State Industries Green Choice Typical Installation, GET to Know Your Water Heater GAS Models

Page 5

TYPICAL INSTALLATION

GET TO KNOW YOUR WATER HEATER - GAS MODELS

A	Vent Assembly	I	Ground Joint Union
B	Flue Outlet	J	Drip Leg (Sediment Trap)
C	Anode	K	Inner Door
D	Hot Water Outlet	L	Outer Doors with Gaskets
E	Outlet	M	Union
F	Insulation	N	Inlet Water Shut-off Valve
G	Gas Supply	O	Cold Water Inlet

HManual Gas Shut-off Valve

*INSTALL IN ACCORDANCE WITH LOCAL CODES.

*DRIP LEG AS REQUIRED BY LOCAL CODES.

PInlet Dip Tube

QTemperature-Pressure Relief Valve

RRating Plate

SFlue Baffle

TThermostat

UDrain Valve

VPilot and Main Burner W Flue

X Drain Pan

Y Piezo Ignitor

Z Thermostat Shield (optional)

(V)PILOT & MAIN BURNER

(T) THERMOSTAT

*ALL PIPING MATERIALS TO BE SUPPLIED BY CUSTOMERS.

FIGURE1.

5

Image 5

Contents Residential Direct Vent GAS Water Heaters Important Definitions Safe INSTALLATION, USE and ServiceGeneral Safety Introduction Table of ContentsGET to Know Your Water Heater GAS Models Typical InstallationMixing Valve Usage Facts to Consider about the Location Locating the NEW Water HeaterVenting Clearances Combustion Air and VentilationFlue Extensions Optional Wire GrillChart #2 Chart #1Vertical Height Extension Kit Horizontal Extension KitStandard Vent Kit Installation #1 ALL InstallationsCutting The Opening Through The Outside Wall Water Heater AttitudePage Page BTU’s in 1000’s NAT./L.P Chart #3 GAL CAPPage Page Optional Horizontal Vent Kit Installation #3 Page Through The Outside Wall. See Optional Vertical and Horizontal Vent Kit Installation #4Chart #4 GAL CAP Collar Optional Vent Cap Porcelain-Enameled Page Page Water Piping Installing the NEW Water HeaterValve and Pipe Insulation TEMPERATURE-PRESSURE Relief ValveFilling the Water Heater GAS Piping GAS Piping with ALL Black Iron Pipe to GAS Control GAS Piping with Flexible ConnectorSediment Traps Before Lighting the Pilot Installation ChecklistPage For Your Information Temperature RegulationStart UP Conditions CondensateOperational Conditions Burner Cleaning Periodic MaintenanceGAS Control Valve & Burner Assembly Venting System InspectionHousekeeping TEMPERATURE-PRESSURE Relief Valve OperationAnode ROD Inspection DrainingLeakage Checkpoints Drain Valve Washer ReplacementRepair Parts List BTU’s in 1000’s NAT/L.P 36/36 38/38 40/40 48/44 55 NAT Parts GAL. CAP KEY # DescriptionRepair Parts List BTU’s in 1000’s NAT/L.P 36/36 38/38 40/40 48/44 This is a Repair Parts LIST, not a Packing ListTroubleshooting Guidelines Page Page