Safety Alert Key:
•DANGER! Indicates a hazardous situation which, if not avoided will result in death or serious injury.
•WARNING! Indicates a hazardous situation which, if not avoided could result in death or serious injury.
•CAUTION! Indicates a hazardous situation which, if not avoided, could result in minor or moderate injury.
•NOTICE: Used to address practices not related to personal injury.
Table of Contents
A. Congratulations . . . . . . . . . . . . . . . . . 3 B. SANS Compliance . . . . . . . . . . . . . . . . 4 C. Limited Lifetime Warranty. . . . . . . . . . . . . . 7
1 Listing and Code Approvals
A. Appliance Certification. . . . . . . . . . . . . . 10 B. Gas Pressure Requirements . . . . . . . . . . . . 10 C. High Altitude Installations. . . . . . . . . . . . . 10
D.
E.Combustible Materials Specification . . . . . . . . . 10
F.Electrical Codes. . . . . . . . . . . . . . . . . 10
User Guide
2 Operating Instructions
A. | Gas Fireplace Safety | . 11 |
B. | Your Fireplace | 11 |
C. | Fan Kit | 12 |
D. | Clear Space | 12 |
E. | Decorative Doors and Fronts | . 12 |
F. | Fixed Glass Assembly | 12 |
G. Remote Controls, Wall Controls and Wall Switches. . . 12 | ||
H. Before Lighting Fireplace | 12 | |
I. | Lighting Instructions (IPI) | 13 |
J. | Control Module Operation | . 14 |
K. | After Fireplace is Lit | 15 |
L. | Frequently Asked Questions | . 15 |
3 Maintenance and Service
A. Maintenance
B. Maintenance
Installer Guide
4 Getting Started
A.Typical Appliance System. . . . . . . . . . . . . . . . . . . . . . . . . 18
B.Design and Installation Considerations . . . . . . . . 19
C.Tools and Supplies Needed. . . . . . . . . . . . 19
D.Inspect Appliance and Components. . . . . . . . . 19
5 Framing and Clearances
A. Selecting Appliance Location. . . . . . . . . . . . 20 B. Constructing the Appliance Chase. . . . . . . . . . 21 C. Clearances. . . . . . . . . . . . . . . . . . . 21 D. Mantel and Wall Projections. . . . . . . . . . . . 23
6 Termination Locations
A. Vent Termination Minimum Clearances. . . . . . . . 24
7 Vent Information and Diagrams
A. Approved Pipe. . . . . . . . . . . . . . . . . 26 B. Vent Table Key. . . . . . . . . . . . . . . . . 26 C. Use of Elbows . . . . . . . . . . . . . . . . . 26 D. Measuring Standards. . . . . . . . . . . . . . . 26 E. Vent Diagrams. . . . . . . . . . . . . . . . . 26
8 Vent Clearances and Framing
A. Pipe Clearances to Combustibles . . . . . . . . . . 38 B. Wall Penetration Framing. . . . . . . . . . . . . 38 C. Install the Ceiling Firestop . . . . . . . . . . . . . 39 D. Install Attic Insulation Shield. . . . . . . . . . . . 40 E. Installing the Optional
•Remove the knockout from the fireplace and discard it (see
Figure 8.6).. . . . . . . . . . . . . . . . . . . 40
9 Appliance Preparation
A. | Top Vent | . 41 |
B. | Rear Vent | 42 |
C.Installing the
D.Securing and Leveling the Appliance. . . . . . . . . 43
E.Covers Removal For Servicing. . . . . . . . . . . . . . . . . . . . . 44
F.Components Removal For Service . . . . . . . . . 44
G.Parts Replacement . . . . . . . . . . . . . . . 44
H.Adjustments And Replacement Parts. . . . . . . . . 44
I.Install Trim and/or Surround. . . . . . . . . . . . 44
J.Air Shutter Setting . . . . . . . . . . . . . . . . 44
10 Installing Vent Pipe (DVP and SLP Pipe)
A. Assemble Vent Sections (DVP Pipe Only). . . . . . . 45 B. Assemble Vent Sections (SLP Pipe Only). . . . . . . 46 C. Assemble Slip Sections. . . . . . . . . . . . . . 46 D. Secure the Vent Sections. . . . . . . . . . . . . 47 E. Disassemble Vent Sections. . . . . . . . . . . . 47 F. Install Support Brackets. . . . . . . . . . . . . . 48 G. Install Firestops . . . . . . . . . . . . . . . . . 48 H. Flue Termination. . . . . . . . . . . . . . . . . 49
I.Heat Shield Requirements for Horizontal Termination. . 50
J.Install Metal Roof Flashing. . . . . . . . . . . . . 50
K.Assemble and Install Storm Collar. . . . . . . . . . 51
L.Install Vertical Termination Cap . . . . . . . . . . . 51
11 Gas Information
A. Gas Pressure Requirements . . . . . . . . . . . . 52 B. Gas Connection. . . . . . . . . . . . . . . . . 52
12 Electrical Information
A. Wiring Requirements. . . . . . . . . . . . . . . 54
Heat & Glo • | 5 |
