Handle, Latch Assembly | Vulcan-Hart MHB24G, VHX24G5 specification

VHX SERIES STEAMERS - REMOVAL AND REPLACEMENT OF PARTS

Handle

1.Open the door.

2.Remove screws from the top and bottom of the door.

3.Pull the inner door panel out from the door housing with the gasket plate and gasket still attached.

NOTE: When installing the spacers, the smaller diameter fits into the slot in the door and the latch lever must rest on top of the handle latch screw.

5.Reverse procedure to install.

Latch Assembly

1.Open the door.

2.Remove screws from the top and bottom of the door.

3.Pull the inner door panel out from the door housing with the gasket plate and gasket still attached.

4.Remove the screws from the side edge of the door that secure the latch mechanism and remove the latch from the door.

NOTE: When installing, the latch lever must rest on top of the handle latch screw.

5. Reverse procedure to install.

4.Remove the nuts and spacers from the handle screws and remove the handle from the door.

F24700 (October 2001)		Page 22 of 68

Image 22

Vulcan-Hart MHB24G, VHX24G5 manual Handle, Latch Assembly

Contents

VHX Boiler Base Series High Efficiency GAS Steamers VHX24G Shown Table of Contents VHX Series Steamers Maintenance Cleaning Introduction InstallationGeneral Boiler Control Styles Water Supply Water Conditioning SpecificationsSystem Electrical Standard ToolsGas Supply Special Cooking Compartment Controls Steamer OperationCabinet Base Boiler VHX Series Steamers Operation Boiler Blowdown Steamer Shut OFF Blowdown/Drain Component FunctionVHX Series Steamers Component Function Ignition Control Module Water Inlet Valve manual Steam Header AssemblyWater Level Pressure Relief Valve Manifold Pressure Gauge Compartment Pressure SwitchSteam Solenoid Valve Steam Supply Manifold Component Locations Removal and Replacement of PartsVHX Series Steamers Removal and Replacement of Parts Cabinet Base Boiler Controls Cabinet Base Boiler Controls Relay Board Water Level Controls Main or Auxiliary LlcoCooking Compartment Controls Pressure Switches Water Level Gauge AssemblyBoiler Assembly Pilot GAS Valve Main GAS Valve Boiler Fill and Cold Water Condenser Solenoid Valves Burner Head Assembly Complete Burner Assembly Heat Exchanger VHX Series Steamers Removal and Replacement of Parts Removal Cooking Compartment DoorsGasket Latch Assembly Handle Boiler Service Procedures and AdjustmentsClean-Out Inspection Water Level Probe Housing Blowdown Descaler Cathodic Protector Water Level Controls Test Auxiliary Low level Cut-Off Control High Limit Cycling Fill and Cold Water Solenoid Valves Small increments Inline Water Strainer Cleaning Boiler BLOWDOWN/DRAIN Solenoid Valve Pressure Switch Adjustment Main Burner Ignition Checks GAS Manifold Pressure Adjustment VHX Series Steamer Service Procedures and Adjustments AIR Pressure Switch Adjustment GAS Pilot Pressure Adjustment Pressure Readings Inches W.C GAS Manifold Pressure Adjustment Ignition Control Module Checks Terminals Spark Verification Test Cooking Compartment Intake Shut-Off Valve Adjustment Steam FlowDoor Sealing Adjustment Cooking Compartment Doors Door Latch Adjustment VHX Series Steamer Electrical Operation Electrical Operation Low Level Cut-Off & Differential Control Auxiliary Low Level Cut-Off Board Layout and LED Legend LED Legend Initial Conditions State a Boiler Operational Status LED IndicatorReset Engaged State C Aux Water Level Satisfied State B K51 Close Air Pressure Switch Satisfied State DK32 Close Burner ON, Boiler Heating to generate steam State E Initial Fill and Preheat Sequence of OperationNEW Style Controls Boiler HL-LED N9, N10, N11, N12, N13 go out N14, N16, N17 go out Water Refill After Initial Fill Boiler Blowdown/drain VHX Series Steamer Electrical Operation Cooking Compartment Controls This page Intentionally Left Blank Schematics Models Built After 5/25/00 New Style Boiler Controls VHX Series Steamer Electrical Operation Models Built Before 5/25/00 Old Style Boiler Controls Cooking Compartment Controls Wiring Diagrams VHX Series Steamer Electrical Operation Models Built Before 5/25/00 Old Style Boiler Controls VHX Series Steamer Electrical Operation Cooking Compartment Controls VHX Series Steamer Troubleshooting TroubleshootingBoiler Base Controls Symptom Possible Causes Adjustments Boiler blowdown solenoid valve clogged and not fully closing Boiler Base Procedures and Adjustments VHX Series Steamer VHX Series Steamer Condensed Spare Parts List Condensed Spare Parts ListNEW Style Controls only VHX24G, VHX24G5, MHB24G