Honda Power Equipment BF2D - page 79

77

To Qualify for This Warranty:

What AmericanHonda Will Repair or Replace Under

Warranty:

Accessories and Replacement Parts

TECHNICAL AND CONSUMER INFORMATION

The accessories or replacement parts must be

purchasedf rom American Honda or a dealer,

distributor,or distributor’s dealer authorized by

AmericanHonda to sell those products in the United

States,Puerto Rico, and the U.S. Virgin Islands. Parts

and Accessories must be purchased for installation on

originalHonda equipment or engines to be eligible for

warranty coverage. Installing parts and accessories on

non-Honda productsor engines voids this warranty.

You must be thef irst retailpurchaser. This warranty is

not transferable to subsequentowners.

American Honda will repair or replace, at its option, any

marine product accessories or replacement parts that are

proven tobe def ectivein material or workmanship under

normal use during the applicable warranty time period.

Anything replaced under warranty becomes the property

of American Honda Motor Company, Inc. Allp arts

replaced under warranty will be considered aspart of the

originalproduct and any warranty on those parts will

expirecoincidentally with the original product warranty.

Accessories and replacement parts, installed by a dealer

who is authorizedby American Honda to sell them, will

be repaired or replaced under warranty withoutcharge f or

parts or labor. If installed by anyone else, accessories and

replacement parts will be repaired or replaced under

warrantywithout charge f or parts,but any labor charges

will be the responsibility of the purchaser.

1.

2.

This warranty is limited to HondaMarine parts, accessories and apparel when distributed by American Honda Motor Co.,

Inc.,1919 TorranceBlvd., Torrance, California 90501-2746.

ProductsCovered by Warranty:

12months 3months 3 months

Non Commercial Commercial/Rental Local/State/Federal

Government

Lengthof Warranty:(f rom date of original retail purchase)

6months 3 months 3 months

24months24months24months

Accessoriesother than noted below

Emissionrelated accessories:

Portablefuel tanks, f uel line assemblies, and

water/fuel separators

ReplacementParts

11/03/03 17:19:41 31ZW6620_078

Contents

Main Page INTRODUCTION 2 A FEW WORDS ABOUT SAFETY INTRODUCTION CONTENTS Page CONTENTS 6 Operator Responsibility IMPORTANT SAFETY INFORMATION OUTBOARD MOTOR SAFETY 7 Carbon Monoxide HazardRefuel With Care Page Page OUTBOARD MOTOR SAFETY 11 CONTROL AND FEATURE IDENTIFICATION CODES CONTROLS AND FEATURES 12 COMPONENT AND CONTROL LOCATIONS 13 Choke Knob CONTROLS Emergency Stop Switch Clip and Emergency Stop Switch 14 Throttle Grip (SH, SCH and LCH types) (SH, SCH and LCH types)(S, L types) 15 Starter GripFuel Valve Lever Engine Cover Retaining Strap 16 Tilt LeverTransom Angle Adjusting Bolt 17 Steering Friction Bolt Fuel Filler Cap Vent KnobClamp Screws Page 19 INSTALLATION POSITION POWER REQUIREMENTS INSTALLATION 20 ATTACHMENT INSTALLATION 22 ARE YOU READY TO GET UNDERWAY? Safety Knowledge IS YOUR OUTBOARD MOTOR READY TO GO? BEFORE OPERATION 23 Safety InspectionMaintenance Inspection BEFORE OPERATION 24 SAFE OPERATING PRECAUTIONS BREAK-IN PROCEDURE TRANSOM ANGLE ADJUSTMENT OPERATION 25 STARTING THE ENGINE INFREQUENT OR OCCASIONAL USE Page Page 28 EMERGENCY STARTING Page 30 Normal Engine Stopping STOPPING THE ENGINE Emergency Engine Stopping Page 32 THROTTLE OPERATION 33 REVERSING THE OUTBOARD MOTOR 34 STEERING 35 Transom Angle CRUISING Engine Speed 36 MOORING, BEACHING, LAUNCHING Page 38 THE IMPORTANCE OF MAINTENANCE SERVICING YOUR OUTBOARD MOTOR 39 MAINTENANCE SAFETY Safety Precautions 40 TOOL KIT AND EMERGENCY STARTER ROPE 41 MAINTENANCE SCHEDULE DistributorsLimited W arranty (1) (2) (3) Forprof essionalcommercial use, log hours of operation to determine proper maintenance intervals. Lubricatemore frequently when used in salt water.(1) (2) (3) 43 Engine Oil Level Check Engine Oil Change ENGINE COVER REMOVAL AND INSTALLATION 44 Engine Oil Recommendations 45 Gear Case Oil Change 46 Lubrication Points 47 Spark Plug Service Page 49 REFUELING 50 FUEL RECOMMENDATIONS 51 Recoil Starter Rope Inspection Anode Replacement 52 Propeller Replacement Removal Installation 53 STORAGE PREPARATION Fuel STORAGE 54 Adding a Fuel Stabilizer Draining the Fuel Tank and Carburetor 55 Engine Oil STORAGE PRECAUTIONS 56 REMOVAL FROM STORAGE 57 WITH OUTBOARD MOTOR INSTALLED ON BOAT WITH OUTBOARD MOTOR REMOVED FROM BOAT TRANSPORTING TAKING CARE OF UNEXPECTED PROBLEMS Page Page Page 62 SUBMERGED OUTBOARD MOTOR Page 64 TECHNICAL INFORMATION Serial Number Locations TECHNICAL AND CONSUMER INFORMATION 65 Carburetor Modification for High Altitude Operation 66 Emission Control System Information Source of Emissions Tampering and AlteringThe U.S. and Califor nia Clean Air Acts 67 Maintenance Replacement PartsProblems That May Af f ect Emissions Page Page 70 Specifications Tuneup 71 CONSUMER INFORMATION Honda Publications Parts Catalog Customer Service Information Accessory Catalog 72 WarrantyCoverage 73 Warranty Service 74 United states, Puerto Rico and Virgin Islands Warranty Statements Distributors Limited Warranty Page Page Page Page 79 Emission Control SystemWarranty Page Page EMISSION CONTROL SYSTEM WARRANTY PARTS: 83 Canada WARRANTY PERIOD RETAILED ON OR AFTER APRIL 1, 2005: THIS WARRANTY COVERS Distributors Warranty 84 THIS WARRANTY DOES NOT COVER THE OWNERS OBLIGATION TO OBTAIN WARRANTY SERVICE 85 REPLACEMENT PARTS AND ACCESSORY WARRANTY ENTIRE WRITTEN WARRANTY DISCLAIMER NOTICE TO CONSUMER INDEX Page INDEX