Crown Boiler 24-06, 24-11, 24-10, 24-08, 24-12, 24-05, 24-09, 24-03, 24-04, 24-07 Rear Target Wall Carton

Page 64

REAR FLUE OUTLET CARTON

	KEY	DESCRIPTION	CROWN		QUANTITY
	KEY	DESCRIPTION	PART #	7	8	10	12
			PART #	7	8	10	12
		7" REAR OUTLET DAMPER ASSY	333007	1
	20A	8" REAR OUTLET DAMPER ASSY	333008		1
	20A	10" REAR OUTLET DAMPER ASSY	333010			1
		10" REAR OUTLET DAMPER ASSY	333010			1
		12" REAR OUTLET DAMPER ASSY	333012				1
		TOP OUTLET COVER, 7"& 8" OPENING	333017	1	1
	21B	TOP OUTLET COVER, 10" OPENING	333020			1
		TOP OUTLET COVER, 12" OPENING	333022				1

BURNER MOUNTING PLATE CARTON

	KEY	DESCRIPTION	CROWN	QUANTITY
	KEY	DESCRIPTION	PART #	8"	4"
			PART #	8"	4"
		B.M.P., 4" CARTON COMPLETE*	330404	0	1
		B.M.P., 8" CARTON COMPLETE*	330408	1	0
		5/16 X 1" CAP SCREW	900410	8	8
	23	5/16" WASHER	900102	8	8
	23	3/8 X 7/8 CAP SCREW	900450	5	5
		3/8 X 7/8 CAP SCREW	900450	5	5
		3/8 FLAT WASHER	90-036	4	4
		3/8 LOCK WASHER		9	9
		FLEXROPE, 3/16" DENSE	333005	6.5 ft	6.5 ft

BURNER ADAPTOR PLATE CARTON

KEY	DESCRIPTION	CROWN			QUANTITY
KEY	DESCRIPTION	PART #	920	921		922		923	924
		PART #	920	921		922		923	924
	BECKETT B.A.P. ASSY, 920	330400	1
	BECKETT B.A.P. ASSY, 921	330401		1
28	BECKETT B.A.P. ASSY, 922	330402				1
28	BECKETT B.A.P. ASSY, 923	330403						1
	BECKETT B.A.P. ASSY, 923	330403						1
	BECKETT B.A.P. ASSY, 924	330404							1
	BURNER ADAPTOR PLATE GASKET	333405	1	1		1

REAR FLAME OBSERVATION PORT CARTON

	KEY	DESCRIPTION	CROWN	QUANTITY
	KEY	DESCRIPTION	PART #	QUANTITY
			PART #
		REAR FLAME OBSERVATION PORT ASSY	333000	1
	29	5/16 X 1" CAP SCREW		4
	29	5/16" WASHER		4
		5/16" WASHER		4
		FLEXROPE, 3/16" DENSE	333005	2.83 ft

REAR TARGET WALL CARTON

	DESCRIPTION	CROWN	QUANTITY
	DESCRIPTION	PART #	QUANTITY
		PART #
	TARGET WALL	335025	1

64

Image 64

Contents Series Page Important Information Read Carefully Page Page Table of Contents Table of Contents Section I General Information Boiler RATINGS/DATA Section I General Information Locate the UnitBoiler Foundation Chimney or VentVents Faults & Suggestions Section II Cast Iron Block Assembly Assembly of Sections Manual DRAW- UPNipple Gauge Series 24 Section Arrangement Draw-Up Rods Alternating Pattern Manual Draw-up Center Section Channel Block Position Partial Block Draw-Up Hydraulic Draw-Up of Sections Section III Installation Instructions Canopy with Rear Flue Outlet Damper AssemblyBare Boiler Assembly Avoid Breathing Fiber Particulates and Dust Left Side Canopy Intermediate Bracket Mount Rear Observation Port Cover Refer to Figure Inspect ALL Boiler SealsSeries 24 Jacket Assembly Boiler Models 24-03 thru Burner Mounting Plate Refer to Figures 16 Mount Burner Adapter Plate to Burner Mounting PlatePurpose of Tappings Steam Boilers Steam Trim Steam Boilers Install Steam Trim This Is Intentionally Left Blank Purpose of Tappings Water Boilers Water Trim Burner Installation Water Boilers Install Water TrimBoiler Piping Heating Applications Page Parallel Piping Conversion Recommendation 1 Use when Recommendation 2 Use when Recommendation 3 Use when Page Page Page BMounting Elevations M&M 150, 64 Float Low Water Cut-offs Schematic Tankless Heater Piping 24-08 24-09 Return Temperature Control and Components CCW Open to SystemWater Boiler Pressure Relief Valve Hook-Up Typical Boiler Wiring with RTC Front Typical Boiler with RTC Return Sensor Rear Always Inspect Installation Before Section IV Operating InstructionsStarting Burner Fill Heating System with WaterFlame Failure Boil MIN Delay Test Controls Check Operation of High Limit ControlBoiler and System Cleaning Steam Boiler Boiler and System Cleaning Water Boilers Frequent Water Addition Oxygen CorrosionSection V Service Instructions Clean the Boiler FluewaysMaintenance of LOW Water Cutoff Devices General Maintenance Considerations OperationSection VI Burner Specifications OIL BurnersSection VII Repair Parts & Carton Contents Series 24 Master Parts List Section VII Repair Parts Jacket Carton Bare Boiler Assembly Section Joiner Carton Assy Rear Target Wall Carton Standard Steam Trim Carton Assy RTC Carton with Outdoor Reset Tankless Coil Components Boiler Water Section Viii Appendix Page Mechanical Page Mechanical Electrical Page Page Page Page Page Page Page Page Series 24 Boiler Circulator Selection Taco 20F Differential Boiler Recirculation Grundfos Circulating Pump Way Boiler Recirculation Bell and Gossett Circulating Pump Way Boiler Recirculation Armstrong Circulating Pump Way Appendix C Valve and Actuator Mounting Instructions ApplicationService Record PN 980417 S24 12/05