Generac 004614-1 owner manual 1926

Page 48

Appendix 3 — Exploded Views and Parts Lists

QUIETPACT™ 65D Recreational Vehicle Generator Electrical Enclosure Assembly – Drawing No. 0D5056-A

31

16

17

29

30

11

281

27

18

2

		3
25	26	9
25	26
	27	20

28	33
28
8

25

1926

13

27

28

5

	6	12
	6	7
		7

4 15 11

14

32

ITEM	PART NO.	QTY.	DESCRIPTION		ITEM	PART NO.	QTY.	DESCRIPTION
1	0D2412	1	WELDMENT, ELECTRICAL	19		022985	4	WASHER, FLAT #6
			ENCLOSURE	20		0C6359	1	GASKET, ELECTRICAL ENCLOSURE
2	071914	1	TERMINAL BLOCK 4 POSITION	21		0D2021G*	1	WIRE ASSEMBLY # 32
3	083048	1	ASSEMBLY, POTTED REGULATOR	22		0D2021F*	1	WIRE ASSEMBLY # 22
4	0C7610	1	RESISTOR 20R 5% 12W	23		0D2021D*	1	DIODE ASSEMBLY
5	093642	1	ASSEMBLY MARINE CONTROL BOARD	24		0D2021E*	1	WIRE ASSEMBLY # 162
6	065795	1	RECTIFIER, BATTERY CHARGING	25		0A1658	2	¼ SPECIAL LOCKWASHER
7	048512	1	CIRCUIT BREAKER 5 AMP	26		022473	2	WASHER, FLAT ¼-M6
8	027565	A/R	TAPE, GLASS INSULATED	27		022097	7	WASHER, SPLIT LK ¼-M6
9	066849C	2	TAPTITE, M5-0.8 X 30	28		049813	7	NUT, HEX M6-1
10	066849	1	TAPTITE, M5-0.8 X 16	29		023484D	1	BUSHING, SNAP
11	022264	3	LOCKWASHER M5	30		022717B	2	GROMMET
12	051715	2	NUT, HEX M4-0.7	31		051787	4	HHCS, M4-0.7 X 16MM
13	040213	4	PCB SUPPORT SNAP -IN	32		0C7390	1	GASKET, ELECTRICAL ENCLOSURE
14	0C8620	1	HHMS, #8-32 X 2.25"					DIVIDER
15	043180	1	WASHER, FLAT M5	33		0D5035	1	HARNESS, AC OUTPUT
16	0D2021B	1	HARNESS
17	0C3992	4	M4-0.7 X 16 HHCS TAPTITE		A/R = AS REQUIRED
18	0C7022	1	DECAL, CUSTOMER CONNECTION		* NOT SHOWN REFER TO WIRING DIAGRAM C4946

46 Generac® Power Systems, Inc.

Image 48

Contents Power SYSTEMS, INC Authorized Service Dealer Location IntroductionPart II Installation Instructions General Hazards Electrical Hazards Generator Identification Quietpact 65DSafety SpecificationsGenerator Applicability Generator AC Connection SystemFuel Consumption GAL/HR Engine OIL RequirementsGenerator Generator Control Panel Optional Remote START/STOPBefore Starting the Engine Starting the Generator Stopping the Generator Protection SystemsAdditional Information Overspeed ShutdownOvervoltage Protection 1 25-HOUR BREAK-IN PeriodChecking the Engine OIL Level Changing the Engine OIL AND/OR OIL FilterOperation in High Grass or Brush Effects of Moisture and DirtServicing the Engine AIR Filter Spark Arrestor MufflerCleaning the Generator Battery MaintenanceOUT-OF-SERVICE Procedure Cooling SystemEngine Coolant Drive BeltReturn to Service Service Schedule SYSTEM/COMPONENT Procedure FrequencyPart General Hazards Electrical Hazards Purpose and Scope Manual Standards BookletsEquipment Description Generator Engine Operating SpeedMajor Features and Dimensions Location and Support Generator LocationGenerator Support Suspended MountingGenerator Compartments Generator RestraintCompartment Construction Sound Insulating Materials AcousticsCompartment Floor Cutouts Typical Noise AbatementCooling and Ventilating AIR Cooling AIR Inlet OpeningsGenerator Airflow Testing the Installation Diesel Fuel SystemCompensating for Restrictions Generator Fuel Supply Lines Generator Fuel Return LinesExhaust System Safety Exhaust SystemMuffler and Spark Arrestor Electrical Connections Electrical Junction BOXGenerator AC Connections Power Supply Cord Ground Fault Circuit InterruptersIsolating Different Power Sources Battery Installation Battery CablesRecommended Battery Battery Cable ConnectionsOptional Accessories Battery CompartmentPost Installation Tests Testing Under LoadBefore Initial Startup Initial StartInstallation Checklist Troubleshooting Guide Problem Cause CorrectionAppendix 2 Electrical Data Appendix 2 Electrical Data Appendix 2 Electrical Data Appendix 3 Exploded Views and Parts Lists QTY Description Base Frame Weldment 174 Appendix 3 Exploded Views and Parts Lists Cooling System Drawing No. D2360 1926 Exhaust Gasket Description QTY Start / Stop Switch Camshaft Assembly Complete Cylinder Block Cylinder Head Assembly Crankshaft Assembly Part NO. QTY Description Rocker ARM Shaft Injector Pump Assembly Fuel Filter Support Appendix 3 Exploded Views and Parts Lists HOUSING, Timing Gear 3114 Water Pump Assembly Appendix 4 Notes Appendix 4 Notes Federal and California Emissions Control Warranty Statement Your Warranty Rights and ObligationsManufacturers Warranty Coverage Parts CoveredObtaining Warranty Service Obligations and Rights of the Manufacturer and OwnerLimitations Generac Power SYSTEMS, INC