Slant/Fin installation instructions Jaguar J-390 Direct VENT, Sidewall Venting, Thick Wall

Page 12

12	Jaguar Model J-390

JAGUAR J-390 - DIRECT VENT, SIDEWALL VENTING

All joints must be liquid and pressure tight. Use 4” dia. PVC/CPVC schedule 40 pipe or U/L listed single wall 4" dia.

AL29-4C S.S.*. venting materials (See page 7).

3" - 14" THICK WALL

4" DIA PVC/CPVC PIPE FOR AIR INTAKE	SLANT/FIN VENT/AIR INTAKE
90°ELBOW	TERMINATION KIT PART # 83 0802 000
90°ELBOW
4" DIA PVC/CPVC FLUE PIPE

AIR INTAKE LOUVERS

4" DIA PVC/CPVC COUPLING WITH SCREEN

SNOW LINE ** (SEE DEFINITION)

OUTSIDE WALL

Figure 10. Direct vent, sidewall venting illustration; utilizing PVC/CPVC pipe for venting

3" - 14" THICK WALL

4" DIA PVC/CPVC PIPE FOR AIR INTAKE 90°ELBOW

4" DIA STAINLESS STEEL PIPE FOR VENT

ADAPTOR

SLANT/FIN VENT/AIR INTAKE TERMINATION KIT PART # 83 0802 000

TOGETHER WITH SPECIAL KIT FOR STAINLESS STEEL VENT PIPE

AIR INTAKE LOUVERS

4" DIA STRIGHT SCREENED VENT TERMINATION

SNOW LINE ** (SEE DEFINITION)

OUTSIDE WALL

Figure 11. Direct vent, sidewall venting illustration; utilizing stainless steel vent materials for venting.

**Definition of Snow Line: Knowledge of local conditions will reveal the maximum height that repeated snowfalls accumulate to. The height should be used as the SNOW LINE.

* AL 29-4C IS A REGISTERED TRADEMARK OF ALLEGHENY LUDLUM CORP.

Image 12

Contents Installation and Operating Instructions Ratings and Dimensions Jaguar J-390 BoilerLocation and Identification of Parts Location and identification of partsSafety Boiler LocationBoiler Foundation Minimum Clearances from Combustible ConstructionsNON-DIRECT Vent Installation Direct Vent InstallationContamination Prevention Products to AvoidFlue GAS Venting Requirements Vent and AIR Intake MaterialsPVC/CPVC Pipe General Assembly Method Vent and AIR Intake RestrictionsVenting Installation Sidewall Venting NON-DIRECT VentVent Termination Location and Clearances NON-DIRECT Vent Vertical VentingJaguar J-390 NON-DIRECT VENT, Sidewall Venting 10 MAXJaguar J-390 NON-DIRECT VENT, Venting Through a Roof FT. MINFT. MIN Jaguar J-390 Direct VENT, Sidewall Venting Thick WallDIA PVC/CPVC Pipe for Vent Combustion Screw Jaguar Model J-390 Direct Vent Venting and AIR Intake Through a Roof FT. MINVenting and AIR Intake System Regular Inspection Condensate Removal SystemCommonwealth of Massachusetts Special Requirement GAS PipingElectrical Wiring Space Heating ThermostatsDomestic HOT Water Tank Thermostat Outdoor AIR Sensor101112 Boiler Control 120V 3 4 5 6 7 3 4 5 6 7 Thermostat Water Piping Water Outlet Piping Jaguar Tank PipingFeet w.c Zoning with circulators Zoning with zone valves Piping a heating-cooling system to the boiler and a chiller View and Changing Temperatures Viewing and changing system settingOperating Instructions Filling and Venting Water Systems Before Firing BOILER, make these checksJaguar Boiler Display Board Boiler Operation StatusViewing and Changing Temperatures If outdoor sensor is usedBoiler model selection, value is 5 for model J-390 Water Safety Information III. Initial StartInstructions To Turn OFF GAS to ApplianceJaguar Model J-390 Sequence of Operation Gas valve adjustment IV. Check Combustion and Fuel Input RateSafety Check Control Safety Shutdown testVI. Diagnostic Error Codes Check for gas leaks19, 42 Going to the sensor, or replace the sensor. If no sen Care and Maintenance General MaintenanceIII. Cleaning If Replacement Parts are NeededGeneral Troubleshooting Guide for Service Personnel Jaguar Model J-390 SLANT/FIN CORPORATION, Greenvale, N.Y Phone 516