American Dryer Corp ADG-60 service manual Wr

Page 50

3URJUDP/RFDWLRQKDVH0LFURSURF3DUDPHWHUVVRU&RQWUROOHU3URJUDPPLQJ5DQJH /LPLWV,QFUHPHQWV

	3/	3GU<$XWR&\FOHSHUFHQWDJHRIGU\QHVV	WR

	3/	+,’U\LQJ7HPSHUDWXUH	WR)
	3/	+,’U\LQJ7HPSHUDWXUH	WR&
			WR&

		+,&RRO’RZQ7HPSHUDWXUH	WR)
	3/	+,&RRO’RZQ7HPSHUDWXUH	WR&
	3/	+,&RRO’RZQ7LPH	WR&
		+,&RRO’RZQ7LPH	WR	PLQXWH
			WR	PLQXWH
	3/	/2’U\LQJ7HPSHUDWXUH	WR)
	3/	/2’U\LQJ7HPSHUDWXUH	WR&
			WR&

		/2&RRO’RZQ7HPSHUDWXUH	WR)
	3/	/2&RRO’RZQ7HPSHUDWXUH	WR&
	3/	/2&RRO’RZQ7LPH	WR&
		/2&RRO’RZQ7LPH	WR	PLQXWH
			WR	PLQXWH
	3/	33’U\LQJ7HPSHUDWXUH	WR)
	3/	33’U\LQJ7HPSHUDWXUH	WR&
			WR&

		33&RRO’RZQ7HPSHUDWXUH	WR)
	3/	33&RRO’RZQ7HPSHUDWXUH	WR&
	3/	33&RRO’RZQ7LPH	WR&
		33&RRO’RZQ7LPH	WR	PLQXWH
			WR	PLQXWH
	3/	/&G(/HIW&RLQ’HQRPLQDWLRQ	WR

	3/	U’G(5LJKW&RLQ’HQRPLQDWLRQ	WR

	3/	W)$67LPHIRU$PRXQWWR6WDUW	WR	PLQXWH

	3/	$W6W$PRXQWWR6WDUW	WR

	3/	$)$W$PRXQWIRU$GGLWLRQDO7LPH	WR

	3/	$GUW0D[LPXP$XWR’U\7LPH	WR	PLQXWH

	3/	G/<$QWL:ULQNOHXDUG’HOD\7LPH	WR	PLQXWH
	3/	RQW$QWL:ULQNOHXDUG2Q7LPH	WR	VHFRQG
		RQW$QWL:ULQNOHXDUG2Q7LPH	WR	VHFRQG

	3/	$W$QWL:ULQNOHXDUG$FWLYH7LPH	WR	PLQXWH

	3/	$$XWR&\FOH)DFWRU	WR
	3/	%$XWR&\FOH)DFWRU	WR
		%$XWR&\FOH)DFWRU	WR

46

Image 50

Contents VAC Phase Retain This Manual In a Safe Place For Future Reference For Your Safety Page Table of Contents Electrical Troubleshooting Cleaning SectionAdjustments LubricationTo remove control middle or lint lower door To remove gas valve train assemblyTo Remove Lint Drawer To Remove Front Panel To Remove and Replace Lint Drawer Switch AssemblyTo Remove Control Box To Remove and Replace Sensor Bracket and Components To Remove or Replace Belt Loctite To Remove or Replace Motor Reverse steps 1 through Loctite Belt and Idler Tension Adjustment To Remove or Replace Impellor FanFan Belt and Tension Adjustment To Replace Dual Control Microprocessor DMC ComputerTo Replace Touchpad Keypad To Replace Coin AcceptorTo Replace either Motor Relay Basket Tumbler Alignment VerticalBasket Tumbler Alignment Lateral To Replace Basket tumbler or Basket tumbler Support Loctite To Replace Basket tumbler Support Pillow Block Bearing Important Never strike the shaft directly with a hammerPage To Replace Basket Tumbler Support Flange Bearing To Replace 330º F Burner Hi-Limit Switch Thermostat To Replace Direct Spark Ignition DSI Module To Replace Sail SwitchTo Replace Main Door Switch AA. To Replace Ignitor and Probe BB. To Replace Gas ValveDiscontinue power to the dryer DD. To Replace Coin VaultGG. To Replace Main Door Gasket FF. To Install New Main Door GlassEE. To Remove Main Door HH. To Replace Main Door HingeTroubleshooting No L.E.D. DisplayDMC computer L.E.D. display reads dSFL DMC computer L.E.D. display reads Hot DMC computer L.E.D. display reads SeflIf dryer is equipped with optional battery back up Dryer operates, but is taking to long to dry Condensation on main door glassDryer is making scraping noise at basket tumbler area Excessive noise or vibrationElectrical Troubleshooting No Display ConditionNo Start Condition Motor Doesnt Turn No Heat Condition Gas DOOr Condition DSFL Condition Technical Information Data LabelUsing a Manometer HOW to USE a ManometerE.D. Display Codes ClccFill Phase 5 System Diagnostics Diagnostic L.E.D. Display Failure CodesE.D. Display Indicators DOT Phase 5 DMC Computer Relay Output L.E.D. IndicatorsPhase 5 DMC Computer Input and Output L.E.D. Indicators WR ADC450162 1- 10/15/98-50