9-4-7 TAPPET ADJUSTMENT

Set the tappet at the lowest point and push down the valve. Measure the clearance between the valve and the tappet stem, using a clearance gauge inserted into the clearance (See Fig. g-4-12).

Note: When the engine is not running, the clearance between the valve and tappet stem must be in the range of 0.110.02. This holds true for both the intake valve and the exhaust valve.

e;

 

 

 

Intake

Valve ‘a

r

Exhaust Valve

e+ig+.

 

 

 

 

 

 

~<Wty!.&<~~

 

 

 

 

 

 

. i’

 

_I ’/:

p-.

 

 

 

 

\

.I

-Lq

 

 

 

 

 

 

 

 

 

 

 

 

7;:

;:,z<-

1

 

 

 

 

<y,-

;,:

:/ :m

Valve

Spring

 

 

 

 

 

 

 

 

‘2 <

j

’ ij>m,Y,,

 

 

 

 

--A’

A./,,-,

_”

 

 

 

 

 

C-J.

.- Ii-\ J

i,L

 

 

 

c

 

 

 

 

 

 

 

 

 

 

 

 

 

 

Clearance

Gauge

 

 

 

 

Fig. 9-4-12

 

 

Fig. 94

13

 

Note: If the clearance is smaller than the specified one, grind down slightly the valve stem tip with a grinder and measure the clearance again.

If the clearance is larger than the specified allowance, replace the valve with a new one and adjust the clearance using some compound etc.

Note: Install the valve spring retainers after completing adjustment of the tappet clearance. Then recheck the clearance.

*Installment of spring retainers

Place the retainer, using a special tool, over the valve stem with the retainer’s notch facing towards the front.

Front

9-4-8 BREATHER PLATE AND TAPPET COVER

Note: Pay attention to installing procedure of the gaskets and position of the breather valve, which should be located in the intake valve side.

9-4-9 CYLINDER HEAD

Before installing the cylinder head, be sure to remove any carbon deposits from the combustion chamber, and scrape off any dust in the section between the cooling fans.

Also check the level of the cylinder head.

Note: Replace the cylinder head gasket with a new one.

Note: Torque for the cylinder head: 190 % 230 kg-cm

-54-

Page 58
Image 58
Subaru Robin Power Products R1200 service manual Tappet Adjustment, Breather Plate and Tappet Cover Cylinder Head