Cornelius Cold Beverage Dispenser manual Dispenser Troubleshooting, Probable Cause, Remedy

IntelliCarb Training Manual

DISPENSER TROUBLESHOOTING

Should your unit fail to operate properly, check that there is power to the unit and that the hopper contains ice. If the unit does not dispense, check the following chart under the appropriate symptoms to aid in locating the defect.

Trouble

BLOWN FUSE OR CIRCUIT BREAKER.

GATE DOES NOT OPEN. AGITATOR DOES NOT TURN.

GATE DOES NOT OPEN OR IS SLUGGISH. AGITATOR TURNS.

ICE DISPENSES CONTINU- OUSLY.

SLUSHY ICE. WATER IN HOPPER.

BEVERAGES DO NOT DIS- PENSE

BEVERAGES TOO SWEET

Probable Cause

A. Short circuit in wiring

B. Inoperable gate solenoid.

C. Inoperable agitator motor. A. No power.

B. Bent depressor plate (does not actuate switch).

C. Inoperable dispensing switch. A. Inoperable gate solenoid.

B. Excessive pressure against gate slide.

C. Inoperable rectifier.

A. Stuck or bent depressor plate (does not release switch).

B. Inoperable dispensing switch.

C. Improper switch installation.

A. Blocked drain.

B. Unit not sitting level.

C. Poor ice quality due to water qual- ity or icemaker problems.

D. Improper use of flaked ice. A. No 24 volts power to faucets.

B. No CO 2 pressure.

A. Carbonator not operating.

Remedy

A. Repair wiring.

B. Replace gate solenoid.

C. Replace agitator motor.

A. Restore power.

B. Replace depressor plate.

C. Replace dispensing switch. A. Replace gate solenoid.

B. Adjust gate slide.

C. Replace rectifier.

A. Replace depressor plate.

B. Replace dispensing switch.

C. Make sure switch is installed properly.

A. Unplug drain.

B. Level the unit.

C. Correct water quality or repair ice- maker.

D. Call Service Person.

A. Restore 24 volt power to faucets.

B. Restore CO 2 pressure.

A. Repair carbonator.

Publication Number: TP01071 - 38 - © 2004, IMI Cornelius Inc.