Hoshizaki FD-1001MAH(-C), FD-1001MRH(-C), FD-1001MLH(-C) Stacking Remote Condenser Units

Page 22

6.Stacking Remote Condenser Units

1)Install the lower remote condenser unit as described earlier in this section.

2)Place the upper remote condenser unit on top of the lower. See Fig. 10.

3)Secure the upper remote condenser unit to the lower remote condenser unit with the 4 screws provided.

4)Install refrigerant lines and make electrical connection as described earlier in this section.

Upper Remote

Condenser Unit

Screws Screws

Lower Remote

Condenser Unit

Fig. 10

22

Image 22
Contents Superior Degree Reliability Hoshizaki AMERICA, INC Contents Page Indicates important information about the use and care Important Safety InformationSerious injury UnitSpecifications Nameplate Rating FD-1001MAH-C air-cooledFD-1001MWH-C water-cooled FD-1001MRH-C remote air-cooled FD-1001MLH-C low-side, parallel rack system Dimensions / Connections FD-1001MWH-C water-cooled FD-1001MRH-C remote air-cooled FD-1001MLH-C low side, parallel rack system How to Remove Panels II. Installation and Operating InstructionsChecks Before Installation See FigSetup LocationFor All Models Electrical ConnectionAdditional Warnings for Remote Air-Cooled Model Checks Before Installation Installation of Remote Condenser UnitLocation Setup Line SetField Fabricated Line Set Installation Polyol Ester POE OIL Electrical Connection Stacking Remote Condenser Units Line Set Installation Connection to an R-404A Parallel Rack SystemRack System-Braze Connection Entire Male Fitting Water Supply and Drain Connections See , 15, orFD-1001MAH-C FD-1001MRH-C FD-1001MLH-C IcemakerTo a Potable FD-1001MWH-C CondenserConnection Water SupplyConnection to FD-1001MWH-CClosed Loop Final Checklist Startup Bin Control Check Infrared Sensor CheckThumbscrew Infrared Sensor Housing Lens Mechanical Backup Bin Control Check Infrared Sensor Shutdown Delay Seconds 1.6 minutesCleaning Solution III. Cleaning and MaintenanceCleaning and Sanitizing Instructions Cleaning ProcedureFloat Switch Assembly Reservoir Cover Infrared Sensor Infrared Sensor Housing Lens Sanitizing Solution Sanitizing Procedure InitialSanitizing Procedure Final Maintenance Frequency Area TaskRemove the water from the icemaker water supply line Preparing the Icemaker for Long StorageDrain the evaporator Page Hoshizaki AMERICA, INC