Model 465M Ozone Monitor | Teledyne instruction

INSTRUCTION MANUAL

MODEL 465M

OZONE MONITOR

TELEDYNE ADVANCED POLLUTION INSTRUMENTATION (TELEDYNE API)

9480 Carroll Park Drive

San Diego, CA 92121-5201

TOLL-FREE: 800-324-5190

TEL: 858-657-9800

FAX: 858-657-9816

EMAIL: api-sales@teledyne.com

WEB SITE: http://www.teledyne-api.com/

Copyright 2007-2012	06160D DCN 6409
Teledyne Advanced Pollution Instrumentation	23 MARCH 2012

Image 1

Teledyne instruction manual Model 465M Ozone Monitor

Contents

Model 465M Ozone Monitor This page is Intentionally Left Blank General Safety Hazard Safety Messages Mise EN Garde Consignes DE Sécurité Warranty This page is Intentionally Left Blank Table of Contents Calibration Figures Tables Preface Introduction This page is Intentionally Left Blank Specifications Specifications and Agency Approvals Approvals SafetyEMC Other Type Certifications 3   Principle of OperationPage Getting Started Mechanical Installation for Nema 4X EnclosureVentilation Clearance Area Minimum required clearance M465M Mounting Hole Locations and Dimensions Mechanical Installation 19 Rack Version AC Power Connection for Monitors in Nema 4X Enclosures Nema AC Power Connection to Monitor Pneumatic Connections Pneumatic Connections, Rack Mount Configuration Ozone Inlet Connection Pneumatic Connections, Nema Configuration Rear Panel Electrical I/O Connections Exhaust Connection Nema Electrical I/O Connections Electrical I/O Connections Location of I/O Connectors in the Nema ConfigurationAnalog Output Status Name Normal Operating Output # State Status Outputs Digital Serial Interfaces Hi-Current Relay OutputsRelay # Function Normal Operating State Ethernet Connection Frequently Asked Questions This page is Intentionally Left Blank Optional Hardware and Software Low Flow AlarmRack Mount Slides This page is Intentionally Left Blank Front Panel Overview OperationOzone Concentration Display Menu Navigation Keypad Alarm Status LED Color Alarm State Concentration Alarm Status/ResetStatus LED’s Status LED Normal State Menu Navigation Basics Front Panel MenusEditing Numeric Values Front Panel Menu Diagram Front Panel Menu Diagram Point 5V Output MA Output Diag Menu Zero Calibration Signal Name Rear Panel Label Function Span Calibration Parameter Meaning Units Normal Range View Menu Meaning Default Value SETUP-VARS MenuRange Config Menu SETUP-ALARM MenuProperty Meaning Default Range Value This page is Intentionally Left Blank Digital Communications Changing COM port Hardware ConfigurationDigital Communications Overview RS232 Configuration Function DB-9 General I/O Connector Pin SW2 DTE SW2 DCE RS-232 ConfigurationProperty Value Function DB-9 General I/O Connector Pin SW2 DCE RS-485 Configuration Hardware Setup for Configuring the Ethernet Module Ethernet ConfigurationVerifying Network Hardware Connection Link LED Left Side Activity LED Right Side Color Meaning Manually Assigning a Static IP Address Determining a Dynamically Assigned IP Address Dhcp ModePage Modbus Register Maps Instrument Setup and Configuration Registers Read / WriteReal-Time Concentration and Status Registers Read Only Decimal Star Address Description Register Type Bit Bits Maintenance Schedule MaintenanceMaintenance Item Recommended Interval Section Instrument Layout Instrument Layout, Rack Mount Configuration Instrument Layout, Nema Configuration Replacing Internal Particulate Filter Internal Particulate Filter Replacement UV Lamp Replacement UV Lamp Adjustment1150 mV Auto-Zero Valve Replacement Sample Pump Replacement Configuring the Analog Output Zero Cleaning Exterior Surfaces of the M465M Boot Loader Hardware Setup Boot Loader OperationBoot Loader Software Setup Upload Firmware Page Pneumatic Diagram TroubleshootingReference Drawings Pneumatic Diagram Nema Version with Sample Conditioner Interconnect Diagram Interconnect Diagram Status LED/Output Definitions Sensor OK Pneumatic ErrorInvalid Reading Check Lamp Pressure Too High Factory Calibration Calibration This page is Intentionally Left Blank Technical Assistance This page is Intentionally Left Blank 13. M465M Spare Parts Spare Parts List for Rack Mount Version Spare Parts List for Nema Version