Manuals / Quadra-Fire / Household Appliance / Indoor Fireplace

Quadra-Fire CASTILEI-MBK 5Venting Systems, A. Full Reline With Horizontal Outside Air, Figure

Models: CASTILEI-MBK

1 56

Download 56 pages 60.57 Kb

Page 15

5Venting Systems

R

Castile Pellet Insert

5Venting Systems

A. Full Reline With Horizontal Outside Air

CAUTION

Never draw outside combustion air from:

•Wall, ﬂ oor or ceiling cavity

•Enclosed space such as an attic or garage

WARNING

Fire Risk.

Inspection of Chimney:

•Masonry chimney must be in good condition.

•Meets minimum standard of NFPA 211

•Factory-built chimney must be a minimum 6 inch (152mm) UL103 HT.

NOTE; Use metal plate around exhaust vent pipe and seal all edges with non-flammable insu- lation such as , mineral wool or ceramic.

Do not use high temperature caulking materials to seal any edge to prevent future service- ability.

Outside Air through Rear

Wall (Horizontal)

Figure 15.1

NOTE:

In Canada, where passage through a wall or partition of combustible construction is desired, the installation shall conform to CAN/CSA-B365.

NOTE:

•Illustrations reﬂ ect typical installations and are FOR DESIGN PURPOSES ONLY.

•Illustrations/diagrams are not drawn to scale.

•Actual installation may vary due to individual design preference.

January 19, 2011

7022-122

Page 15

Image 15

Quadra-Fire CASTILEI-MBK 5Venting Systems, A. Full Reline With Horizontal Outside Air, Castile Pellet Insert, Figure

Contents

CASTILEI-CWL Installation and OperationNOTICE CASTILEI-MBK CASTILEI-PMH CASTILEI-CSBCastile Pellet Insert SAFETY LABEL / ÉTIQUETTE DE SÉCURITÉand Welcome to the Quadra-FireFamily Castile Pellet Insert Safety Alert Key TABLE OF CONTENTSB. Mobile Home Approved 1 Listing and Code ApprovalsA. Appliance Certiﬁcation E. BTU & Efﬁciency Speciﬁcations•Frequently open doors Getting StartedCastile Pellet Insert 1.Appliance LocationCastile Pellet Insert B. Locating Your Appliance & ChimneyC. Draft D. Negative PressureOutside Air E. Avoiding Smoke and OdorsCastile Pellet Insert Vent ConﬁgurationsPre-BurnCheck List F. Fire SafetyH. Inspect Appliance & Components G. Tools And Supplies Needed3Dimensions and Clearances A. Appliance DimensionsCastile Pellet Insert Shown with Rear Vent and Outside Air Must be installed in a non-taperedenclosureINSTALLED AS A BUILT-INUNIT B. Clearance To Combustibles, UL and ULCFigure C. Masonry and Factory-BuiltFireplacesCastile Pellet Insert E. Floor Protection F. Prefabricated Metal ChimneyG. Removing Metal Floor of Factory-BuiltFireplace H.Altering the Factory-BuiltFireplaceCastile Pellet Insert B. Venting Termination Requirements Vent Information4Castile Pellet Insert A. Chimney and Exhaust ConnectionHorizontalHori tal Run,RunftFT Figure C. Pellet Venting ChartsCastile Pellet Insert Minimum Vent for One ElbowFigure 5Venting SystemsA. Full Reline With Horizontal Outside Air Castile Pellet InsertCastile Pellet Insert C. Full Reline With Vertical Outside AirFigure A. Mobile Home Installation6Mobile Home Castile Pellet InsertLeveling Bolt on each Side 7Appliance Set-UpB. Outside Air Kit Instructions A. Leveling SystemCastile Pellet Insert E. Adjustable Hearth SupportC. Door Handle Removal D. Door RemovalFigure 20.1 - Assembled View F. Hearth Support For Standard Surround OnlyCastile Pellet Insert Turn right side up and attach top cast ringCastile Pellet Insert Base Plate Only InstallationF. Hearth Support Cont’d G. Surround & Trim Set, Econopiece. Figure. G. Surround & Trim Set, Econo Cont’dH. Surround and Cast Trim Set Castile Pellet InsertFigure I. Optional Log Set Placement InstructionsH. Surround and Cast Trim Set Cont’d Castile Pellet InsertCastile Pellet Insert J. Thermostat InstallationCastile Pellet Insert 8 Operating InstructionsA. Combustible/Non-CombustibleMaterials B.Fuel Material and Fuel StorageCastile Pellet Insert C. General Operating InformationD.Before Your First Fire E. Clear SpaceCastile Pellet Insert G. Fire CharacteristicsH. Feed Rate Adjustment Instructions F. Starting Your First FireI. Ignition Cycles J. Frequently Asked QuestionsISSUES SOLUTIONSPossible Cause Exhaust blower must be offUnplug appliance before servicing Castile Pellet InsertCastile Pellet Insert SymptomPossible Cause Corrective ActionCorrective Action SymptomCastile Pellet Insert Possible CauseB. Quick Reference Maintenance Chart Proper Shutdown ProcedureC. General Maintenance section for each step listed in the chart below3.Ash Removal from Firebox 4.Cleaning Ash DrawerCastile Pellet Insert See Figure 28.1 on pageCastile Pellet Insert 6.Cleaning Heat Exchanger Tubes7.Cleaning Beneath Heat Exchanger 8.Cleaning the Glass•Task: Contact your local dealer 10.Cleaning the HopperCastile Pellet Insert 14.Preparing Firebox for Non-BurnSeasonFirepot Overfills D. High Ash Fuel MaintenanceIMMEDIATE ATTENTION AND CLEANING IS REQUIRED Castile Pellet InsertFigure E. Combustion Blower ReplacementF.Convection Blower Replacement Castile Pellet InsertFigure G. Igniter ReplacementH. Glass Replacement Castile Pellet InsertFigure Re-installingBafﬂe & Brick SetI. Bafﬂe & Brick Set Removal Castile Pellet InsertFigure Re-installingBafﬂe & Brick Set Cont’dCastile Pellet Insert FigureWhen describing the location of a component Reference MaterialsComponent Function A.1116.Thermostat 20.Vacuum Switch21.Wiring SchematicSee Figure 42.1 below Castile Pellet InsertFigure RIGHT SIDEB. Component Locations Castile Pellet InsertCastile Pellet Insert R Service PartsCastile Insert Part number list on following pagesITEM at DepotR Service Parts Castile Insert#28 Feed Assembly Stocked at DepotR Service Parts #23 Door Assemblyat Depot StockedR Service Parts Castile Insertat Depot R Service PartsOPTIONAL ACCESSORIES Castile Insertat Depot R Service PartsCastile Insert StockedITEM R Service PartsCastile Insert at DepotCastile Pellet Insert E. Service And Maintenance LogDate of Service Description of ServiceCastile Pellet Insert E. Service And Maintenance Log Cont’dDate of Service Description of ServiceCastile Pellet Insert F. Homeowner’s NotesCastile Pellet Insert WARRANTY COVERAGEWARRANTY PERIOD LIMITED LIFETIME WARRANTYLIMITATIONS OF LIABILITY WARRANTY CONDITIONSWARRANTY EXCLUSIONS This warranty is void ifNOTICE CONTACT INFORMATION