Southbend STRE-3D owner manual High-Limit Thermostats Check

Page 30

SERVICE	STRATOSTEAM COUNTERTOP STEAMER
Figure 19
High-Limit Thermostats Check
	Continuity

1.Allow cavity bottom to cool before performing this test.

2.DISCONNECT POWER AT CIRCUIT BREAKER.

3.Remove left side panel.

4.Disconnect wire B4 from left (as shown above) high-limit thermostat.

5.Disconnect wire B5 from right high-limit thermostat.

6.Disconnect remaining high-limit thermostat wires B11 and B12.

7.Test each high-limit thermostat for continuity (as shown above). There should be continuity when the thermostat is cool. Replace as necessary.

8.Reconnect wires.

PAGE 30 OF 48

OWNER’S MANUAL 1185184

Image 30

Contents StratoSteam Safety Precautions Introduction Location of Serial PlatesSpecifications DimensionsClearances Dimensions Right Side ViewElectrical Requirements Water RequirementsDrain Requirements Startup Troubleshooting by OperatorOperation OperationControls Cooking TipsSuggested Cooking Times Periodic DE-LIMING AS Needed Cleaning & MaintenanceDaily Cleaning and Maintenance STAINLESS-STEEL SurfacesStratosteam Countertop Steamer Cleaning & Maintenance Installation UnpackingAttach Legs Attach LegsMounting on Cabinet Base Installation on CountertopAttach to Countertop Stacking TWO SteamersLocation of Connections and Vents Drain ConnectionWater Drain Water ConnectionWater Connection Electrical Connection Electrical ConnectionCheck the Installation SHUT-DOWN and WIPE-CLEAN SteamerCheck Steamer Operation Service Troubleshooting FLOWCHARTS, PROCEDURES, and Wiring DiagramsHOW the Steamer Operates How the Steamer Operates Steamer Not Heating Up, Power Light Is Not Lit Disconnect Power AT Circuit BreakerCheck that water-supply pressure is adequate Buzzer Does Not Come On When Timer Runs Out Disconnect Power AT Circuit Breaker Heating Cartridge Check at ContactorPower Switch Check Contactor Check Timer and Buzzer Check Door Switch Check High-Limit Thermostats Check Water-Level-Control Sensor Check Water Solenoid Check Wiring Diagram for 208/220/240 Volt Models Wiring Diagram for 480 Volt Models Parts Diagram PartsStructural Parts See parts list on previous Door Assembly Parts Door Switch Parts Control Panel Parts Heating Cartridges, Thermostats, and Contactor Parts Water Train Parts Water-Train Parts Cabinet Base Parts Cabinet-Base Parts Stratosteam Countertop Steamer Stratosteam Countertop Steamer StratoSteam Countertop Steamer Models STRE-3D and STRE-5D