Disposal, Storage Maintenance | Toshiba G8000 Series instruction

Storage Maintenance

∙If stored at an ambient temperature less than 20° C (68° F), recharge the batteries every 9 months.

∙	If stored at an ambient temperature of 20° – 30° C	(68°	– 86° F), recharge the batteries every 6 mont	hs.
∙	If stored at an ambient temperature of 30° – 40° C	(86°	– 104° F), recharge the batteries every 3 mon	ths.

Disposal

Please contact your local or state environmental agency for details on disposal of electrical components and packaging in your particular area.

It is illegal to dump lead-acid batteries in landfills or dispose of improperly.

Please help our Earth by contacting the environmental protection agencies in your area, the battery manufacturer, or call Toshiba toll-free at (800) 231-1412 for more information about recycling.

10

Image 11

Toshiba G8000 Series operation manual Disposal, Storage Maintenance

Contents

Document Number February Uninterruptible Power System UPS G8000 Series Introduction Uninterruptible Power Supply Contacting Toshiba’s Customer Support Center Manual’s Purpose and Scope Table of Contents Safety Alert Symbol General Safety Instructions Special Symbols Qualified Personnel only Maintenance PrecautionsPage Storing Conditions Storage Preparation Disposal Storage Maintenance Conductor Routing and Grounding Installation Precautions Mandatory UPS is to be installed in a controlled environmentDo not install the UPS close to a water source Connect ground wire to the earth ground terminal only Operating Precautions Important Safety Instructions Safety Precautions Do not open the front cover Personal injury Operators should be certified* personnel Faults by removing these panelsDo not remove the rear/side panels UPS exterior showing warning label locations Labeling Requirements UPS exterior/interior showing warning labels Battery Grounding Electrode Terminal Handling Precautions Do not operate the UPS in wet locations Keep the reset button pressed for 5 seconds to reset the UPS Do not open the front and/or rear panel Outline and Layout Shows the outline dimensions of the 300kVA UPS Recommended Cable Size and Tightening Torque for 150kVA UPS UPS Connections Cable knockout plates at the bottom 150 and 225kVA Recommended Cable Size and Tightening Torque for 225kVA UPS Recommended Cable Size and Tightening Torque for 300kVA UPS Battery Bypass Input Cable knockout plates at the top 300kVA Recommended Lugs Operating Switches Operating Switches Control Functions UPS Circuit Configuration Key-switch function Name Function Remarks Key-Switch and ButtonsKey-switch Name Function Remarks Operating ButtonsButton functions External Connections External Connections LED Indication Graphics Interface Name Function LCD/LED Legend Scroll up Scroll down LCD Indication Volt AC-VOAC- I O Sync Batt Discharging 15MINDC-V Another Item No Fault No WarningNo Alarm No Warning Fuse Blown UPS 35H Battery 56MIN Operate the UPS in the specified condition OperationOperation Types Operators should be qualified/trained personnel System Initialize ProceduresPre-operational check LED legend Off Flash Press the RUN button For 0.5 sec Startup Procedures Cont’d Press ‘UPS’ Switch Move #72B to ‘OFF’ Position Stopping procedureStop BATT-V Batt Press ‘RUN’ SwitchComplete Shutdown Step Procedure LCD/LED Status Complete Shutdown Float Charge LED Float Charge LED is On Equal Charge LED is Off Float Charge is On Equal CAHRGE* LED is Off Goes awayPress FLOAT/EQAUL Button for 0.5 sec Types of Errors Troubleshooting Fault Data Screen LCD Fault Displays Number of the message in the detection order 1 UPS Fault Messages LCD Message Description Indication UPS When the UPS has stopped due to a fault, be sure to removeLCD Scroll with faults or warnings Data needed to determine the cause of the fault Changing screens with scroll buttons Scroll Buttons Do not open the front and/or rear panels Contact Toshiba in the event of malfunction or faultRestoring UPS Operation Do not attempt to modify or relocate the UPS Mechanical Specification UPS SpecificationsGeneral Specification Rated Capacity 150kVA 120kW 225kVA 180kW 300kVA 240kW Electrical Specification Word Definitions Appendix