New Buck Corporation 74 installation instructions Table Of Contents

Page 3

TABLE OF CONTENTS
Important Instructions	2
SECTION I: Introduction	3
Type of wood and loading procedures …………………………………….. ……………..3
SECTION II: Masonry Insert Installation	4
Installation Preparation-Fireplace	5
Mounting the Trim Panels	7
SECTION III: Pre-Fab Insert Installation	10
SECTION IV: Residential Freestanding Installation	11
Clearances To Combustibles Freestanding Without Close Clearance
Shields and Using Single Wall Pipe……………………………………………………..19
Residential / Mobile Home Double Wall or Shielded Single Wall
Connector With Close Clearance Shields……………………….……………………….20
Residential / Mobile Home Double Wall or Shielded Single Wall
Connector Without Close Clearance Shields……………………….…………………....21
Installation of Close Clearance Shields (Optional)	22
Alcove Installation Double or Shielded Single Wall Connector With Close
Clearance Shields	23
SECTION V: Freestanding Mobile Home Installation	24
SECTION VI: Wood Heater Safety	30
SECTION VII: Operation	31
SECTION VIII: Troubleshooting	32
Warranty………………………………………………………………………………… 34

1

Image 3

Contents BUCKSTOVE Page TABLE OF CONTENTS IMPORTANT INSTRUCTIONS INSTALLATION, OPERATION, ANDMAINTENANCE INSTRUCTIONS MODEL BEFORE INSTALLING YOUR NEW BUCK STOVEINTRODUCTION SECTIONSECTION MASONRY INSERT INSTALLATIONMINIMUM CLEARANCE MASONRY INSERT MODELINSTALLATION OPTIONS POSSIBLE TOOLS NEEDED FOR INSTALLATIONINSTALLATION PREPARATION MASONRY INSERT INSTALLATIONOPTION B AIRTIGHT INSU LATED CLEAN OUT REMOVE DAMPEROR WIRE IT OPEN OPTION AMOUNTING THE TRIM PANELS INSTALLATION PROCEDUREPOSITIONING THE HEATER POSITIONINGFINAL CHECK Page SECTION PRE-FABINSERT INSTALLATION SECTION RESIDENTIAL FREESTANDING INSTALLATION PREPARING THE STOVE FOR INSTALLATIONheater to the remainder of the home Floor Protection ChimneyDETERMINING THE CHIMNEY LOCATION B. Wall Exit Into Metal Tee-Box Page D. Ceiling Exit-CloseClearance COLLAR Alcove Installation ClearancesFINAL CHECK CLEARANCES FOR MODEL MINIMUM CLEARANCES TO COMBUSTIBLES RESIDENTIAL / MOBILE HOMECLEARANCES FOR MODEL MINIMUM CLEARANCES TO COMBUSTIBLES CONNECTOR WITHOUT CLOSE CLEARANCE SHIELDSDOUBLE WALL OR SHIELDED SINGLE WALL CLEARANCES FOR MODELInstallation of Close Clearance Shields Optional B H C CLEARANCES FOR MODEL ALCOVE INSTALLATION DOUBLEOR SHIELDED SINGLE WALL CONNECTOR WITH CLOSE CLEARANCE SHIELDSFLOOR PROTECTION SECTION FREESTANDING MOBILE HOME INSTALLATIONTOOLS FOR INSTALLATION PREPARING THE HEATER FOR INSTALLATIONCHIMNEY PREPARING THE LOCATION FOR ROOM HEATER Ceiling Exit Using Close Clearance listed chimney Page 1.Recheck the specified clearances FINAL CHECKSECTION WOOD HEATER SAFETY BUILDING A FIRE SECTION OPERATIONPOSSIBLE CAUSE SECTION TROUBLESHOOTINGPROBLEM SOLUTIONPROBLEM SOLUTIONPOSSIBLE CAUSE PRODUCTS COVERED WARRANTY TIME PERIODSPROCEDURE NEW BUCK CORPORATION NBCOTHER RIGHTS CONDITIONS AND EXCLUSIONS