Frymaster BIELA14 manual 1.14.7 M3000 Menu Summary Tree, Adding New Menu Items

Page 45

1.14.7 M3000 Menu Summary Tree

1.14.7 M3000 Menu Summary Tree

Reflected below are the major programming sections in the M3000 and the order in which submenu headings will be found under the sections in the Installation and Operation Manual.

Adding New Menu Items	See section	4.10.2
Storing Menu Items in Product Buttons	See section	4.10.3
Draining, Refilling, and Disposing of Oil	See section	4.10.4

1-38

Image 45

Contents FRYMASTER BIELA14 SERIES GEN LOV ELECTRIC FRYER SERVICE AND PARTS MANUALemail: service@frymaster.com 8196446NOTICE NOTICENOTICE DANGERDANGER Do not use water jets to clean this equipmentDANGERi DANGERB.WARRANTY PROVISIONS - FRYPOTS A.WARRANTY PROVISIONS - FRYERSD.WARRANTY EXCLUSIONS C.PARTS RETURNELECTRICAL POWER SPECIFICATIONS TABLE OF CONTENTS BIELA14 SERIES GEN II LOV ELECTRIC FRYERSCHAPTER 1: Service Procedures TABLE OF CONTENTS cont CHAPTER 2: Parts ListBIELA14 SERIES GEN II LOV ELECTRIC FRYERS BIELA14 SERIES GEN II LOV ELECTRIC FRYERS CHAPTER 1: SERVICE PROCEDURES1.1 General 1.2 Replacing a Computer3.Remove the two screws from the upper corners of the computer and allow the computer to swing down 1.4 Replacing a High-LimitThermostat DANGER1.5 Replacing a Temperature Probe 4.Locate the red or yellow and white wires of the temperature probe to be replaced. Note where the leads are connected prior to removing them from the connector. Unplug the 12-pinconnector C-6and using a pin-pusherpush the pins of the temperature probe out of the connector 1.6Replacing a Heating Element Full vat element wire routing Dual vat element wire routingElement grounding and wire routing 1.7Replacing Contactor Box Components DANGER 1.8 Replacing a Frypot17.Disconnect the oil return flexlines malfunction DANGER 1.9.3 Replacing the Transformer or Filter Relay 1.10.1 ATO Automatic Top-offTroubleshooting 1.10 ATO Automatic Top-offService ProceduresProblem Probable CausesSERVICE ProblemProbable Causes Corrective ActionWire Reset Switch 1.10.4 Replacing the ATO PumpDrain Switch SwitchThe following buttons are inoperable in auto mode Buttons and LED’sConstant Illumination: Drain open No Illumination: Drain closedProblem 1.11.2 MIB Manual Interface Board TroubleshootingProbable Causes Corrective ActionProbable Causes ProblemCorrective Action 1-19Connector DISPLAY ResettingEXPLANATION Drain1.11.6 Replacing the MIB Board 1.11.7 Control Power Reset SwitchTroubleshooting 1.12RTI Service Issues 1.12.1 RTI MIB TestsWaste full signal AC voltage measurements1.12.2 RTI LOV Wiring DISPOSE TO WASTE, REFILL VAT FROM BULK 1.12.4 RTI LOV TEST QUICK REFERENCEDISPOSE TO WASTE FILL VAT FROM BULKFILL JUG FROM BULK 1.13.1 AIF Troubleshooting ProblemCorrective Action Probable CausesWire 1.13.4 Replacing a Linear Actuator Problem 1.13.5 Replacing a Rotary ActuatorRECOVERY FAULTProblem Probable CausesMISCONFIGURED Corrective ActionProblem Probable CausesCorrective Action 1.14.2 M3000 Useful Codes PASSWORDSProblem •0469 – Reset FILTER STAT DATAERROR MESSAGE 1.14.3 Service Required ErrorsEXPLANATION 1-34 ERROR MESSAGE 1.14.4 Error Log Codes EXPLANATION 1-351.14.5 Tech Mode ERROR 1.14.6 M3000 Filter Error Flowchart NORMALSYSTEM ERROR FIXED? YES OPERATION RESUMESAdding New Menu Items 1.14.7 M3000 Menu Summary TreeStoring Menu Items in Product Buttons Draining, Refilling, and Disposing of Oil1.14.8 M3000 Board Pin Positions and Harnesses SETUP COMPLETE is displayed 1.15Loading and Updating Software ProceduresUNTIL THE DISPLAY PROMPTS TO DO SO IN STEP 24.FILTER NOW YES/NO is displayed1.16 BIELA14 Series LOV Data Network Flowchart Diagnostic LED Legend 1.17 Interface Board Diagnostic ChartPN 826-2260 1-42Probe Resistance Chart 1.18 Probe Resistance ChartOHMS OHMS1.19.1 Component Wiring Domestic 1.19 Wiring Diagrams1.19.2 Component Wiring CE 1.19.3 Component Wiring CSA 1.19.4 Component Wiring Australia 1.19.5 Contactor Box – Delta Configuration 1.19.6 Contactor Box - WYE Configuration Page Page Page Page Page Accessories CHAPTER 2 PARTS LISTITEM PART #PART # ITEMCOMPONENT Not illustrated2.3.1 Drain Tube Sections and Associated Parts 2.3Drain System ComponentsPART# ITEMITEM 2.3.2.2 Rotary Actuator Drain ValvesPART # COMPONENTPage ITEM PART # 2.4.1 Component Boxes contboxes COMPONENT2.4.2Contactor Boxes PART # COMPONENT106-8658 2.4.3Heating Element Assemblies and Associated Parts 2.4.3.1 Element Assemblies and Hardware WYE units 2.4.3.1 Element Assemblies and Hardware contITEM PART # COMPONENT2.4.3.2 Element Tube Assemblies FULL-VATELEMENT ASSEMBLYDUAL-VATELEMENT ASSEMBLY 2.4.4 2.4.3.2 Element Tube Assemblies contdComputers ITEMCOMPONENT Contactor Box Harness Assembly Dual Vat 2.4.5WiringPART # ITEM PART #14/17 kW Mechanical Contactor 106-8744ITEM PART #2.4.5.5 Main Wiring Harnesses PART # Filter Pump C2 to Component Box Wiring HarnessCOMPONENT Full Vat Control Harness J4 to J2 StandardReset Switch 4-5Battery only 2.4.5.8 M3000, MIB, AIF and ATO Wiring Harnessesonly ITEMPage Filtration Components cont 2.5.1COMPONENT ITEMITEM PART # 2.5.2.2 Manual Interface Board AssemblyCOMPONENT ITEM PART #2.5.2.4 LOV PCB/Computer Board Matrix 2.5.2.3 AIF Board AssemblyITEM PART # COMPONENTSee Page 2-5for Drain Valve Assemblies PART #COMPONENT ITEM 2.6.2 Frypots with Rotary ActuatorsPART # COMPONENT2.8 Return Valves and Associated Parts 2.7 Oil Return ManifoldsITEM PART #2.8.2 Return Valve Rotary Actuators 2.9.2 JIB Cap and Pick Up Assembly2.9Auto Top Off Components 2.9.1 JIB Basket PART #2.9.3 Automatic Top Off Board Assembly 2.9.2 JIB Cap and Pick Up Assembly contshipping ITEMDomestic Units 2.9.4ATO Pump AssemblyInternational Units ITEMPART # ITEMCOMPONENT 108-30412.10RTI 2.10.1 RTI Manifold and Accessories ITEM 2.10.1 RTI Manifold and Accessories contPART # COMPONENT2.10.3 RTI Test Box 2.10.2RTI Dispose Waste ValveMicroswitch, Gold Sealed Valve, ½” Ball Cover, DV Safety Switch Cover, DV Safety SwitchConnectors and Tools ITEM 2.12FastenersPART # COMPONENTTHIS PAGE INTENTIONALLY LEFT BLANK FAX Parts SERVICE HOTLINETech Support 1-800-551-8633

Related manuals

Manual 86 pages 43.72 Kb

Manual 26 pages 13.97 Kb