Briggs & Stratton 074002 Table of Contents, Equipment Description, Safety Rules

DESCRIPTION / SAFETY RULES

SAVE THESE INSTRUCTIONS

TABLE OF CONTENTS

Safety Rules . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-5

Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-7

Features and Controls . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8

Operation. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9-12

Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13

Maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14-20

Storage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20-21

Troubleshooting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22-23

Glossary. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24

Emission Information. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25

Emission Control Warranty . . . . . . . . . . . . . . . . . . . . . . . . . 26

Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27

Français. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28-53

Espanõl . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 54-80

EQUIPMENT DESCRIPTION

This manual contains operation and maintenance information for a single stage air compressor that produces 11.0 CFM at 40 PSI (2.8 bars) and 9.0 CFM at 90 PSI (6.2 bars) using a

6.5HP internal combustion engine.This high quality system features a belt-drive oil lubricated pump with cast iron sleeve, easy start valve, and two air outlets.

Every effort has been made to ensure that information in this manual is accurate and current. However, we reserve the right to change, alter or otherwise improve the product and this document at any time without prior notice.

The Emissions Control System for this air compressor is warranted for standards set by the Environmental Protection Agency and the California Air Resources Board.

Statement of Use

This air compressor has been manufactured to provide an adequate volume of compressed air for operating a variety of light-duty air tools (hand grinders, nailers, ratchets, or staplers), spraying equipment, and inflators requiring less than

9.0CFM air flow for operation. Operate this compressor ONLY in an ambient temperature range from 32° to 95°F (0° to + 35°C). Operate this compressor ONLY on a level surface to avoid lubrication problems.This compressor is designed for a maximum of 70% duty per hour at full load.

This air compressor is not intended for use in mobile equipment or marine applications.

SAFETY RULES

This is the safety alert symbol. It is used to alert you to potential personal injury hazards. Obey all safety messages that follow this symbol to avoid possible injury or death.

The safety alert symbol () is used with a signal word (DANGER, CAUTION,WARNING), a pictorial and/or a safety message to alert you to hazards. DANGER indicates a hazard which, if not avoided, will result in death or serious injury.WARNING indicates a hazard which, if not avoided, could result in death or serious injury. CAUTION indicates a hazard which, if not avoided, might result in minor or moderate injury. CAUTION, when not used with the safety alert symbol (), indicates a situation that could result in equipment damage. Follow safety messages to avoid or reduce the risk of injury or death.

Copyright © 2006 Briggs & Stratton Power Products Group, LLC. All rights reserved. No part of this material may be reproduced or transmitted in any form by any means without the express written permission of Briggs & Stratton Power Products Group, LLC.

WARNING

The engine exhaust from this product contains chemicals known to the state of California to cause cancer, birth defects, or other reproductive harm.

•Operate air compressor ONLY outdoors.

•Keep exhaust gas from entering a confined area through windows, doors, ventilation intakes or other openings.

•DO NOT operate air compressor inside any building, confined area or enclosure, such as basements, garages or a similar location, even if doors or windows are open.

2