Frymaster BIELA14 manual Probe Resistance Chart, Ohms

Page 50

1.18 Probe Resistance Chart

1.18 Probe Resistance Chart

Probe Resistance Chart

For use with fryers manufactured with Minco Thermistor probes only.

F	OHMS	C
60	1059	16
65	1070	18
70	1080	21
75	1091	24
80	1101	27
85	1112	29
90	1122	32
95	1133	35
100	1143	38
105	1154	41
110	1164	43
115	1174	46
120	1185	49
125	1195	52

	F	OHMS	C
	F	OHMS	C
	130	1204	54
	130	1204	54
	135	1216	57
	140	1226	60
	145	1237	63
	150	1247	66
	155	1258	68
	160	1268	71
	165	1278	74
	170	1289	77
	175	1299	79
	180	1309	82
	185	1320	85
	190	1330	88
	195	1340	91

F	OHMS	C
200	1350	93
205	1361	96
210	1371	99
215	1381	102
220	1391	104
225	1402	107
230	1412	110
235	1422	113
240	1432	116
245	1442	118
250	1453	121
255	1463	124
260	1473	127
265	1483	129

F	OHMS	C
270	1493	132
275	1503	135
280	1514	138
285	1524	141
290	1534	143
295	1544	146
300	1554	149
305	1564	152
310	1574	154
315	1584	157
320	1594	160
325	1604	163
330	1614	166
335	1624	168

	F	OHMS	C
	F	OHMS	C
	340	1634	171
	340	1634	171
	345	1644	174
	350	1654	177
	355	1664	179
	360	1674	182
	365	1684	185
	370	1694	188
	375	1704	191
	380	1714	193
	385	1724	196
	390	1734	199
	395	1744	202
	400	1754	204
	405	1764	207

1-43

Image 50

Contents email: service@frymaster.com SERVICE AND PARTS MANUALFRYMASTER BIELA14 SERIES GEN LOV ELECTRIC FRYER 8196446NOTICE NOTICENOTICE DANGERDANGERi Do not use water jets to clean this equipmentDANGER DANGERD.WARRANTY EXCLUSIONS A.WARRANTY PROVISIONS - FRYERSB.WARRANTY PROVISIONS - FRYPOTS C.PARTS RETURNELECTRICAL POWER SPECIFICATIONS CHAPTER 1: Service Procedures TABLE OF CONTENTSBIELA14 SERIES GEN II LOV ELECTRIC FRYERS BIELA14 SERIES GEN II LOV ELECTRIC FRYERS TABLE OF CONTENTS contCHAPTER 2: Parts List 1.1 General CHAPTER 1: SERVICE PROCEDURESBIELA14 SERIES GEN II LOV ELECTRIC FRYERS 1.2 Replacing a Computer3.Remove the two screws from the upper corners of the computer and allow the computer to swing down 1.5 Replacing a Temperature Probe 1.4 Replacing a High-LimitThermostatDANGER 4.Locate the red or yellow and white wires of the temperature probe to be replaced. Note where the leads are connected prior to removing them from the connector. Unplug the 12-pinconnector C-6and using a pin-pusherpush the pins of the temperature probe out of the connector 1.6Replacing a Heating Element Element grounding and wire routing Full vat element wire routingDual vat element wire routing 1.7Replacing Contactor Box Components 1.8 Replacing a Frypot DANGER17.Disconnect the oil return flexlines malfunction DANGER 1.9.3 Replacing the Transformer or Filter Relay Problem 1.10 ATO Automatic Top-offService Procedures1.10.1 ATO Automatic Top-offTroubleshooting Probable CausesProbable Causes ProblemSERVICE Corrective ActionWire Drain Switch 1.10.4 Replacing the ATO PumpReset Switch SwitchConstant Illumination: Drain open Buttons and LED’sThe following buttons are inoperable in auto mode No Illumination: Drain closedProbable Causes 1.11.2 MIB Manual Interface Board TroubleshootingProblem Corrective ActionCorrective Action ProblemProbable Causes 1-19Connector EXPLANATION ResettingDISPLAY Drain1.11.7 Control Power Reset Switch 1.11.6 Replacing the MIB BoardWaste full signal 1.12RTI Service Issues 1.12.1 RTI MIB TestsTroubleshooting AC voltage measurements1.12.2 RTI LOV Wiring DISPOSE TO WASTE 1.12.4 RTI LOV TEST QUICK REFERENCEDISPOSE TO WASTE, REFILL VAT FROM BULK FILL VAT FROM BULKFILL JUG FROM BULK Corrective Action Problem1.13.1 AIF Troubleshooting Probable CausesWire 1.13.4 Replacing a Linear Actuator RECOVERY 1.13.5 Replacing a Rotary ActuatorProblem FAULTMISCONFIGURED Probable CausesProblem Corrective ActionCorrective Action ProblemProbable Causes Problem PASSWORDS1.14.2 M3000 Useful Codes •0469 – Reset FILTER STAT DATAEXPLANATION 1.14.3 Service Required ErrorsERROR MESSAGE 1-34EXPLANATION 1.14.4 Error Log CodesERROR MESSAGE 1-351.14.5 Tech Mode SYSTEM ERROR FIXED? YES 1.14.6 M3000 Filter Error Flowchart NORMALERROR OPERATION RESUMESStoring Menu Items in Product Buttons 1.14.7 M3000 Menu Summary TreeAdding New Menu Items Draining, Refilling, and Disposing of Oil1.14.8 M3000 Board Pin Positions and Harnesses UNTIL THE DISPLAY PROMPTS TO DO SO IN STEP 1.15Loading and Updating Software ProceduresSETUP COMPLETE is displayed 24.FILTER NOW YES/NO is displayed1.16 BIELA14 Series LOV Data Network Flowchart PN 826-2260 1.17 Interface Board Diagnostic ChartDiagnostic LED Legend 1-42OHMS 1.18 Probe Resistance ChartProbe Resistance Chart OHMS1.19 Wiring Diagrams 1.19.1 Component Wiring Domestic1.19.2 Component Wiring CE 1.19.3 Component Wiring CSA 1.19.4 Component Wiring Australia 1.19.5 Contactor Box – Delta Configuration 1.19.6 Contactor Box - WYE Configuration Page Page Page Page Page ITEM CHAPTER 2 PARTS LISTAccessories PART #COMPONENT ITEMPART # Not illustratedPART# 2.3Drain System Components2.3.1 Drain Tube Sections and Associated Parts ITEMPART # 2.3.2.2 Rotary Actuator Drain ValvesITEM COMPONENTPage boxes 2.4.1 Component Boxes contITEM PART # COMPONENT2.4.2Contactor Boxes 106-8658 PART #COMPONENT 2.4.3Heating Element Assemblies and Associated Parts 2.4.3.1 Element Assemblies and Hardware ITEM PART # 2.4.3.1 Element Assemblies and Hardware contWYE units COMPONENTDUAL-VATELEMENT ASSEMBLY 2.4.3.2 Element Tube AssembliesFULL-VATELEMENT ASSEMBLY Computers 2.4.3.2 Element Tube Assemblies contd2.4.4 ITEMPART # 2.4.5WiringCOMPONENT Contactor Box Harness Assembly Dual Vat ITEM PART #ITEM 106-874414/17 kW Mechanical Contactor PART #2.4.5.5 Main Wiring Harnesses COMPONENT Filter Pump C2 to Component Box Wiring HarnessPART # Full Vat Control Harness J4 to J2 Standardonly 2.4.5.8 M3000, MIB, AIF and ATO Wiring HarnessesReset Switch 4-5Battery only ITEMPage COMPONENT 2.5.1Filtration Components cont ITEMCOMPONENT 2.5.2.2 Manual Interface Board AssemblyITEM PART # ITEM PART #ITEM PART # 2.5.2.3 AIF Board Assembly2.5.2.4 LOV PCB/Computer Board Matrix COMPONENTCOMPONENT See Page 2-5for Drain Valve AssembliesPART # PART # 2.6.2 Frypots with Rotary ActuatorsITEM COMPONENTITEM 2.7 Oil Return Manifolds2.8 Return Valves and Associated Parts PART #2.9Auto Top Off Components 2.9.1 JIB Basket 2.9.2 JIB Cap and Pick Up Assembly2.8.2 Return Valve Rotary Actuators PART #shipping 2.9.2 JIB Cap and Pick Up Assembly cont2.9.3 Automatic Top Off Board Assembly ITEMInternational Units 2.9.4ATO Pump AssemblyDomestic Units ITEMCOMPONENT ITEMPART # 108-30412.10RTI 2.10.1 RTI Manifold and Accessories PART # 2.10.1 RTI Manifold and Accessories contITEM COMPONENTMicroswitch, Gold Sealed Valve, ½” Ball 2.10.2RTI Dispose Waste Valve2.10.3 RTI Test Box Cover, DV Safety Switch Cover, DV Safety SwitchConnectors and Tools PART # 2.12FastenersITEM COMPONENTTHIS PAGE INTENTIONALLY LEFT BLANK Tech Support SERVICE HOTLINEFAX Parts 1-800-551-8633

Related manuals

Manual 86 pages 43.72 Kb

Manual 26 pages 13.97 Kb