Crown Boiler 24-10, 24-11, 24-08, 24-12, 24-06, 24-05, 24-09, 24-03, 24-04, 24-07 Water Trim

Page 31

Figure 26b: Water Trim

KEY	DESCRIPTION	BOILER MODELS
1	3" SQ. HD. PLUG	24-03 THRU 24-12
1	3" SQ. HD. PLUG	24-12 WITH 20° DROP
2	1" RECESSED HD PLUG	ALL
3	3" X 3/4" BLK BUSHING	ALL
4	3/4" CLOSE NIPPLE	ALL
5	3/4" BALL VALVE	ALL
6	3/4" SQ. HD. PLUG	ALL
7	1/2" RECESSED HD PLUG	ALL
8	3/4" LONG WELL	ALL
9	L4006E1109	CSD-1 EQUIPPED BOILERS
10	#550 PROBE LWCO	CSD-1 EQUIPPED BOILERS
11	L4006A2015	ALL
12	FIRING RATE TEMP CTRL	MODULATING BOILERS
13	TRIDICATOR GAUGE	ALL
14	1/2" X 1/4" BLK BUSHING	ALL
15	4" BK PLUG	ALL
NOT	3/4" RECESSED HD. PLUG	ALL
SHOWN	3/4" RECESSED HD. PLUG	ALL

QUANTITY

STANDARD	OPTIONAL	NOT SUPPLIED
2
1
4
1
		1
		1
		1
2
1	1	1
	1
	1
1
		1
1
1
1
4

KEY	DESCRIPTION	BOILER MODELS
16	1-1/2" x 3/4" BLK BUSHING	24-03 THRU 24-07
16	1-1/2" x 1" BLK BUSHING	24-08 THRU 24-10
16	1-1/2" x 1-1/4" BLK BUSHING	24-11 THRU 24-12
17	3/4" X 3" NIPPLE	24-03 THRU 24-07
17	1" X 4" NIPPLE	24-08 THRU 24-10
17	1-1/4" X 4" NIPPLE	24-11 THRU 24-12
18	3/4" 90° ELBOW	24-03 THRU 24-07
18	1" 90° ELBOW	24-08 THRU 24-10
18	1-1/4" 90° ELBOW	24-11 THRU 24-12
19	3/4" CLOSE NIPPLE	24-03 THRU 24-07
19	1" CLOSE NIPPLE	24-08 THRU 24-10
19	1-1/4" CLOSE NIPPLE	24-11 THRU 24-12
20	RELIEF VALVE 10-408-05	24-03 THRU 24-04
20	RELIEF VALVE 10-614-05	24-05 THRU 24-07
20	RELIEF VALVE 10-615-05	24-08 THRU 24-10
20	RELIEF VALVE 10-616-05	24-11 THRU 24-12

QUANTITY

STANDARD

OPTIONAL

NOT SUPPLIED

1

1

1

1

1

1

1

1

1

1

1

1

1

1

1

1

31

Image 31

Contents Series Page Important Information Read Carefully Page Page Table of Contents Table of Contents Section I General Information Boiler RATINGS/DATA Locate the Unit Section I General InformationChimney or Vent Boiler FoundationVents Faults & Suggestions Assembly of Sections Manual DRAW- UP Section II Cast Iron Block AssemblyNipple Gauge Series 24 Section Arrangement Draw-Up Rods Alternating Pattern Manual Draw-up Center Section Channel Block Position Partial Block Draw-Up Hydraulic Draw-Up of Sections Canopy with Rear Flue Outlet Damper Assembly Section III Installation InstructionsBare Boiler Assembly Avoid Breathing Fiber Particulates and Dust Left Side Canopy Intermediate Bracket Inspect ALL Boiler Seals Mount Rear Observation Port Cover Refer to FigureSeries 24 Jacket Assembly Boiler Models 24-03 thru Mount Burner Adapter Plate to Burner Mounting Plate Burner Mounting Plate Refer to Figures 16Purpose of Tappings Steam Boilers Steam Trim Steam Boilers Install Steam Trim This Is Intentionally Left Blank Purpose of Tappings Water Boilers Water Trim Burner Installation Water Boilers Install Water TrimBoiler Piping Heating Applications Page Parallel Piping Conversion Recommendation 1 Use when Recommendation 2 Use when Recommendation 3 Use when Page Page Page BMounting Elevations M&M 150, 64 Float Low Water Cut-offs Schematic Tankless Heater Piping 24-08 24-09 CCW Open to System Return Temperature Control and ComponentsWater Boiler Pressure Relief Valve Hook-Up Typical Boiler Wiring with RTC Front Typical Boiler with RTC Return Sensor Rear Fill Heating System with Water Always Inspect Installation BeforeSection IV Operating Instructions Starting BurnerFlame Failure Boil MIN Delay Check Operation of High Limit Control Test ControlsBoiler and System Cleaning Steam Boiler Boiler and System Cleaning Water Boilers Oxygen Corrosion Frequent Water AdditionClean the Boiler Flueways Section V Service InstructionsMaintenance of LOW Water Cutoff Devices Operation General Maintenance ConsiderationsOIL Burners Section VI Burner SpecificationsSection VII Repair Parts & Carton Contents Series 24 Master Parts List Section VII Repair Parts Jacket Carton Bare Boiler Assembly Section Joiner Carton Assy Rear Target Wall Carton Standard Steam Trim Carton Assy RTC Carton with Outdoor Reset Tankless Coil Components Boiler Water Section Viii Appendix Page Mechanical Page Mechanical Electrical Page Page Page Page Page Page Page Page Series 24 Boiler Circulator Selection Taco 20F Differential Boiler Recirculation Grundfos Circulating Pump Way Boiler Recirculation Bell and Gossett Circulating Pump Way Boiler Recirculation Armstrong Circulating Pump Way Application Appendix C Valve and Actuator Mounting InstructionsService Record PN 980417 S24 12/05