Southbend STRE-3D owner manual Door Switch Check

Page 29

STRATOSTEAM COUNTERTOP STEAMER

SERVICE

Figure 18

Door Switch Check

Continuity

Side View with Right Side and Top Panels Removed

1.DISCONNECT POWER AT CIRCUIT BREAKER.

2.Remove right side panel.

3.Open and close the steamer’s door while looking to see that the door switch actuator rod actuates the door switch when the rod moves.

4.Disconnect the wiring harness from the switch terminals at the two places shown above (where the test-probe tips are located).

5.Place the test probes on the switch terminals (as shown above).

6.Check for continuity with the door open (there should NOT be continuity).

7.Check for continuity when the door is closed (there should be continuity).

8.If the continuity checks are not correct, replace the door switch.

9.Reconnect connector the wiring harness to the switch terminals.

OWNER’S MANUAL 1185184

PAGE 29 OF 48

Image 29

Contents StratoSteam Safety Precautions Location of Serial Plates IntroductionClearances SpecificationsDimensions Right Side View DimensionsDrain Requirements Electrical RequirementsWater Requirements Operation Troubleshooting by OperatorStartup OperationCooking Tips ControlsSuggested Cooking Times Daily Cleaning and Maintenance Cleaning & MaintenancePeriodic DE-LIMING AS Needed STAINLESS-STEEL SurfacesStratosteam Countertop Steamer Cleaning & Maintenance Unpacking InstallationAttach Legs Attach LegsAttach to Countertop Installation on CountertopMounting on Cabinet Base Stacking TWO SteamersDrain Connection Location of Connections and VentsWater Connection Water DrainWater Connection Electrical Connection Electrical ConnectionCheck Steamer Operation Check the InstallationSHUT-DOWN and WIPE-CLEAN Steamer Troubleshooting FLOWCHARTS, PROCEDURES, and Wiring Diagrams ServiceHOW the Steamer Operates How the Steamer Operates Disconnect Power AT Circuit Breaker Steamer Not Heating Up, Power Light Is Not LitCheck that water-supply pressure is adequate Buzzer Does Not Come On When Timer Runs Out Heating Cartridge Check at Contactor Disconnect Power AT Circuit BreakerPower Switch Check Contactor Check Timer and Buzzer Check Door Switch Check High-Limit Thermostats Check Water-Level-Control Sensor Check Water Solenoid Check Wiring Diagram for 208/220/240 Volt Models Wiring Diagram for 480 Volt Models Parts Parts DiagramStructural Parts See parts list on previous Door Assembly Parts Door Switch Parts Control Panel Parts Heating Cartridges, Thermostats, and Contactor Parts Water Train Parts Water-Train Parts Cabinet Base Parts Cabinet-Base Parts Stratosteam Countertop Steamer Stratosteam Countertop Steamer StratoSteam Countertop Steamer Models STRE-3D and STRE-5D