Quadra-Fire MTVERNINSAE-CSB, MTVERNINSAE-PMH, MTVERNINSAE-MBK, MTVERNINSAE-CWL owner manual Fasteners

Page 52

Mt. Vernon Pellet Insert (AE)

R

IMPORTANT: THIS IS DATED INFORMATION. When requesting service or replacement

 

 

parts for your appliance please provide model number and serial number. All parts listed

 

Stocked

in this manual may be ordered from an authorized dealer.

 

 

at Depot

ITEM

DESCRIPTION

COMMENTS

PART NUMBER

 

 

 

 

 

 

 

Top Mount Left

 

SRV7036-117

 

 

 

 

 

 

 

Top Mount Right

 

SRV7036-115

 

 

 

 

 

 

 

Vacuum Hose - Field Cut to Size

3 Ft.

SRV7000-373

Y

 

 

 

 

 

 

Wire Harness Battery Backup

 

7034-202

Y

 

 

 

 

 

 

Wire Harness Convection Blower

 

7034-219

Y

 

 

 

 

 

 

Wire Harness Door/Hopper

 

SRV7034-192

Y

 

 

 

 

 

 

Wire Harness Ignitor

 

SRV7034-199

Y

 

 

 

 

 

 

Wire Harness Power Out Ac

AC Current

7034-220

Y

 

 

 

 

 

 

Wire Harness Power Out Dc

DC Current

7034-221

Y

 

 

 

 

 

 

Wire Harness Power Supply Receptacle

 

SRV7034-233

Y

 

 

 

 

 

 

Wire Harness Snap Disc

 

7034-193

Y

 

 

 

 

 

 

Wire Harness Thermostat

 

SRV7034-200

Y

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

Fasteners

 

 

 

 

 

 

 

 

 

Avk Rivnut Repair Kit - 1/4-20 & 3/8-16 Rivnut Tools

 

RIVNUT-REPAIR

Y

 

 

 

 

 

 

Bolt, Shoulder, 5/16 X 1/4-20

Pkg of 20

223-0170/20

Y

 

 

 

 

 

 

Hitch Pin Clip 3/32

Pkg of 10

7000-374/10

Y

 

 

 

 

 

 

Nut, Ser Flange Small 1/4-20

Pkg of 24

226-0130/24

Y

 

 

 

 

 

 

Screw, 1/4-20 X 3/8 Phillips Button Head

Pkg of 24

7000-401/24

Y

 

 

 

 

 

 

Screw 1/4-20 X 5/8 Phillips Pan Head

Pkg of 24

7000-398/24

Y

 

 

 

 

 

 

Screw, Pan Head Philips 8-32 X 3/8

Pkg of 40

225-0500/40

Y

 

 

 

 

 

 

Screw, Flat Head Philips 8-32 X 1/2

Pkg of 10

832-0860

Y

 

 

 

 

 

 

Screw, Sheet Metal #8 X 1/2 S-Grip

Pkg of 40

12460/40

Y

 

 

 

 

 

 

Washer, 1/4 Sae

Pkg of 24

28758/24

Y

 

 

 

 

 

 

Wing Thumb Screw 8-32 X 1/2

Pkg of 24

7000-223/24

Y

 

 

 

 

 

 

Wire Clip

Pkg of 10

7000-400/10

Y

 

 

 

 

 

Additional service part numbers appear on following page.

Page 52

7036-135G

November 22, 2011

Page 51 Page 53
Image 52
Page 51 Page 53
Contents Installation and Operation Hot glass will cause burnsMt. Vernon Pellet Insert AE Label Location On Beaded Chain on e behind Right Side PanelTable of Contents Listing and Code Approvals Appliance Certifi cationMobile Home Approved Glass Specifi cationsDesign, Installation & Location Considerations Getting StartedAppliance Location Floor SupportTools And Supplies Needed Inspect Appliance and ComponentsPre-Use Check List Thermostat Wall Control Location3Dimensions and Clearances Appliance DimensionsInch Clearance To Exposed Section And Face Trim Built-in Unit Rear Vent with Outside AirMt. Vernon Pellet Insert AE Built-In Vertical Masonry and Zero Clearance FireplacesFloor Protection Minimum Opening for Masonry and Zero Clearance FireplacesStarter hole Mark area of floor to cut Mt. Vernon Pellet Insert AE Prefabricated Metal Chimney Altering the Factory-Built Fireplace4Vent Information Venting Termination Minimum RequirementsDo not Terminate Vent Termination must exhaust above air inlet elevationNegative Pressure, Shut-Down and Electrical Power Failure Optional Battery Back-UpMt. Vernon Pellet Insert AE Avoiding Smoke and Odors Outside AirMt. Vernon Pellet Insert AE Negative Pressure Draft Equivalent Feet of Pipe Mt. Vernon Pellet Insert AE Chimney and Exhaust ConnectionExample of 3 Elbow-Rear Vent Termination Calculation Mt. Vernon Pellet Insert AE Pipe Selection Chart Altitude in Thousands of Feet5Venting Systems Full Reline With Outside Air Horizontal305mm min. above 305mm min. below Never Install in a Sleeping Room 6Mobile HomeLeveling System 7Appliance Set-UpOutside Air Kit Instructions Mt. Vernon Pellet Insert AE Hearth Support Removal of Cast SidesMt. Vernon Pellet Insert AE Surround and Trim Set Cast Surround & Trim Set, BasicRebox. Figures 23.1 Optional Log Set Placement InstructionsRebox. Figures 23.3 7036-135G November 22 Fire Safety 8Operating InstructionsCombustible/Non-Combustible Materials Fuel Material and Fuel StorageThermostat Wall Control Automatic Setting Thermostat Wall Control Manual SettingAuto-Clean Firepot System General Operating InformationFire Characteristics and Flame Height Feed Rate Adjustment Mt. Vernon Pellet Insert AE Before Your First FireFilling the Hopper with Fuel Starting Your First FireMt. Vernon Pellet Insert AE Battery Back-up System Optional Clear SpaceMt. Vernon Pellet Insert AE Ignition Cycles Insert Removal Auto-Clean CycleAdditional Screen Messages Mt. Vernon Pellet Insert AE Quick Start Guide Or CWall Control for Reference 74ºF Frequently Asked Questions Issues SolutionsError Message Possible Cause Corrective ActionQuick Reference Maintenance Chart Proper Shutdown Procedure10Maintaining & Servicing Your Appliance Before Servicing Your ApplianceGeneral Maintenance and Cleaning Auto-Clean System Inspection & CleaningCleaning Ash Pan Ash Removal from FireboxLarge Clinker Cleaning Heat Exchanger, Drop Tube & Exhaust Example of a dirty heat exchangerLoosen all 6 nuts, but do not Remove Cleaning the Hopper Cleaning the GlassDoor Latch Inspection Preparing Firebox for Non-Burn SeasonBaffl e Removal Fire and Smoke RiskGlass Replacement Convection Blower ReplacementConvection Blower Replacement Cont’d Convection Blower ReplacementReference Materials Power Supply Thermocouple on Drop Tube Vacuum SwitchOverheat Sensor Snap Disc Thermocouple FirepotFeed Motor, Vacuum Switch, Exhaust Blower, Overheat Sensor Mt. Vernon Pellet Insert AE Component LocationsMt. Vernon Pellet Insert AE Exploded Drawings Part number list on following pagesStocked at Depot Stocked At Depot#38 Feed Assembly 38.5 38.6 38.4 38.3 38.2 38.1 Stocked at Depot #39 Firepot Riser Assembly #40 Auto-Clean Motor/Arm AssemblyStocked At DepotFasteners Accessories SP-MTVS-GDMt. Vernon Pellet Insert AE Mt. Vernon Pellet Insert AE Contact Information
Top Page Image Contents