INSTALLATION CLEARANCESCLEARANCES 53D9032. Rev 1 03/03FIREPLACE LOCATION CAUTION Do not install fireplace over carpetingWITH GLASS DOORS INSTALLED 21 1/2 MININSTALLATION PREPARATION JOIST INSULATE SAMESINGLE STORY INSTALLATION WITH ATTIC SPACE INSTALLATION PREPARATION53D9032. Rev 1 03/03 If this fireplace is installed on a combustible floor, the floor area 20 inches in front of, and 12 inches either side of the fireplace opening must be protected by an insulating noncombustible hearth extension. This hearth extension may be either minimum 6-inch thick stone or brick as shown by Figure 10, an H2066 Hearth Extension Kit or a locally constructed hearth equivalent to the H2066 FLOOR PROTECTIONFLOOR LINE WITH RAISED HEARTH FLOOR METAL SAFETY STRIPFLOOR PROTECTION FIREPLACE HEARTHSC ROUND FIREPLACE COMPONENTSGD42B OR GD42PB FP-4-UMODEL FIREPLACE COMPONENTSDESCRIPTION FIREPLACE INSTALLATION CHIMNEY INSTALLATION 53D9032. Rev 1 03/03CHIMNEY INSTALLATION 53D9032. Rev 1 03/03ADDED STABILIZATION OF PIPE CHIMNEY OFFSET INSTALLATIONREQUIRED TO BE SECURED FOR STRAPS MUST BE NAILED ON TO FRAMING MEMBER22-1/16 CHIMNEY OFFSET AND CAP INSTALLATION14-1/2 14 FTCHIMNEY CAP INSTALLATION CHIMNEY HEIGHT AND OFFSET CHARTS 53D9032. Rev 1 03/03CHIMNEY CAP CHASE INSTALLATION OUTSIDE COMBUSTION AIR PRECAUTIONS & RECOMMENDATIONS 53D9032. Rev 1 03/03OUTSIDE COMBUSTION AIR PRECAUTIONS & RECOMMENDATIONS MODEL AK4 COMBUSTION AIR ASSEMBLY COMBUSTION AIR ASSEMBLY53D9032. Rev 1 03/03 GAS APPLIANCE INSTALLATION 53D9032. Rev 1 03/03GAS APPLIANCE INSTALLATION GAS LINE PLUMBING DETAILFIREBOX THRU A POINT 4 IN FRONT OF FIREPLACE FACE, AND 1 OUTSIDE OF TRIM INSTALLATIONFRAMING EXTEND LINE FROM OPPOSITE REAR OF 1/4 SCREENED OPENING FINISHED WALL SCREENED OPENING OF FIREPLACEFAN ASSEMBLY GLASS DOOR INSTALLATION AND FAN ACCESSORYGLASS DOOR INSTALLATION 53D9032. Rev 1 03/03ADVANTAGES OF A WOOD BURNING FIREPLACE HOW TO BUILD A BETTER FIREFIREPLACE OPERATION WHICH WOODS ARE BEST?DENSITY FIREPLACE OPERATIONSPECIES HEAT VALUEFUEL STORAGE MAINTENANCE AND SAFETYCHIMNEY MAINTENANCE DISPOSAL OF ASHESMAINTENANCE AND SAFETY DO’SMAINTENANCE AND SAFETY DONT’SREPAIR PART DIAGRAMS AND LISTS BWB500 / BWB500I MODEL FIREPLACEBWBC500 / BWBC500I MODEL FIREPLACE REPAIR PART DIAGRAMS AND LISTSFACTORY-BUILT FIREPLACE AND COMPONENTS LIMITED WARRANTYEXCEPT BLOWERS Technical Service Department LIMITED WARRANTY2813 W. Mall Drive, Unit B. Florence, Alabama Tel 53D9032. Rev 1 03/03 THIS PAGE INTENTIONALLY LEFT BLANK53D9032. Rev 1 03/03 THIS PAGE INTENTIONALLY LEFT BLANKAPPLIANCE INSTALLER PLEASE RETURN THIS OPERATING AND INSTALLATION INSTRUCTIONS53D9032. REV 1 03/03 TO THE CONSUMER