Manuals / Quadra-Fire / Household Appliance / Stove

Quadra-Fire MTVERNINSAE-MBK, MTVERNINSAE-CSB, MTVERNINSAE-PMH Mt. Vernon Pellet Insert AE

Models: MTVERNINSAE-CWL MTVERNINSAE-PMH MTVERNINSAE-MBK MTVERNINSAE-CSB

1 56

Download 56 pages 40.26 Kb

Page 54

Mt. Vernon Pellet Insert (AE)

R

Page 54

7036-135G

November 22, 2011

Image 54

Quadra-Fire MTVERNINSAE-MBK, MTVERNINSAE-CSB, MTVERNINSAE-PMH, MTVERNINSAE-CWL owner manual Mt. Vernon Pellet Insert AE

Contents

Installation and Operation Hot glass will cause burns Mt. Vernon Pellet Insert AE Label Location On Beaded Chain on e behind Right Side Panel Table of Contents Mobile Home Approved Listing and Code ApprovalsAppliance Certiﬁ cation Glass Speciﬁ cations Appliance Location Design, Installation & Location ConsiderationsGetting Started Floor Support Pre-Use Check List Tools And Supplies NeededInspect Appliance and Components Thermostat Wall Control Location 3Dimensions and Clearances Appliance Dimensions Inch Clearance To Exposed Section And Face Trim Built-in Unit Rear Vent with Outside Air Floor Protection Mt. Vernon Pellet Insert AE Built-In VerticalMasonry and Zero Clearance Fireplaces Minimum Opening for Masonry and Zero Clearance Fireplaces Starter hole Mark area of floor to cut Mt. Vernon Pellet Insert AE Prefabricated Metal Chimney Altering the Factory-Built Fireplace Do not Terminate Vent 4Vent InformationVenting Termination Minimum Requirements Termination must exhaust above air inlet elevation Mt. Vernon Pellet Insert AE Avoiding Smoke and Odors Negative Pressure, Shut-Down and Electrical Power FailureOptional Battery Back-Up Outside Air Mt. Vernon Pellet Insert AE Negative Pressure Draft Mt. Vernon Pellet Insert AE Chimney and Exhaust Connection Equivalent Feet of PipeExample of 3 Elbow-Rear Vent Termination Calculation Mt. Vernon Pellet Insert AE Pipe Selection Chart Altitude in Thousands of Feet 5Venting Systems Full Reline With Outside Air Horizontal 305mm min. above 305mm min. below Never Install in a Sleeping Room 6Mobile Home 7Appliance Set-Up Leveling SystemOutside Air Kit Instructions Mt. Vernon Pellet Insert AE Hearth Support Removal of Cast Sides Mt. Vernon Pellet Insert AE Surround and Trim Set Cast Surround & Trim Set, Basic Optional Log Set Placement Instructions Rebox. Figures 23.1Rebox. Figures 23.3 7036-135G November 22 Combustible/Non-Combustible Materials Fire Safety8Operating Instructions Fuel Material and Fuel Storage Auto-Clean Firepot System Thermostat Wall Control Automatic SettingThermostat Wall Control Manual Setting General Operating Information Filling the Hopper with Fuel Fire Characteristics and Flame Height Feed Rate AdjustmentMt. Vernon Pellet Insert AE Before Your First Fire Starting Your First Fire Mt. Vernon Pellet Insert AE Battery Back-up System Optional Clear Space Mt. Vernon Pellet Insert AE Ignition Cycles Auto-Clean Cycle Insert RemovalAdditional Screen Messages Or C Mt. Vernon Pellet Insert AE Quick Start GuideWall Control for Reference 74ºF Frequently Asked Questions Issues Solutions Error Message Possible Cause Corrective Action 10Maintaining & Servicing Your Appliance Quick Reference Maintenance ChartProper Shutdown Procedure Before Servicing Your Appliance Cleaning Ash Pan General Maintenance and CleaningAuto-Clean System Inspection & Cleaning Ash Removal from Firebox Large Clinker Cleaning Heat Exchanger, Drop Tube & Exhaust Example of a dirty heat exchanger Loosen all 6 nuts, but do not Remove Door Latch Inspection Cleaning the HopperCleaning the Glass Preparing Firebox for Non-Burn Season Bafﬂ e Removal Fire and Smoke Risk Glass Replacement Convection Blower Replacement Convection Blower Replacement Cont’d Convection Blower Replacement Reference Materials Overheat Sensor Snap Disc Power SupplyThermocouple on Drop Tube Vacuum Switch Thermocouple Firepot Feed Motor, Vacuum Switch, Exhaust Blower, Overheat Sensor Mt. Vernon Pellet Insert AE Component Locations Mt. Vernon Pellet Insert AE Exploded Drawings Part number list on following pages Stocked at Depot Stocked At Depot #38 Feed Assembly 38.5 38.6 38.4 38.3 38.2 38.1 Stocked at Depot #39 Firepot Riser Assembly #40 Auto-Clean Motor/Arm Assembly Stocked At Depot Fasteners Accessories SP-MTVS-GD Mt. Vernon Pellet Insert AE Mt. Vernon Pellet Insert AE Contact Information