Briggs & Stratton 01938-0 & 01815-0 manual Before Initial START-UP, Engine Oil, Battery Connection

Page 12

Briggs & Stratton Power Products Home Generator

Operator’s Manual

BEFORE INITIAL START-UP

Engine Oil

This engine is shipped from the factory filled with the recommended oil. Before starting the engine, check oil level and ensure that engine is serviced as described in the engine operator’s manual.

CAUTION

Any attempt to crank or start the engine before it has been properly serviced with the recommended oil will result in equipment failure.

•Refer to engine manual for oil fill information.

•Damage to equipment resulting from failure to follow this instruction will void warranty.

Oil Considerations

Your Home Standby Generator is equipped with an engine that has been pre-run at the factory and does not require the traditional “break-in” procedure.

The system is filled with synthetic oil (API SJ/CF 5W-30W). This allows for system operation in the widest range of temperature and climate conditions.

NOTE: The use of synthetic oil DOES NOT alter the required oil change intervals described in the engine operator’s manual.

Battery Connection

The Home Standby Generator is supplied with a 12 Volt DC 33 Amp-Hour, valve regulated battery. It is a sealed, lead-acid rechargeable battery. It is installed in the unit and the battery cables are connected at the factory.The generator’s 15 Amp fuse has been removed to prevent the unit from starting during shipping.

CAUTION

Installing the 15A fuse could cause the engine to start.

•DO NOT install the 15 Amp fuse until all plumbing and wiring has been completed and inspected.

NOTE: With the battery installed, all wiring to transfer switch and Home Standby Generator completed, utility power supplied to the Automatic Transfer Switch, and the unit in AUTO mode, the battery receives a trickle charge while the engine is not running.The trickle charger cannot be used to recharge a battery that is completely discharged.

Gaseous Fuel System

•Ensure that all fuel connections are tight, secure and without leaks.

•Ensure that all shutoff valves are OPEN and that adequate pressure is available (see installation manual).

WARNING

Propane and Natural Gas is extremely flammable and explosive.

Fire or explosion can cause severe burns or death.

•DO NOT operate engine if smell of fuel is present or other explosive conditions exist.

•If you smell ‘raw’ gaseous fuel (natural or LP) near the unit, immediately turn off the gas supply to the Home Standby Generator.

•Contact your gas utility or the system installer for assistance in determining the source of the smell.

12

Page 11 Page 13
Image 12
Page 11 Page 13
Contents 10kW / 12kW Rated Table of Contents Important Safety Rules Hazard Symbols and MeaningsDo not dispose of battery in a fire Operate generator only outdoorsAmp fuse Before working on the equipment Installation Assistance IntroductionOwner Orientation For the Home OwnerFuel Factors Generator LocationHome Standby Generator Location Essential Circuits Device Running WattsShipment Contents UnpackingDelivery Inspection Know Your Home Standby Generator Control Panel seeFuel Inlet DataSwitch Know Your System Control Panel15 Amp Access Doors To Remove an Access DoorTo Install an Access Door BatteryBattery Connection Before Initial START-UPEngine Oil Gaseous Fuel SystemSetting Exercise Timer To perform the Set Exercise procedureAutomatic Operation Servicing the SystemFault Detection System Oil Temperature High Operator’s Manual Low Voltage GeneratorEngine Fail To Start Low FrequencyGenerator Maintenance To Clean the GeneratorWhen Calling the Factory StorageTroubleshooting Problem Cause CorrectionOperator’s Manual Consumer Use Years Years or YearTabla DE Contenido Manual del OperarioInstrucciones Importantes DE Seguridad PeligroAdvertencia Símbolos de Peligro y SignificadosPrecaución Los generadores producen un voltaje muy poderosoConserve Estas Instrucciones IntroducciónOrientación Para EL Propietario Asistencia para la instalaciónFactores Relacionados con el Combustible Ubicación del Generador de ReservaUbicación del Generador Distancias Desde el GeneradorCircuitos Fundamentales Pautas Generales para la Ubicación del GeneradorDispositivo Vatiaje de Desempaque Inspección al Momento de la EntregaContenido de la Caja Selección de los Circuitos FundamentalesConozca SU Generador Doméstico DE Reserva Conozca EL Panel DE Control DEL Sistema LED de Diagnóstico InterruptorPuertas de Acceso Para Retirar una Puerta de AccesoPara Instalar una Puerta de Acceso Tornillo de Bloqueo deAntes DEL Arranque Inicial Conexión de la BateríaAceite de Motor Sistema de Combustible GaseosoConfiguración del Temporizador de Práctica Operación AutomáticaVerificación de la Operación Automática Paro del SistemaMantenimiento Baja Tensión El Motor no ArrancaBaja Frecuencia Sobrevelocidad del MotorMantenimiento DEL Generador AlmacenamientoCambio del Aceite del Motor Para Limpiar el GeneradorReparacion DE Averias Notas Garantía Limitada Table DES Matières Manuel dUtilisationSymboles de Danger et Moyens Directives DE Sécurité ImportantesAvertissement NE touchez PAS les fils dénudés ou les boîtiers Aide à lInstallation Conservez CES InstructionsIntroduction Conseils AU PropriétaireEmplacement du Génératrice d’état d’Attente Emplacement de la GénératriceFacteurs Relatifs au Combustible Dégagement Autour de la GénératriceDirectives Générales Concernant lEmplacement Circuits EssentielsAppareil Watts Déballage Vérification de la LivraisonContenu de la Boîte Sélection des Circuits EssentielsFAMILIARISEZ-VOUS Avec Votre Groupe Électrogène BatterieFiltre à air La position normale de fonctionnement est la position Pour Installer une Porte dAccès Portes dAccèsPour Enlever une Porte dAccès Avant LE Démarrage Initial Huile à MoteurBranchement de la Batterie Système de Combustible GazeuxFonctionnement Automatique Arrêt du SystèmeVérification du Fonctionnement Automatique Réglage de la Minuterie du Cycle dExerciceEntretien Basse Tension Le Moteur Ne Démarre Pas Emballement du MoteurSecondes, fait une pause de 15 secondes, se lance durant Basse FréquenceEntretien DU Générateur RemisageVidange de lHuile Moteur Pour Nettoyer le GénérateurDépannage Remarques Remarques Garantie Limitée
Top Page Image Contents