State Industries Green Choice instruction manual Residential Direct Vent GAS Water Heaters

Page 1

Instruction Manual

RESIDENTIAL DIRECT VENT GAS WATER HEATERS

NOT FOR USE IN MANUFACTURED (MOBILE) HOMES

GAMA certification applies to all residential gas water heaters with capacities of 20 to 100 gallons with input rating of 75,000 BTU/Hr. or less.

For Your Safety

AN ODORANT IS ADDED TO THE GAS USED

BYTHIS WATER HEATER.

ALL TECHNICAL AND WARRANTY QUESTIONS: SHOULD BE DIRECTED TO THE LOCAL DEALER FROM WHOM THE WATER HEATER WAS PURCHASED.IFYOUAREUNSUCCESSFUL,PLEASEWRITETOTHECOMPANYLISTEDONTHERATINGPLATEONTHEWATERHEATER.

 

KEEP THIS MANUAL IN THE POCKET ON HEATER FOR FUTURE REFERENCE

PRINTED 1005

WHENEVER MAINTENANCE ADJUSTMENT OR SERVICE IS REQUIRED.

183774-001

Image 1
Contents Residential Direct Vent GAS Water Heaters Important Definitions Safe INSTALLATION, USE and ServiceGeneral Safety Introduction Table of ContentsGET to Know Your Water Heater GAS Models Typical InstallationMixing Valve Usage Facts to Consider about the Location Locating the NEW Water HeaterVenting Clearances Combustion Air and VentilationFlue Extensions Optional Wire GrillChart #2 Chart #1Vertical Height Extension Kit Horizontal Extension KitStandard Vent Kit Installation #1 ALL InstallationsCutting The Opening Through The Outside Wall Water Heater AttitudePage Page BTU’s in 1000’s NAT./L.P Chart #3 GAL CAPPage Page Optional Horizontal Vent Kit Installation #3 Page Through The Outside Wall. See Optional Vertical and Horizontal Vent Kit Installation #4Chart #4 GAL CAP Collar Optional Vent Cap Porcelain-Enameled Page Page Water Piping Installing the NEW Water HeaterValve and Pipe Insulation TEMPERATURE-PRESSURE Relief ValveFilling the Water Heater GAS Piping Sediment Traps GAS Piping with Flexible ConnectorGAS Piping with ALL Black Iron Pipe to GAS Control Before Lighting the Pilot Installation ChecklistPage For Your Information Temperature RegulationStart UP Conditions CondensateOperational Conditions Burner Cleaning Periodic MaintenanceGAS Control Valve & Burner Assembly Venting System InspectionHousekeeping TEMPERATURE-PRESSURE Relief Valve OperationAnode ROD Inspection DrainingLeakage Checkpoints Drain Valve Washer ReplacementRepair Parts List BTU’s in 1000’s NAT/L.P 36/36 38/38 40/40 48/44 55 NAT Parts GAL. CAP KEY # DescriptionRepair Parts List BTU’s in 1000’s NAT/L.P 36/36 38/38 40/40 48/44 This is a Repair Parts LIST, not a Packing ListTroubleshooting Guidelines Page Page