Manuals / Quadra-Fire / Household Appliance / Stove

Quadra-Fire MTVERNINSAE-CWL, MTVERNINSAE-CSB, MTVERNINSAE-PMH Mt. Vernon Pellet Insert AE

Models: MTVERNINSAE-CWL MTVERNINSAE-PMH MTVERNINSAE-MBK MTVERNINSAE-CSB

1 56

Download 56 pages 40.26 Kb

Page 55

R

Mt. Vernon Pellet Insert (AE)

November 22, 2011

7036-135G

Page 55

Image 55

Quadra-Fire MTVERNINSAE-CWL, MTVERNINSAE-CSB, MTVERNINSAE-PMH, MTVERNINSAE-MBK owner manual Mt. Vernon Pellet Insert AE

Contents

Hot glass will cause burns Installation and Operation Label Location On Beaded Chain on e behind Right Side Panel Mt. Vernon Pellet Insert AE Table of Contents Glass Speciﬁ cations Listing and Code ApprovalsAppliance Certiﬁ cation Mobile Home Approved Floor Support Design, Installation & Location ConsiderationsGetting Started Appliance Location Thermostat Wall Control Location Tools And Supplies NeededInspect Appliance and Components Pre-Use Check List Appliance Dimensions 3Dimensions and Clearances Built-in Unit Rear Vent with Outside Air Inch Clearance To Exposed Section And Face Trim Minimum Opening for Masonry and Zero Clearance Fireplaces Mt. Vernon Pellet Insert AE Built-In VerticalMasonry and Zero Clearance Fireplaces Floor Protection Starter hole Mark area of floor to cut Altering the Factory-Built Fireplace Mt. Vernon Pellet Insert AE Prefabricated Metal Chimney Termination must exhaust above air inlet elevation 4Vent InformationVenting Termination Minimum Requirements Do not Terminate Vent Outside Air Negative Pressure, Shut-Down and Electrical Power FailureOptional Battery Back-Up Mt. Vernon Pellet Insert AE Avoiding Smoke and Odors Mt. Vernon Pellet Insert AE Negative Pressure Draft Equivalent Feet of Pipe Mt. Vernon Pellet Insert AE Chimney and Exhaust ConnectionExample of 3 Elbow-Rear Vent Termination Calculation Altitude in Thousands of Feet Mt. Vernon Pellet Insert AE Pipe Selection Chart Full Reline With Outside Air Horizontal 5Venting Systems 305mm min. above 305mm min. below 6Mobile Home Never Install in a Sleeping Room Leveling System 7Appliance Set-UpOutside Air Kit Instructions Removal of Cast Sides Mt. Vernon Pellet Insert AE Hearth Support Surround & Trim Set, Basic Mt. Vernon Pellet Insert AE Surround and Trim Set Cast Rebox. Figures 23.1 Optional Log Set Placement InstructionsRebox. Figures 23.3 7036-135G November 22 Fuel Material and Fuel Storage Fire Safety8Operating Instructions Combustible/Non-Combustible Materials General Operating Information Thermostat Wall Control Automatic SettingThermostat Wall Control Manual Setting Auto-Clean Firepot System Starting Your First Fire Fire Characteristics and Flame Height Feed Rate AdjustmentMt. Vernon Pellet Insert AE Before Your First Fire Filling the Hopper with Fuel Clear Space Mt. Vernon Pellet Insert AE Battery Back-up System Optional Mt. Vernon Pellet Insert AE Ignition Cycles Insert Removal Auto-Clean CycleAdditional Screen Messages Mt. Vernon Pellet Insert AE Quick Start Guide Or CWall Control for Reference 74ºF Issues Solutions Frequently Asked Questions Possible Cause Corrective Action Error Message Before Servicing Your Appliance Quick Reference Maintenance ChartProper Shutdown Procedure 10Maintaining & Servicing Your Appliance Ash Removal from Firebox General Maintenance and CleaningAuto-Clean System Inspection & Cleaning Cleaning Ash Pan Example of a dirty heat exchanger Large Clinker Cleaning Heat Exchanger, Drop Tube & Exhaust Loosen all 6 nuts, but do not Remove Preparing Firebox for Non-Burn Season Cleaning the HopperCleaning the Glass Door Latch Inspection Fire and Smoke Risk Bafﬂ e Removal Convection Blower Replacement Glass Replacement Convection Blower Replacement Convection Blower Replacement Cont’d Reference Materials Thermocouple Firepot Power SupplyThermocouple on Drop Tube Vacuum Switch Overheat Sensor Snap Disc Mt. Vernon Pellet Insert AE Component Locations Feed Motor, Vacuum Switch, Exhaust Blower, Overheat Sensor Part number list on following pages Mt. Vernon Pellet Insert AE Exploded Drawings Stocked at Depot At Depot Stocked #38 Feed Assembly 38.5 38.6 38.4 38.3 38.2 38.1 #40 Auto-Clean Motor/Arm Assembly Stocked at Depot #39 Firepot Riser Assembly At Depot Stocked Fasteners SP-MTVS-GD Accessories Mt. Vernon Pellet Insert AE Mt. Vernon Pellet Insert AE Contact Information