Southbend STRE-3D owner manual Door Assembly Parts

Page 38

SERVICE

STRATOSTEAM COUNTERTOP STEAMER

Figure 25

Door Assembly Parts

2

1

13

3

4

5

6

7

8

	10	9
	10
11
		15	16	18	19
12		15			19
12		14		17
				17

Note: The entire door, assembled, can be ordered (see page 36).

Key	Part Number	Qty	Description
1	1177317	1	LATCH ASSEMBLY
2	1177344	4	SCREW, #10-24X3/4 SLOTTED HEX
3	1146527	6	WASHER #10 LOCK, SS, 300
4	1146526	4	WASHER, #10, FLAT
5	1185053	1	PANEL W/A, R2 STACKABLE
6	1185028	2	HINGE PLATE W/A
7	1185115	1	GASKET, DOOR R2 REDESIGN
8	1146268	2	BOLT, 1/4-20X5/8 HEX HEAD, SS
9	6600412	2	LOCK WASHER, SS
10	1177086	1	RETAINER
11	1185048	1	TRAY, DOOR CNDSATION
12	1146390	4	SCREW, 10-24X1/2, SS, TRUSS SLOT
13	PH-292	2	NYLON WASHER, 1/4 X 1/2 X 1/8
14	1185029	1	INSULATION, DOOR
15	1185023	1	SUPPORT W/A , DOOR GASKET
16	1173254	8	SCREW, 6-32X3/4, SELF TAP
17	1185118	1	RETAINER, DOOR GASKET
18	1180460	4	WASHER, FLAT #10
19	1173224	4	SCREW, 1/2-20 X 5/8 S, SLOT TRS

PAGE 38 OF 48

OWNER’S MANUAL 1185184

Image 38

Contents StratoSteam Safety Precautions Introduction Location of Serial PlatesClearances SpecificationsDimensions Dimensions Right Side ViewDrain Requirements Electrical RequirementsWater Requirements Startup Troubleshooting by OperatorOperation OperationControls Cooking TipsSuggested Cooking Times Periodic DE-LIMING AS Needed Cleaning & MaintenanceDaily Cleaning and Maintenance STAINLESS-STEEL SurfacesStratosteam Countertop Steamer Cleaning & Maintenance Installation UnpackingAttach Legs Attach LegsMounting on Cabinet Base Installation on CountertopAttach to Countertop Stacking TWO SteamersLocation of Connections and Vents Drain ConnectionWater Connection Water DrainWater Connection Electrical Connection Electrical ConnectionCheck Steamer Operation Check the InstallationSHUT-DOWN and WIPE-CLEAN Steamer Service Troubleshooting FLOWCHARTS, PROCEDURES, and Wiring DiagramsHOW the Steamer Operates How the Steamer Operates Steamer Not Heating Up, Power Light Is Not Lit Disconnect Power AT Circuit BreakerCheck that water-supply pressure is adequate Buzzer Does Not Come On When Timer Runs Out Disconnect Power AT Circuit Breaker Heating Cartridge Check at ContactorPower Switch Check Contactor Check Timer and Buzzer Check Door Switch Check High-Limit Thermostats Check Water-Level-Control Sensor Check Water Solenoid Check Wiring Diagram for 208/220/240 Volt Models Wiring Diagram for 480 Volt Models Parts Diagram PartsStructural Parts See parts list on previous Door Assembly Parts Door Switch Parts Control Panel Parts Heating Cartridges, Thermostats, and Contactor Parts Water Train Parts Water-Train Parts Cabinet Base Parts Cabinet-Base Parts Stratosteam Countertop Steamer Stratosteam Countertop Steamer StratoSteam Countertop Steamer Models STRE-3D and STRE-5D