Monessen Hearth HBDV300N/PV7, HBDV400N/PSC7, HBDV400N/PV7, HBDV300N/PSC7 manual On next

Page 36

HBDV7 Series Direct Vent Gas Fireplace OPERATING INSTRUCTIONS - SIGNATURE COMMAND

for your safety read before lighting

WARNING

If you do not follow these instructions exactly, a fire or explosion may result causing property damage, personal injury or loss of lie.

A.This appliance is equipped with an ignition device which automatically lights the pilot. Refer to the instructions.

B.BEFORE OPERATING smell all around the appliance area for gas. Be sure to smell next to the floor because some gas is heavier than air and will settle on the floor.

WHAT TO DO IF YOU SMELL GAS:

Do not attempt to light any appliance.

Do not touch any electric switch; do not use any phone in your building.

Immediately call your gas supplier from a neighbor's phone. Follow the gas supplier's instructions.

If you cannot reach your gas supplier, call the fire department.

C.Use only your finger to push in the master switch. Never use tools. If the switch will not func- tion by hand, do not try to repair it. Call a qualified service technician. Force or attempted repair may result in a fire or explosion.

D.Do not use this appliance if any part of it has been under water. Immediately call a qualified service technician to inspect the appliance and to replace any part of the control system and any gas control that has been under water.

continued on next page

36

54D8000

Image 36
Contents HBDV7 Series Direct Vent Gas Fireplace Pre-Installation Information Check Gas Pressure Signature Command SystemMassachusetts Residents Only Important Safety Information InstallerOwner Please Read the Following Carefully Never connect unit to private nonKnown as wellhead gas Code ApprovalProduct Specifications High ElevationsFraming Dimensions HBDV300 HBDV400PRE-INSTALLATION Information Firebox framingFireplace Location Cold Climate InsulationClearances to combustibles Mantel ClearancesNever obstruct or modify the air inlet or Outlet grilles louvers. This may create aSecure Fireplace to Floor or Framing Finishing MaterialOptional top vent application Optional TOP Vent ApplicationVenting Installation Information Installation precautionsGeneral Venting Canadian Installations1 US Installations2 General Venting Information Termination LocationUSA Installations Canadian InstallationsTermination Clearances How to Use the Vent Graph Twist Lock PipesRefer to Page 21 for requirements for snorkels Vent Installation 1219 mmRear Wall Vent Installation Twist Lock Pipe Rear Wall Vent ApplicationStep Rear Wall Vent Installations Flex Vent Pipe Vent configurations apply and must be strictly adhered toTop vent Sidewall Application + B = 17 Max Venting Installation Vertical Sidewall Installation Twist Lock PipeAlways install horizontal venting on a level plane Vertical Sidewall installation flex vent pipe Install the 4 flex then 7 flex to the terminationBelow Grade Installations Vertical THROUGH-THE-ROOF APPLICA- TionDo not back fill around snorkel Vertical THROUGH-THE-ROOF Installation Roof Flashing Install gas piping to fireplace / burner system location Check gas typeFireplace Installation Natural GasPropane/LP Millivolt Check GAS Pressure and Electrical installation Electrical WiringDo not use open flame to check for gas LeaksElectrical Installation Remote Wall mounted SwitchRemote Wall Switch Optional DC Remote SystemsWhat to do if YOU Smell GAS Initial lightingNever use an open flame to check for gas leak Approved leak testing method Operating Instructions MillivoltNever check for gas leak with open FlameMain burner switch Lighting the burnerPilot position Optional Accessory Requirements Electrician. Main power must be off whenConnecting to main electrical power supply Or performing service. All wiring shall beJunction BOX Wiring Command Center Wall InstallationWall Switch Installation Nected together if a wall switch is not Being used Blotsc Signature Command Blower Optional FAN Blower Systems Blot Automatic Thermostat BlowerFK-12 Manual Blower On next Operating Instructions Signature Command Command CenterFeatures Battery InstallationCommand Center Key Combinations for System Settings Function Operation Default SettingCommand Center Operations Self Diagnostics ChartFUNCTIONS/OPERATION Function OperationBrick installation Glass RemovalGlass Frame Removal Placement of Lava ROCK, Rock Wool and Logs Do not sprinkle the lava rock or emberPotential sooting, glass breakage and a fire HazardFinal Installation Left Front Log #6 Installing Universal Andirons Burner, Pilot and Control Compart- ment Vent SysteM Glass DoorLogs Rock woolSymptom Possible Cause Action Standing Pilot IgnitionTroubleshooting Signature Command System Replacement Parts Firebox ComponentsFirebox components Description QtyStanding Pilot Millivolt Control Accessories Fuel Conversion Kits Natural Gas to LPLP to Natural Gas Signature Command System HBDV300NSC7 HBDV300PSC7 HBDV400NSC7 HBDV400PSC7 Replacement Parts LogsDescription Qty Vertical Venting Description Model NumberHorizontal Venting 7TBLSCTKHBDV7 Series Direct Vent Gas Fireplace HBDV7 Series Direct Vent Gas Fireplace Carbon Monoxide Detector Requirements Lifetime Warranty Five Year WarrantyBasic Warranty If Warranty Service is NeededMhsc Model EnerGuide Ratings Fireplace Efficiency %