Weber 56568 manual Check the Flexible Hose to Manifold Connection, Check for GAS Leaks

Page 16

GAS INSTRUCTIONS

Remove Side Burner Cabinet Back Panel and

Side Burner Cabinet Water Deflector

Tools required: Phillips screwdriver..

A) Facing the back of the unit, remove screws that secure back panel of side burner

cabinet with a Phillips screwdriver (1)..

 

B) Remove back panel and set aside (2)..

 

C) Facing the front of the unit, open side burner cabinet door and remove screw

 

securing side burner cabinet water deflector (3)..

 

D) Facing the back of the unit, push water deflector forward to allow rear edge to drop

 

down.. Pivot down on an angle and remove from side burner cabinet (4).. ◆

 

CHECK THE FLEXIBLE HOSE TO MANIFOLD CONNECTION

 

The natural gas hose was attached during the manufacturing process.. We do

 

recommend that the hose to gas manifold connection be leak tested, following

 

guidelines in this Owner’s Guide, prior to barbecue operation.. ◆

 

CHECK FOR GAS LEAKS

 

m DANGER

 

Do not use an open flame to check for gas leaks. Be sure

 

there are no sparks or open flames in the area while you

 

check for leaks. Sparks or open flames will result in a fire

 

or explosion which can cause serious bodily injury or death

 

and damage to property.

 

Note: All factory-made connections have been thoroughly checked for gas leaks.The

 

burners have been flame-tested.As a safety precaution, however, you should recheck

 

all fittings for leaks before using your Weber® gas barbecue. Shipping and handling

 

may loosen or damage a gas fitting.

 

m WARNING: The gas connections of your gas grill have been

 

factory tested. We do however recommend that you leak

 

check all gas connections before operating your gas grill.

 

m WARNING: Perform these leak checks even if your barbecue

 

was dealer or store assembled.

 

If your grill has a side burner, make sure the side burner is turned off..

 

To perform leak checks: Slide back the collar of the quick disconnect (1).. Push male

 

fitting of the hose into the quick disconnect, and maintain pressure.. Slide the collar

1

closed (2).. If it does not engage or lock, repeat procedure.. Gas will not flow unless the

quick disconnect is properly engaged.. Turn on gas supply at source..

mWARNING: Do not ignite burners when leak checking.

You will need: A soap and water solution and a rag or brush to apply it..

A)Mix soap and water..

B)Turn on the gas supply (3)..

C)Check for leaks by wetting the fitting with the soap and water solution and watching for bubbles.. If bubbles form, or if a bubble grows, there is a leak..

If there is a leak, turn off the gas and tighten the fitting. Turn the gas back on and recheck with the soap and water solution. If leak does not stop do not use the barbecue. Contact the customer service representative in your area using the contact information on our web site. Log onto www.weber.com®.

D)When leak checking is complete, turn gas supply off at the source and rinse connections with water..

Note: Since some leak test solutions, including soap and water, may be slightly corrosive, all connections should be rinsed with water after checking for leaks.

mWARNING: You should check for gas leaks every time you disconnect and reconnect a gas fitting.

3

1

2

2

3

16

Page 15 Page 17
Image 16
Page 15 Page 17
Contents GAS Grill Liquid Propane GAS Units only Table of Contents Exploded View Diagrama DE Despiece VUE Eclatee Manifold Múltiple Collecteur Control Panel Wiring Harness IR Burner Igniter WireRotisserie Spit Assembly Thermometer BezelSUMMITGrill Center Left Cabinet121610 Faldón del bastidor derecho Exploded View Diagrama DE Despiece VUE Eclatee Cooler Enfriador Refroidisseur Corner Cabinet Top Panel Wok Ring Aro para wok Bague pour wok Side Burner GrateLeft Back Panel SUMMITGrill Center Social Center121610 Faldón del extremo derecho Warranty Canadian InstallationOperating GAS Supply Testing General InstructionsInstall GAS Supply General Specifications for PipingGAS Instructions Gas Line PipingWhat is Natural GAS? Type of GASSocket PlugCheck That All Burner Valves Are Off Leak Check PreparationRemove Control Panel Check the Flexible Hose to Manifold Connection Check for GAS LeaksReinstall Side Burner Cabinet Water Deflector Reinstall Control PanelCheck Light Features Before Using Your GrillWeber Grill OUT Handle Light Lighted Control KnobsHose Inspection Snap Ignition OperationAlways open the lid before igniting the burners Main Burner Ignition & Usage Main Burner IgnitionTo Extinguish Main Burner Snap IgnitionMain Burner Manual Ignition Grilling Tips & Helpful Hints Flavorizer SystemSear Station Preheating Covered CookingDirect Cooking Cooking MethodsIndirect Cooking Side Burner Ignition & Usage Side Burner IgnitionBurner Manual Ignition Ignite Inner BurnerSide Burner Manual Ignition Side Burner Usage Wok CookingSear Station Burner Ignition Sear Station Ignition & UsageAdjacent Main Burner Snap Ignition Using the Sear Station Sear Station Burner Manual IgnitionSmoker Burner Ignition & Usage Smoker Burner IgnitionSmoker Burner Manual Ignition Smoker Burner Snap IgnitionOpen the lid Using the Smoker Cleaning the SmokerRotisserie Burner Ignition Rotisserie Burner Ignition & UsageRotisserie Burner Snap Ignition Rotisserie Burner Manual Ignition Important Safeguards Operating the RotisserieRotisserie Motor Storage Rotisserie CookingRotisserie Spit Storage Side Burner Troubleshooting TroubleshootingGrease tray with aluminum foil Rotisserie Troubleshooting Sear Station TroubleshootingGrill OUT Handle Light Troubleshooting Maintenance CleaningBurner Tube Cleaning Weber SPIDER/INSECT ScreensReplacing Main Burners 115 Removing The Sear Station BurnerCheck Igniter Wires on the Underside of the Side Burner Side Burner MaintenanceCheck Fit and Alignment of the Side Burner Components Inspection And Cleaning Of The Spider/Insect Screens Annual MaintenanceBurner Flame Pattern Barbacoa DE GAS Advertencias Únicamente Unidades DE GAS Propano LicuadoÍndice Instrucciones Sobre EL GASGarantía Instrucciones GeneralesInstrucciones Sobre EL GAS Instale EL Suministro DE GASEspecificaciones generales de la tubería Instalación de la tubería de gasTipo DE GAS ¿QUÉ ES EL GAS NATURAL?Preparativos Para LA Búsqueda DE Fugas Retire el panel de controlDetección DE Fugas DE GAS Revise Vuelva a instalar el panel de controlIluminación Antes DE Utilizar LA BarbacoaLámpara DEL ASA Weber Grill OUT Perillas DE Control IluminadasInspección DE LA Manguera Operación DEL Encendido DE ChasquidoSiempre abra la tapa antes encender los quemadores Encendido Y USO DEL Quemador Principal Encendido DEL Quemador PrincipalAdvertencia No se incline sobre la barbacoa abierta Para ApagarEncendido Manual DEL Quemador Principal Consejos Prácticos Para Asar Cocción Directa Métodos DE CocciónCocción Indirecta Encendido Y USO DEL Quemador Lateral Encendido DEL Quemador LateralEncienda el quemador interno Encienda el quemador externoEncendido Manual DEL Quemador Lateral USO DEL Quemador Lateral Cómo cocinar con woksEncendido Y USO DE LA Estación DE Dorado Sear Station Encendido DE LA Estación DE Dorado Sear Station Advertencia No se incline sobre la barbacoa abierta Cómo Usar LA Estación Para Dorar Sear StationEncendido DEL Quemador DEL Ahumador Encendido Y USO DEL Quemador DEL AhumadorEncendido rápido del quemador del ahumador Encendido Manual DEL Quemador DEL Ahumador Cómo Usar EL Ahumador Limpieza DEL AhumadorEncendido DEL Quemador DEL Asador Giratorio Encendido Y USO DEL Quemador DEL Asador GiratorioEncendido rápido del quemador del asador giratorio Encendido Manual DEL Quemador DEL Asador Giratorio Medidas Preventivas Importantes Operación DEL Asador GiratorioAlmacenaje DEL Motor DEL Asador Giratorio Cocción CON EL Asador GiratorioAlmacenaje DEL Espetón DEL Asador Giratorio Resolución DE Problemas Resolución DE Problemas CON EL Quemador LateralPrecaución No forre La bandeja del fondo conResolución DE Problemas DEL Asador Giratorio Resolución DE Problemas DE LA LUZ DEL ASA Grill OUTMantenimiento LimpiezaMallas Weber Contra Arañas E Insectos Limpieza DE Tubo DE QuemadorReemplazo DE LOS Quemadores Principales 104 132 143 Mantenimiento DEL Quemador Lateral Patrón de la llama del quemador Mantenimiento AnualTubo quemador Grill a GAZ Mises EN Garde Appareils a GAZ Propane UniquementTable DES Matieres Instructions Relatives AU GAZGarantie GeneralitesInstallation DE L’ALIMENTATION EN GAZ Instructions Relatives AU GAZSpécifications générales relatives à la canalisation Conduite de gazType DE GAZ QU’EST-CE QUE LE GAZ Naturel ?Preparation DE LA Detection DES Fuites Retirez votre panneau de commandesVerifiez que toutes les valves du bruleur sont fermees Detection DES Fuites DE GAZ Réinstallez le panneau de commande VérifiezBoutons DE Commandes Eclaires Fonctionnalites D’ECLAIRAGEAvant D’UTILISER Votre Grill Lampe DE Poignee Weber Grill OUTInspection DU Tuyau Utilisation DE L’ALLUMAGE SnapOuvrez toujours le couvercle avant d’allumer les brûleurs Allumage & Utilisation DU Bruleur Principal Allumage DU Brûleur PrincipalPour Eteindre Bouton d’allumage du bruleur principalAllumage Manuel DU Bruleur Principal Conseils & Astuces Pour LA Grillade Cuisson CouverteEcoulements DE JUS ET DE Graisses Système FlavorizerCuisson Directe Methodes DE CuissonCuisson Indirecte Allumage & Utilisation DU Bruleur Lateral Allumage DU Bruleur LateralAllumer le brûleur interne Allumer le brûleur externeAllumage Manuel DU Bruleur Lateral Utilisation DU Bruleur Lateral Cuisson au wokAllumage DU Bruleur Sear Station Allumage & Utilisation DE LA Sear StationAllumage automatique des bruleurs principaux adjacents Utilisation DU Bruleur Sear Station Allumage Manuel DU Bruleur Sear StationAllumage automatique du bruleur principal adjacent Allumage & Utilisation DU Bruleur DU Fumoir Allumage DU Bruleur DU FumoirAllumage Manuel DU Bruleur DU Fumoir Utilisation DU Fumoir Nettoyage DU FumoirAllumage & Utilisation DU Bruleur DE LA Rotissoire Allumage DU Bruleur DE LA RotissoireMise EN Garde Ne vous penchez pas au-dessus du grill ouvert Bouton d’allumage du bruleur de la rotissoireAllumage & Utilisation DU Bruleur DE LA Rotissoire Precautions DE Securite Importantes Utilisation DE LA RotissoireRangement DU Moteur DE LA Rotissoire Cuisson Avec LA RotissoireRangement DE LA Broche DE LA Rotissoire Depannage Depannage DU Bruleur LateralDepannage DE LA Rotissoire Depannage DE LA Sear StationDepannage DE L’ECLAIRAGE DE Poignee Grill OUT Grilles ANTI-ARAIGNEES/INSECTES Weber NettoyageNettoyage DE Tube DE Brûleur Remplacement DES Bruleurs Principaux Retirer le panneau de commandesRetrait du bruleur Sear Station Maintenance DU Bruleur Lateral Maintenance Annuelle Aspect des flammes du brûleurMemo WEBER-STEPHEN Products LLC
Top Page Image Contents