Whirlpool MFW 9600S Removing the Console and the Touchpad / LED Assembly, To remove the console

Page 37

REMOVING THE CONSOLE AND THE TOUCHPAD / LED ASSEMBLY

Electrical Shock Hazard

Disconnect power before servicing.

Replace all parts and panels before operating.

Failure to do so can result in death or electrical shock.

1.Unplug washer or disconnect power.

2.Turn off the water supply to the washer.

3.Remove the three T-20 hex-head torx screws from the top cover of the washer.

4.Pull back on the cover and release the tabs in the console from the slots in the cover, then lift the cover off the unit.

Console

Tabs

Top Cover Screws

5.To remove the console:

a)Lift the locking tab and disconnect the ribbon cable connector from the cen- tral control unit.

b)Remove the ribbon cable from the five clips.

Touchpad/LED

Ribbon Cable

5 Clips

Connector @ DS3

c)Pull the detergent dispenser drawer out as far as it will go, then press down on the release tab, and remove the drawer from the unit.

Release Tab

Detergent

Dispenser

Drawer

4-2

Image 37

Contents Epic Goals and Objectives ForwardTable of Contents Wiring Diagram General Safety FirstModel Number Model & Serial Number DesignationsSerial Number Model & Serial Number Label Tech Sheet Locations Specifications Maytag Corporation Major Appliance Warranty Page 79372 12345665417289192438675445627 932726757947867 75445627834473$4487968258928 #678#87968258928Electrician+ 2273 1233456768479346724$%&%*$% ,&## 2$&+1234546#2&%2$!#2 &-.0$$+&. /+2+$ &+&+$&#0 787 3887878 #$%2&&8$87Theory of Operation AIR Vent System Pressure Switch Central Control Unit CCU TOUCHPAD/LED AssemblyMotor Control Unit MCU Drive MotorECO Valve Pump MotorSuspension System Door LOCK/SWITCH Assembly Heating Element Temperature SensorInterlock Switches 72717 9717719978234567896358769795947 42OFF567897977979992869795947679476 34628697959476794712345678938294587 Modifier6.7667656778667675694878594587 345647 123455367892234563789682 7397826739868934345#5&6 $747Sturdy colorfast fabrics 123456712345678935 88#$ 888897779 897789777 77 7#83783 Ordisconnect83783power### 35263 123456376468with liquid detergent64326%9894 %241234567 35 37 5 67 9728879 8312345674674Component Locations Component AccessTo remove the console Removing the Console and the Touchpad / LED AssemblyTo remove the touchpad / LED assem- bly Door Lock/Switch Assembly Bellows Retaining Wire To remove the front panel and bellows To remove the door lock/switch as- semblyOn the next Remove the end of the dispenser tube from the bellows Removing the Flowmeter To remove the detergent dispenser motor Removing the Detergent Dispenser Motor & AssemblyTo remove the detergent dispenser as- sembly Removing the Inlet Valves Removing the Central Control Unit Removing the Interference Filter Removing the Pressure Switch Removing the Motor Controller Wire Standoff To remove the temperature sensor Removing the Temperature Sensor Heating ElementTo remove the heating element Removing the Drain Pump Assembly Removing the Airtrap Removing AN Interlock Switch Rotate Switch Up Switch Holder Locking Tabs Removing the Drive Motor Pivot Stud Removing the TUB and Basket Assembly Align Tabs With Slots Support Weight While Removing Front Slot Front Holes Rear Half Of Tub Basket Front Half Of Tub Reassembly Notes Page Water Level Setting Test Points Component TestingDetergent Dispenser Motor & SwitchTo test the door lock main switches To test the door switchTo test the door lock/unlock solenoids Interference Filter Drain Pump MotorTemperature Results Interlock Switch Diagnostic Guide DiagnosticsElectrostatic Discharge ESD Sensitive Electronics Display Explanation and Recommended Procedure FAILURE/ERROR Display CodesLong Drain Motor Control Unit Error Dispenser Circuit Error CCU / Touchpad / LED Assembly Error Sud Starting the Test Mode Diagnostic TestTest Program Control Motor Continuity Test Water Temperature SensorManually Unlocking Door Lock System To remove Central Control Unit CCU To remove the touchpad/LED assemblyTo reassemble CCU To remove Motor Control Unit MCUProblem Troubleshooting ChartDrum will Incorrect Page Wiring Diagram Page United States Product Specifications Warranty Information Sources