Porter-Cable A16759 Maintenance, Customer Responsibilities, To Check Safety Valve, To Drain Tank

Page 17

MAINTENANCE

Customer Responsibilities

	Before	Daily	Every	Every	Every	Every
	each	or after	8	40	160	100
	use	each	hours	hours	hours	hours
	use	use	hours	hours	hours	hours
		use
Check Safety Valve	●
Drain Tank		●
Oil Leaks			●
Check Oil			●
Change Oil						●
Air Filter				●1

1- more frequent in dusty or humid conditions

Unit cycles automatically when power is on. When performing maintenance, you may be exposed to voltage

sources, compressed air, or moving parts. Personal injuries can occur. Before performing any maintenance or repair, disconnect power source from the compressor and bleed off all air pressure.

To ensure efficient operation and longer life of the air compressor outfit, a routine maintenance schedule should be prepared and followed. The following routine maintenance schedule is geared to an outfit in a normal working environment operating on a daily basis. If necessary, the schedule should be modified to suit the conditions under which your compressor is used. The modifications will depend upon the hours of operation and the working environment. Compressor outfits in an extremely dirty and/or hostile environment will require a greater frequency of all maintenance checks.

NOTE: See "Operation" section for the location of controls.

To Check Safety Valve

If the safety valve does not work properly, over pressurization may occur, causing air tank rupture or an

explosion.

1.Before starting compressor, pull the ring on the safety valve to make sure that the safety valve operates freely. If the valve is stuck or does not operate smoothly, it must be replaced with the same type of valve.

To Drain Tank

1.Set the On/Auto/Off lever to "OFF".

2.Pull the regulator knob out and turn counter clockwise to set the outlet pressure to zero.

3.Remove the air tool or accessory.

4.Pull ring on safety valve allowing air to bleed from the tank until tank pressure is approximately 20 psi. Release safety valve ring.

17- ENG

A16759

Image 17

Contents Direct Drive Oil Lube Portable Air Compressor Important Safety Instructions Safety Guidelines DefinitionsDeath or serious injury Or moderate injury Death or serious injuryLocation away from compressor Spray area. An additional length of hoseExplosion May be required To alter the factory set operating pressures Attachments & AccessoriesRepairs attempted by unqualified To human consumption Or attempt maintenance until unit hasYour specific application Result in serious burnsFire, Inhalation, Damage to Vehicle Surfaces Accessories SpecificationsGlossary Duty CycleTo Add Oil To Pump AssemblyLocation of the Air Compressor InstallationVoltage and Circuit Protection Extension CordsPressure Switch B The pressure On/Auto/Off Switch a Turn thisOperation Know Your Air Compressor Description of OperationMotor Thermal Overload Protector not shown Cooling System not shown ThisBefore Starting How to StopBefore Each Start-Up Tire sidewall for the correct tire pressureHow to Use Remote Console How to StartHow to transport unit To Check Safety Valve MaintenanceCustomer Responsibilities To Drain TankOil CheckingMotor Air Filter Inspection and ReplacementTo Replace or Clean Check Valve Service and AdjustmentsStorage Troubleshooting Pressure reading Problem Cause Correction Problem Cause Correction Limited Warranty Manual de Instrucciones Lesiones serias Definiciones DE Normas DE SeguridadLesiones serias Resultar en lesiones menores o Moderadas Cómo prevenirlo Instrucciones Importantes DE SeguridadQué puede occurrir Cómo prevenirlo Advertencia Riesgo de Explosión31- SP A16759 Advertencia Riesgo de Quemaduras Qué puede occurrir Advertencia Riesgo de Operación Lasegura Qué puede occurrir Advertencia Riesgo de Caída Qué puede occurrirCiclo DE Servicio GlosarioEspecificaciones AccesoriosAgregado de aceite a la bomba EnsambladoUbicación del compresor de aire InstalaciónEnchufe Espiga de conexión a tierraProtección del voltaje y del circuito Cables de extensión eléctricaConozca su compresor de aire OperaciónVálvula aliviadora de presión M La válvula aliviadora de Válvula de drenaje I La válvula de drenajeAntes de poner en marcha Cómo utilizar su unidadCómo detenerla Procedimiento para el asentamientoCómo poner en marcha Cómo utilizar la consola de control remotoCómo transportar la unidad Cómo verificar la válvula de seguridad MantenimientoCómo drenar el tanque Riesgo de su ruptura o explosiónCambio AceiteVerifique Ruptura del tanque de aireFiltro de Aire Inspección y reemplazo Para reemplazar o limpiar la válvula de retención Servicio Y AjustesOriginando un riesgo de ruptura de sus paredes AlmacenajeGuía DE Diagnóstico DE Problemas Se utiliza un A16759 50- SP 51- SP A16759 Responsabilidad DEL Comprador Original Usuario inicial Garantía LimitadaManuel dinstructions Consignes DE Sécurité Importantes Mesures DE Sécurité DéfinitionsOu la mort Causer des blessures mineures ou Moyennes Évité, peut causer des dommages à laAvertissement Risque dexplosion ou dincendie Prévention Conserver ces directivesRisque Prévention Avertissement Risque déclatementAvertissement Risque de choc électrique Avertissement Risque de projection dobjetsAvertissement Risque relié aux pièces mobiles Avertissement Risque par inhalationAvertissement Risque de brûlures Avertissement Risque dune utilisation dangereuse Avertissement Risque de chuteRisque Accessoires Cycle DE ServiceLexique Modèle no C3551Ajout dhuile à la pompe AssemblageCourant Emplacement du compresseur dairUtiliser UN ADAPTATEUR. Voir TerreRallonges Protection contre la surtension et protection du circuitFamiliarisez-vous avec votre compresseur dair UtilisationPompe du compresseur dair non illustrée Robinet de vidange I Le robinet deFiltre dadmission dair K Ce filtre a été conçu pour Soupape de retenue L Lorsque le compresseurAvant le démarrage Arrêt de lappareilAvant chaque mise en marche Procédures de rodageUtilisation de la console à distance Mise en marcheTransport de lappareil Vérification de la soupape de sûreté EntretienResponsabilités du consommateur Vidange du réservoirVidange HuileVérification Moteur Filtre à air Inspection et remplacementEntretien ET Réglages Remplacement ou nettoyage de la soupapeRangement Dépannage Elle doit être remplacée Le moteur ne Bruit de cliquetis 78- FR 79- FR A16759 Responsabilité DE Lacheteur Dorigine utilisateur initial Garantie Limitée