Frymaster Computer and Related Components, TB14 SERIES GAS FRYERS PARTS LIST, Part #

Page 53

9.3 Computer and Related Components

TB14 SERIES GAS FRYERS

CHAPTER 9: PARTS LIST

9.3 Computer and Related Components

1		2	3
			9
4
			10
5	6	7	8

ITEM

PART #

COMPONENT

1210-3562 Panel, Control- TB14

2106-1188 Computer, CMIII.5- TB14

3823-3806 Bezel, Computer- TB14

4806-4549 Board, Interface

*

806-7179SP

Sound Device

5807-3684 Outlet, Filter Power- 120V

6807-3577 Breaker, Circuit- 7 Amp (120V)

*807-3538 Breaker, Circuit- 5 Amp (230V)

7

807-3680

Thermostat, High-Limit- 450°F Manual Reset

*810-2046 Spring, Spacer- High-Limit Bulb

8	807-1321	Holder, Fuse- Buss Fuse
*	807-3592	Fuse, 2 Amp
9	807-0979	Transformer, 208/240V - 12V- Secondary
10	106-0986SP	Probe, Temperature

*210-1386 Clamp, Probe Bulb and High-Limit Bulb

*810-2164 Spring, Spacer- Probe Bulb

*809-0448 Clip, Tinnerman (Sensor Probe and High-Limit Probe Clamp)

*809-0360 Screw, Probe/H-Limit Bulb Clamp- #8 x 3/8 Slotted Hex Head

*Not Illustrated

9-4

Image 53

Contents TB14 Series With Built-In Filtration PARTS LIST INCLUDEDInstallation & Operation Manual 8195941REQUIREMENTS in Chapter 3 of this manual for specifics other appliance DANGER from slips or contact with the hot oil DANGERPage # TABLE OF CONTENTSTB14 Series Gas Fryers TABLE OF CONTENTS CONT TB14 SERIES GAS FRYERS CHAPTER 1 INTRODUCTION 1.3 Service Information1.1 After Purchase 1.2 Ordering Parts1.6 Service Personnel 1.5 Safety Information1.4 Computer Information cont TB14 SERIES GAS FRYERS CHAPTER 1 INTRODUCTIONTB14 SERIES GAS FRYERS CHAPTER 1 INTRODUCTION 1.6.1 Definitions cont B. Qualified Installation PersonnelC. Qualified Service Personnel TB14 SERIES GAS FRYERS CHAPTER 2 IMPORTANT INFORMATION 2.4 Pre-Installation2.1 Product Description 2.2 Principles of OperationTB14 SERIES GAS FRYERS CHAPTER 2 IMPORTANT INFORMATION 2.4 Pre-Installation contC. Installation Standards A. Do not connect this fryer to an exhaust duct 2.6 Equipment Installed at High Altitudes2.5 Air Supply and Ventilation If your equipment arrives damaged 2.7 Receiving and Unpacking Equipment3.1 Installing the Fryer TB14 SERIES GAS FRYERS CHAPTER 3 INSTALLATION3.2 Leveling the Fryer fryers equipped with legs only movement to avoid damage and possible bodily injury DANGERQuestions? Call 3.3 Installing Casters and LegsTB14 SERIES GAS FRYERS CHAPTER 3 INSTALLATION Recommended Gas Supply Line Sizes 3.4 Gas ConnectionsNATIONAL CODE REQUIREMENTS damage to the fryer’s gas piping and gas valves 3.4 Gas Connections cont½ PSI 3.45 kPa/35 mbar, a step-down regulator will be required I. Flexible Couplings, Connectors and Casters new connectionsinjury may result 3.5 Electrical Connections 4.1 Initial Start-up 4.1.1 Pilot Lighting Procedures, Standing Pilot OnlyTB14 SERIES GAS FRYERS CHAPTER 4 FRYER OPERATIONS TB14 SERIES GAS FRYERS CHAPTER 4 FRYER OPERATIONS 4.1.1 Pilot Lighting Procedures, Standing Pilot Only cont4.2 Boil-Out Procedure so will damage the heating tubes and frypot, and void the warranty 4.2 Boil-Out Procedure cont4.3 Final Preparation crack glass containerstransfer TB14 SERIES GAS FRYERS CHAPTER 5 BUILT-IN FILTRATIONTB14 SERIES GAS FRYERS CHAPTER 5 BUILT-IN FILTRATION 5.1 General5.2.1 Assembling the Filter 5.2 Filtration PreparationAssemble the filter as follows 5.2.1 Assembling the Filter cont4. Sprinkle 8 ounces of filter powder on the filter sheet. Ensure the powder covers the filter paper evenly 5.3.1 General Overview 5.2.2 Installing the Filter5.3 Daily Filtration Operation container for disposal 5.4 Operating the Filter5.3.2 Filtering Tools overflow and spillage of hot oil/shortening DANGER 5.4 Operating the Filter contabove the maximum fill line located on the container DANGER shortening will rush out creating the potential for severe burns1. Turn the fryer off. Ensure the filter pan assembly is prepared as described in Section 5.2.1- Assembling the Filter 5.4.2 Filter Operationtemperature ~350F ~177C 5-10 5.4.2 Filter Operation cont5-11 5-12 DO NOT ALLOW CRUMBS TO ACCUMULATE IN TRAY 5-136.1 Operating Fryers with Computer Magic III.5 Computers TB14 SERIES GAS FRYERS CHAPTER 6 COMPUTER OPERATIONwater. NEVER allow water to enter the Filtration System DESCRIPTIONSetup 6.1.1 Equipment Setup and Shutdown ProceduresTB14 SERIES GAS FRYERS CHAPTER 6 COMPUTER OPERATION Shutdownresults, do not cook product until the display reads 6.1.1 Equipment Setup and Shutdown Procedures contDo not cancel the melt cycle mode if using solid shortening 6.1.2 Checking Temperature 6.2 Programming the Computer Magic III.5 Computer6.2 Programming the Computer Magic III.5 Computer cont 6.2.1 Boil FeatureSEE CHAPTER 4.2 FOR ADDITIONAL BOIL-OUT PROCEDURES 6.2.1 Boil Feature cont6.2.2 Temperature Selection-Fahrenheit to Celsius 6.2.3 Constant Oil Temperature Display Modetime the cleaner remains on the food-contact surfaces TB14 SERIES GAS FRYERS CHAPTER 7 PREVENTATIVE MAINTENANCE7.1 General 7.2 DailyBuilt-in Filtration TB14 SERIES GAS FRYERS CHAPTER 7 PREVENTATIVE MAINTENANCE7.4 Periodic/Annual 7.5 Stainless Steel Care 7.4 Periodic/Annual contBuilt-in Filtration cont burnstests are required. Use extreme care when performing such tests TB14 SERIES GAS FRYERS CHAPTER 8 TROUBLESHOOTINGDisconnect all power cords before servicing authorized service agent only8.3 Main Burner Malfunctions TB14 SERIES GAS FRYERS CHAPTER 8 TROUBLESHOOTING8.2 Pilot Burner Malfunction cont 8.3 Main Burner Malfunctions cont Diagrams Wiring8.4.1 TB14 SeriesTerminal #2 - Medium 8.4.2 TB14 Series Interface Board Enlarged ViewDual Operation Only 9.1 Accessories TB14 SERIES GAS FRYERS CHAPTER 9 PARTS LISTPART # COMPONENT9.2 Cabinetry and Related Components TB14 SERIES GAS FRYERS CHAPTER 9 PARTS LIST1 823-3248 Support, Leg- Without Optional SUFF Filter Only 9.2 Cabinetry and Related Components cont9.3 Computer and Related Components To Filter 9.4 Filter Module ComponentsTo Frypot 9.4 Filter Module Components cont 9.5 Filter Pan Components 9.6 Frypot, Burners and Related Components 9.6 Frypot, Burners and Related Components cont 9.7 Oil Return Components Shipping Address 8700 Line Avenue, Shreveport, Louisiana SERVICE HOTLINEFAX Parts 1-318-219-7140 FAX Tech Support Price $10.00