Southbend HDG-72-RE, HDG-60-M, HDG-36-RE, G-72-M, HDG-48-M, HDG-36-M, HDG-24-M, HDG-48-RE Installation

Page 11

HEAVY DUTY COUNTERLINE

INSTALLATION

Step 2b: Installation Directly on a Non-Combustible Countertop Surface

The appliance may be installed directly onto a flat NON-COMBUSTIBLE surface, as follows:

1.Place the appliance in the position that it will be used. Lift the appliance only from the ends, never from the middle!

2.Connect the gas supply (see Step 4 on page 18), then return to this procedure.

3.Check that the appliance is in the position you want it to be in.

4.Seal the appliance to the countertop using G.E. or Dow Corning RTV, or the equivalent (as shown in Figure 6 below). Consult local codes for exact requirements. A small bead of RTV around all four bottom edges should be adequate. Open the front door to seal along the front edge of the frame.

5.Go on to Step 5 on page 19.

Figure 6

INSTALLATION

OWNER’S MANUAL 1182845 REV 8

PAGE 11

Image 11

Contents Heavy Duty Counterline Safety Precautions Table of Contents GAS Supply SpecificationsVentilation ClearancesModel Width Number and Size of Burners Total BTU Dimensions of Griddle ModelsConstruction of Griddle Models Dimensions of Charbroiler ModelsConstruction of Open TOP Models Dimensions of Open TOP ModelsConstruction of Charbroiler Models Attach Countertop Legs, Mount on Counter, or Mount on Stand InstallationUnpack Installation on Countertop Legs Installation Installation on Insulated Base Installation on Floor Stand 24, 36, and 48 Models Owner ’S Manual 1182845 REV Installation on Floor Stand 60 and 72 Models Installation Attach Restraint for Appliances Mounted on Casters Connect Gas Supply Check Pilot and Burner Operation Final Positioning, Clearance Check, and Ventilation CheckFinal Installation Steps for Lava-Rock Charbroilers Final Installation Steps for Griddle ModelsLighting After GAS has Been Shut OFF OperationOperation of Thermostatic Griddle Models Operation of Manual Griddle Models Operation of Charbroiler Models Operation of OPEN-TOP Burner Models Daily CleaningOwner ’S Manual 1182845 REV Adjustment of Manifold GAS Pressure AdjustmentsAdjustment of Pilot Flame Charbroiler and OPEN-TOP Models Adjustment of Pilot Flame Griddle ModelsConversion from ONE Type of GAS to Another Adjustment of Burner FlameAdjustment of Griddle Thermostats Problem Look for TroubleshootingParts Index of Parts DiagramsGriddle Chassis Parts See parts list on previous page. Model HDG-24 is shown Thermostatic Griddle Gas System Parts Parts Manual Griddle Gas System Parts See parts list on previous page. Model HDG-36-M is shown Charbroiler Parts Parts Open Top Parts Parts Floor Stand Parts for 24, 36, and 48 Width Units See parts list on previous page. Model HDG-36 is shown Floor Stand Parts for 60 Width Units 1312 Countertop Legs and Insulated-Base Parts Heavy Duty Counterline Heavy Duty Counterline Heavy Duty Counterline Heavy Duty Counterline