Generac 004614-1 Federal and California Emissions Control Warranty Statement, Parts Covered

Page 66

Appendix 5 – Warranty

QUIETPACT™ 65D Recreational Vehicle Generator

FEDERAL AND CALIFORNIA EMISSIONS CONTROL WARRANTY STATEMENT

(for non-road Diesel engines rated under 19 kW)

YOUR WARRANTY RIGHTS AND OBLIGATIONS

The U.S. Environmental Protection Agency (EPA), the California Air Resources Board (CARB), Generac Power Systems, Inc. (GENERAC), and the engine manufacturer for this equipment, Ishikawajima Shibaura Machinery Co., Ltd. (ISM), are pleased to explain the federal and California emission control system warranty on your engine.

In California, new 2000 and later small non-road engines must be designed, built, and equipped to meet the state's strin- gent anti-smog standards. In other states, new 2000 and later non-road diesel engines rated under 19 kW must be designed, built, and equipped to conform to applicable EPA regulations.

ISM must warrant the emission control system on your engine for that period of time listed below, provided there has been no abuse, neglect, or improper maintenance of your small non-road diesel engine.

Your California and EPA emission control system may include parts, such as, the fuel injection system and other emission- related assemblies.

Where a warrantable condition exists, GENERAC will repair your engine at no cost to you, including diagnosis, parts, and labor, on behalf of ISM. Although ISM is ultimately responsible for this warranty, GENERAC has agreed to carry out ISM's warranty repair responsibilities, and GENERAC should be your primary contact for emission-related warranty service.

MANUFACTURER'S WARRANTY COVERAGE

For 2000 and later small non-road diesel engines, first sold in California, and for 2000 and later non-road diesel engines rated under 19 kW, first sold in all other states, the applicable warranty period is two (2) years or 1,500 hours, whichever comes first.

If any emission-related part on your engine is defective, the part will be repaired or replaced by a Generac Authorized Warranty Service Facility on behalf of ISM.

PARTS COVERED

This emission control system warranty applies to the following engine emission control parts.

• Fuel Injection Pump

• Fuel Injectors

• Intake Manifold

• Exhaust Manifold

• Air Cleaner Element

• Miscellaneous Hoses, Bolts and Connectors

 

OWNER'S WARRANTY RESPONSIBILITIES

As the engine owner, you are responsible for the performance of the required maintenance listed in your Owner's Manual. GENERAC and ISM recommend that you retain the original purchase documentation and all receipts covering maintenance on your engine, but GENERAC and ISM cannot deny warranty solely for the lack of receipts or for your failure to ensure the performance of all scheduled maintenance.

As the engine owner, you should be aware, however, that GENERAC and ISM may deny you warranty coverage if your engine or a part has failed due to abuse, neglect, improper maintenance, or unapproved modifications.

You are responsible for contacting a Generac Authorized Warranty Service Facility as soon as a problem occurs. The warranty repairs should be completed in a reasonable amount of time, not to exceed 30 days.

Warranty Service can be arranged by contacting either your selling dealer or a Generac Authorized Warranty Service Facility. To locate the Generac Authorized Warranty Service Facility nearest you, call our toll-free number:

1-800-333-1322

If you have any questions regarding your warranty rights and responsibilities, you should contact GENERAC at the following address:

ATTENTION WARRANTY DEPARTMENT

GENERAC POWER SYSTEMS, INC.

211 MURPHY DRIVE

EAGLE, WI 53119

Page 1

64 Generac® Power Systems, Inc.

Page 65 Page 67
Image 66
Page 65 Page 67
Contents Power SYSTEMS, INC Authorized Service Dealer Location IntroductionPart II Installation Instructions General Hazards Electrical Hazards Generator Identification Quietpact 65DGenerator Applicability SafetySpecifications Generator AC Connection SystemFuel Consumption GAL/HR Engine OIL RequirementsGenerator Generator Control Panel Optional Remote START/STOPBefore Starting the Engine Starting the Generator Stopping the Generator Protection SystemsOvervoltage Protection Additional InformationOverspeed Shutdown 1 25-HOUR BREAK-IN PeriodOperation in High Grass or Brush Checking the Engine OIL LevelChanging the Engine OIL AND/OR OIL Filter Effects of Moisture and DirtServicing the Engine AIR Filter Spark Arrestor MufflerCleaning the Generator Battery MaintenanceEngine Coolant OUT-OF-SERVICE ProcedureCooling System Drive BeltReturn to Service Service Schedule SYSTEM/COMPONENT Procedure FrequencyPart General Hazards Electrical Hazards Equipment Description Purpose and Scope ManualStandards Booklets Generator Engine Operating SpeedMajor Features and Dimensions Generator Support Location and SupportGenerator Location Suspended MountingGenerator Compartments Generator RestraintCompartment Construction Sound Insulating Materials AcousticsCompartment Floor Cutouts Typical Noise AbatementCooling and Ventilating AIR Cooling AIR Inlet OpeningsGenerator Airflow Testing the Installation Diesel Fuel SystemCompensating for Restrictions Generator Fuel Supply Lines Generator Fuel Return LinesExhaust System Safety Exhaust SystemMuffler and Spark Arrestor Electrical Connections Electrical Junction BOXGenerator AC Connections Power Supply Cord Ground Fault Circuit InterruptersIsolating Different Power Sources Recommended Battery Battery InstallationBattery Cables Battery Cable ConnectionsOptional Accessories Battery CompartmentBefore Initial Startup Post Installation TestsTesting Under Load Initial StartInstallation Checklist Troubleshooting Guide Problem Cause CorrectionAppendix 2 Electrical Data Appendix 2 Electrical Data Appendix 2 Electrical Data Appendix 3 Exploded Views and Parts Lists QTY Description Base Frame Weldment 174 Appendix 3 Exploded Views and Parts Lists Cooling System Drawing No. D2360 1926 Exhaust Gasket Description QTY Start / Stop Switch Camshaft Assembly Complete Cylinder Block Cylinder Head Assembly Crankshaft Assembly Part NO. QTY Description Rocker ARM Shaft Injector Pump Assembly Fuel Filter Support Appendix 3 Exploded Views and Parts Lists HOUSING, Timing Gear 3114 Water Pump Assembly Appendix 4 Notes Appendix 4 Notes Manufacturers Warranty Coverage Federal and California Emissions Control Warranty StatementYour Warranty Rights and Obligations Parts CoveredObtaining Warranty Service Obligations and Rights of the Manufacturer and OwnerLimitations Generac Power SYSTEMS, INC
Top Page Image Contents