Southbend STRE-3D owner manual Control Panel Parts

Page 40

SERVICE

STRATOSTEAM COUNTERTOP STEAMER

Figure 27

Control Panel Parts

1817

3

16

13

2

10

1

14 15

12

11

9

8

4

19 20

5

			7
			6
Key	Part Number	Qty	Description
1-17	1185039	1	CONTROL PANEL ASSEMBLY (assembled)
1	1170337	1	KNOB
2	1185058	1	POLYPANEL, CONTROL
3	1185038	1	PANEL, CONTROL W/A
4	1185205	1	GUAGE, THERMOMETER 2 IN
5	1170350	1	LIGHT, AMBER 240V SIGNAL
6	1178388	1	VALVE LEVER W/A
7	1177770	1	BUSHING, VALVE LEVER MOUNT
8	1177865	1	NUT, HEX, 5/8-18, BRASS
9	1178276	1	CAM ACTUATOR
10	1178549	1	SCREW, SET
11	1185056	1	BRACKET, ON/OFF SWITCH
12	1183429	2	INSERT, KNURLED
13	6600430	2	LOCKNUT
14	1178535	1	SWITCH, POWER
15	1146320	2	SCREW, 6-32X1 ROUND HD
16	1175712	1	BUZZER ASSEMBLY
17	1178341	1	TIMER, MECHANICAL
18	1185080	1	GASKET, CONTROL PANEL
19	1185031	1	VALVE ACTUATION ROD
20	1178393	1	1/8 X 1 1/4 18-8 COTTER PIN
*	1185161	1	WIRING HARNESS
*	Not shown on drawing.

PAGE 40 OF 48

OWNER’S MANUAL 1185184

Image 40

Contents StratoSteam Safety Precautions Introduction Location of Serial PlatesDimensions SpecificationsClearances Dimensions Right Side ViewWater Requirements Electrical RequirementsDrain Requirements Troubleshooting by Operator OperationStartup OperationControls Cooking TipsSuggested Cooking Times Cleaning & Maintenance Daily Cleaning and MaintenancePeriodic DE-LIMING AS Needed STAINLESS-STEEL SurfacesStratosteam Countertop Steamer Cleaning & Maintenance Installation UnpackingAttach Legs Attach LegsInstallation on Countertop Attach to CountertopMounting on Cabinet Base Stacking TWO SteamersLocation of Connections and Vents Drain ConnectionWater Connection Water DrainWater Connection Electrical Connection Electrical ConnectionSHUT-DOWN and WIPE-CLEAN Steamer Check the InstallationCheck Steamer Operation Service Troubleshooting FLOWCHARTS, PROCEDURES, and Wiring DiagramsHOW the Steamer Operates How the Steamer Operates Steamer Not Heating Up, Power Light Is Not Lit Disconnect Power AT Circuit BreakerCheck that water-supply pressure is adequate Buzzer Does Not Come On When Timer Runs Out Disconnect Power AT Circuit Breaker Heating Cartridge Check at ContactorPower Switch Check Contactor Check Timer and Buzzer Check Door Switch Check High-Limit Thermostats Check Water-Level-Control Sensor Check Water Solenoid Check Wiring Diagram for 208/220/240 Volt Models Wiring Diagram for 480 Volt Models Parts Diagram PartsStructural Parts See parts list on previous Door Assembly Parts Door Switch Parts Control Panel Parts Heating Cartridges, Thermostats, and Contactor Parts Water Train Parts Water-Train Parts Cabinet Base Parts Cabinet-Base Parts Stratosteam Countertop Steamer Stratosteam Countertop Steamer StratoSteam Countertop Steamer Models STRE-3D and STRE-5D