Southbend STRE-3D owner manual Wiring Diagram for 480 Volt Models

Page 34

SERVICE

STRATOSTEAM COUNTERTOP STEAMER

Figure 23

Wiring Diagram for 480 Volt Models

WARNING

THIS UNIT REQUIRES A KIT TO BE FIELD CONVERTED FROM THREE-PHASE TO SINGLE-PHASE OR VICE- VERSA. CONSULT FACTORY FOR PHASE CHANGES.

B 11

NOTE:

a. ALL STRE-3D ELEMENTS ARE 1500 W EACH b. ALL STRE-5D ELEMENTS ARE 1834 W EACH

	L1	L2	L3
			CONTACTOR
B 31	LT		RT	61 B
	LT		RT

3PHASE CENTER

FUSE		FUSE
	TRANSFORMER
30	60	51 B
B	240V
B	B

C

POWER MICROSWITCH

POWER MICROSWITCH

C

NO

1

NO

GY

115

6

COM NC

TIMER

SWITCH

		"POWER" LIGHT			BUZZER
		GY	GY/B
1		114	656			6
DOOR SWITCH		THERMOSTAT
	NO	(NC)
1	NO
1
COM	NC
	NC
				R	GY/B
			5	559	658	6
		R	R		HEATER T'STATS
					HEATER T'STATS
		16	555
		CONTACTOR COIL

WATER SOL COIL

KEY

PAGE 34 OF 48

OWNER’S MANUAL 1185184

Image 34

Contents StratoSteam Safety Precautions Introduction Location of Serial PlatesDimensions SpecificationsClearances Dimensions Right Side ViewWater Requirements Electrical RequirementsDrain Requirements Startup Troubleshooting by OperatorOperation OperationControls Cooking TipsSuggested Cooking Times Periodic DE-LIMING AS Needed Cleaning & MaintenanceDaily Cleaning and Maintenance STAINLESS-STEEL SurfacesStratosteam Countertop Steamer Cleaning & Maintenance Installation UnpackingAttach Legs Attach LegsMounting on Cabinet Base Installation on CountertopAttach to Countertop Stacking TWO SteamersLocation of Connections and Vents Drain ConnectionWater Connection Water DrainWater Connection Electrical Connection Electrical ConnectionSHUT-DOWN and WIPE-CLEAN Steamer Check the InstallationCheck Steamer Operation Service Troubleshooting FLOWCHARTS, PROCEDURES, and Wiring DiagramsHOW the Steamer Operates How the Steamer Operates Steamer Not Heating Up, Power Light Is Not Lit Disconnect Power AT Circuit BreakerCheck that water-supply pressure is adequate Buzzer Does Not Come On When Timer Runs Out Disconnect Power AT Circuit Breaker Heating Cartridge Check at ContactorPower Switch Check Contactor Check Timer and Buzzer Check Door Switch Check High-Limit Thermostats Check Water-Level-Control Sensor Check Water Solenoid Check Wiring Diagram for 208/220/240 Volt Models Wiring Diagram for 480 Volt Models Parts Diagram PartsStructural Parts See parts list on previous Door Assembly Parts Door Switch Parts Control Panel Parts Heating Cartridges, Thermostats, and Contactor Parts Water Train Parts Water-Train Parts Cabinet Base Parts Cabinet-Base Parts Stratosteam Countertop Steamer Stratosteam Countertop Steamer StratoSteam Countertop Steamer Models STRE-3D and STRE-5D