Bosch Power Tools 4100DG manual Recommended Accessories, Lubrication, Cat. No

Make sure the teeth of the ANTIKICKBACK pawls are always sharp. To sharpen:

1.Remove blade guard.

2.Rotate pawl toward rear of spreader so that teeth are above top of spreader.

3.Hold spreader with pawl over corner of workbench (Fig. 68).

4.Using a small round file (Smooth Cut) sharpen the teeth.

All repairs, electrical or mechanical, should be ! WARNING attempted only by trained repairmen. Contact the nearest Factory Service Center or Authorized Service Station or other competent repair service. Use only identical replacement

parts, any other may create a hazard.

Lubrication

The gear case has been completely lubricated at the factory. However, after six months to one year, depending upon use, it’s wise to return your tool to the nearest Service Center for the following:

•Brushes replaced.

•Parts cleaned and inspected.

•Relubricated with fresh lubricant.

•Electrical system tested.

•All repairs.

The following parts should be oiled occasionally with SAE No. 20 or No. 30 oil, or WD 40 (Fig. 69).

1.Elevation, support rods, and gears.

2.Sliding rails and supports.

3.Table locking cams (Front & Rear).

FIG. 68

FIG. 69

21

Recommended Accessories

Item Cat. No.

Rear Outfeed Support . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . TS1002 Left Side Outfeed Support . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . TS1003 Dust bag . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . TS1004 Zero Clearance Insert . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . TS1005 Dado Insert Set . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . TS1007 Molding Insert . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . TS1009 Pusher Guide System . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . TS1010 Blade Tote. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . TS1011 Gravity-Rise Wheeled Table Saw Stand . . . . . . . . . . . . . . . . . . TS2000

!	WARNING	Use only recommended accessories. Follow
		instructions that accompany accessories. Use of

improper accessories may cause hazards.

80.