Slant/Fin J-390 installation instructions Zoning with circulators

Page 27

Jaguar Model J-390					27
FROM REST					TO REST
OF SYSTEM					OF SYSTEM
		ADDITIONAL
		ZONES
	ISOLATION		FLOW CHECK	ZONE	ISOLATION
	VALVE		VALVE	CIRCULATOR	VALVE
		SPACE HEAT
		ZONE #1
		.	AIR VENT
	DO NOT EXCEED	.
	DO NOT EXCEED
	12" APART			AIR SEPARATOR
				PRESSURE	SHUTOFF
				PRESSURE	VALVE
				REDUCING	VALVE
				REDUCING
				VALVE
			ISOLATION		MAKE UP
			VALVE		MAKE UP
			VALVE		WATER
					WATER
					SUPPLY
PURGE/	ISOLATION				BACK FLOW
PURGE/	VALVE
DRAIN	VALVE
DRAIN					PREVENTOR
VALVE					PREVENTOR
VALVE					(IF REQUIRED)
					(IF REQUIRED)
	BOILER LOOP
	CIRCULATOR			EXPANSION TANK
	(SUPPLIED WITH			EXPANSION TANK
	(SUPPLIED WITH			(DIAPHRAM TYPE)
	THE BOILER)			(DIAPHRAM TYPE)
	THE BOILER)
			FLOW CHECK
	FLOW CHECK		VALVE
	VALVE
				ISOLATION	T + P
				VALVE	T + P
				VALVE	RELIEF
					RELIEF
			DHW		VALVE
			DHW
			CIRCULATOR
			RELIEF
			VALVE		HOT WATER
	BOILER WATER	BOILER WATER			HOT WATER
	BOILER WATER				OUTLET
	INLET (RETURN)
		OUTLET (SUPPLY)


				DOMESTIC
				HOT WATER
				TANK
					SHUTOFF
					VALVE
					COLD
					INLET
					WATER
				DRAIN VALVE	DRAIN VALVE

Figure 19. Zoning with circulators.

Image 27

Contents Installation and Operating Instructions Jaguar J-390 Boiler Ratings and DimensionsLocation and identification of parts Location and Identification of PartsMinimum Clearances from Combustible Constructions SafetyBoiler Location Boiler FoundationProducts to Avoid NON-DIRECT Vent InstallationDirect Vent Installation Contamination PreventionVent and AIR Intake Materials Flue GAS Venting RequirementsVent and AIR Intake Restrictions PVC/CPVC Pipe General Assembly MethodNON-DIRECT Vent Vertical Venting Venting InstallationSidewall Venting NON-DIRECT Vent Vent Termination Location and Clearances10 MAX Jaguar J-390 NON-DIRECT VENT, Sidewall VentingFT. MIN Jaguar J-390 NON-DIRECT VENT, Venting Through a RoofFT. MIN Thick Wall Jaguar J-390 Direct VENT, Sidewall VentingDIA PVC/CPVC Pipe for Vent Combustion Screw Jaguar Model J-390 FT. MIN Direct Vent Venting and AIR Intake Through a RoofGAS Piping Venting and AIR Intake System Regular InspectionCondensate Removal System Commonwealth of Massachusetts Special RequirementOutdoor AIR Sensor Electrical WiringSpace Heating Thermostats Domestic HOT Water Tank Thermostat101112 Boiler Control 120V 3 4 5 6 7 3 4 5 6 7 Thermostat Water Piping Water Outlet Piping Jaguar Tank PipingFeet w.c Zoning with circulators Zoning with zone valves Piping a heating-cooling system to the boiler and a chiller Before Firing BOILER, make these checks View and Changing TemperaturesViewing and changing system setting Operating Instructions Filling and Venting Water SystemsBoiler Operation Status Jaguar Boiler Display BoardIf outdoor sensor is used Viewing and Changing TemperaturesBoiler model selection, value is 5 for model J-390 Water To Turn OFF GAS to Appliance Safety InformationIII. Initial Start InstructionsJaguar Model J-390 Sequence of Operation IV. Check Combustion and Fuel Input Rate Gas valve adjustmentCheck for gas leaks Safety CheckControl Safety Shutdown test VI. Diagnostic Error Codes19, 42 Going to the sensor, or replace the sensor. If no sen If Replacement Parts are Needed Care and MaintenanceGeneral Maintenance III. CleaningGeneral Troubleshooting Guide for Service Personnel Jaguar Model J-390 SLANT/FIN CORPORATION, Greenvale, N.Y Phone 516